Passive cooling of standalone flat PV module with cotton wick structures

Abstract In common, PV module converts only 4–17% of the incoming solar radiation into electricity. Thus more than 50% of the incident solar energy is converted as heat and the temperature of PV module is increased. The increase in module temperature in turn decreases the electrical yield and efficiency of the module with a permanent structural damage of the module due to prolonged period of thermal stress (also known as thermal degradation of the module). An effective way of improving efficiency and reducing the rate of thermal degradation of a PV module is to reduce the operating temperature of PV module. This can be achieved by cooling the PV module during operation. Hence in the present work, a simple passive cooling system with cotton wick structures is developed for standalone flat PV modules. The thermal and electrical performance of flat PV module with cooling system consisting of cotton wick structures in combination with water, Al2O3/water nanofluid and CuO/water nanofluid are investigated experimentally. The experimental results are also compared with the thermal and electrical performance of flat PV module without cooling system.

[1]  Mohammad Nurul Alam Hawlader,et al.  An active cooling system for photovoltaic modules , 2012 .

[2]  M. Chandrasekar,et al.  Experimental studies on heat transfer and friction factor characteristics of CuO/water nanofluid under turbulent flow in a helically dimpled tube , 2011 .

[3]  Y. Tripanagnostopoulos,et al.  Performance improvement of PV/T solar collectors with natural air flow operation , 2008 .

[4]  Christopher Dey,et al.  Design of a jet impingement cooling device for densely packed PV cells under high concentration , 2007 .

[5]  Bin Zhu,et al.  Energy Management of Stand-alone Hybrid PV System , 2011 .

[6]  Zifeng Yuan,et al.  Simulation and experimental validation of heat transfer in a novel hybrid solar panel , 2012 .

[7]  Saffa Riffat,et al.  Theoretical study of the performance of a novel PV/e roof module for heat pump operation , 2011 .

[8]  D. L. Evans,et al.  Simplified method for predicting photovoltaic array output , 1980 .

[9]  S. Suresh,et al.  Experimental investigations and theoretical determination of thermal conductivity and viscosity of Al2O3/water nanofluid , 2010 .

[10]  Jie Ji,et al.  Experimental study of photovoltaic solar assisted heat pump system , 2008 .

[11]  Bin-Juine Huang,et al.  PERFORMANCE EVALUATION OF SOLAR PHOTOVOLTAIC / THERMAL SYSTEMS , 2001 .

[12]  S. Krauter.  Increased electrical yield via water flow over the front of photovoltaic panels , 2004 .

[13]  Tin-Tai Chow,et al.  A Review on Photovoltaic/Thermal Hybrid Solar Technology , 2010, Renewable Energy.

[14]  Laura Schaefer,et al.  System simulation of a linear concentrating photovoltaic system with an active cooling system , 2012 .

[15]  Soteris A. Kalogirou,et al.  Hybrid PV/T solar systems for domestic hot water and electricity production , 2006 .

[16]  Li Zhu,et al.  Heat dissipation performance of silicon solar cells by direct dielectric liquid immersion under intensified illuminations , 2011 .

[17]  Karl W. Böer,et al.  Cadmium sulfide enhances solar cell efficiency , 2011 .

[18]  Masud Behnia,et al.  Improving Photovoltaic Module Efficiency Using Water Cooling , 2009 .

[19]  C. Dey,et al.  Cooling of photovoltaic cells under concentrated illumination: a critical review , 2005 .

[20]  Arvind Tiwari,et al.  Parametric study of various configurations of hybrid PV/thermal air collector: Experimental validation of theoretical model , 2007 .

[21]  Gilles Notton,et al.  Calculation of the polycrystalline PV module temperature using a simple method of energy balance , 2006 .

[22]  Jie Ji,et al.  Hybrid photovoltaic-thermosyphon water heating system for residential application , 2006 .

[23]  Gilles Notton,et al.  Modelling of a double-glass photovoltaic module using finite differences , 2005 .

[24]  Xingxing Zhang,et al.  Review of R&D progress and practical application of the solar photovoltaic/thermal (PV/T) technologies. , 2012 .

[25]  H. P. Garg,et al.  SOME ASPECTS OF A PV/T COLLECTOR/FORCED CIRCULATION FLAT PLATE SOLAR WATER HEATER WITH SOLAR CELLS , 1995 .

[26]  E. Radziemska,et al.  Thermally affected parameters of the current–voltage characteristics of silicon photocell , 2002 .

[27]  Li Zhu,et al.  The performance and long-term stability of silicon concentrator solar cells immersed in dielectric liquids , 2013 .

[28]  Y. Tripanagnostopoulos,et al.  Hybrid photovoltaic/thermal solar systems , 2002 .