Petroleum pollution sensing at ppb level using quartz crystal resonators sputtered with porous polyethylene under photo-excitation

Abstract Radio-frequency (r.f.) sputtering of a porous polyethylene (PE) disk made by sintering PE granules can be used to form hydrocarbon-polymer films applied as the chemical-sensing overlayers of quartz crystal resonator sensors that can detect petroleum hydrocarbon vapors at low parts-per-billion (ppb) levels. The vapor-sorption capabilities of these films are profoundly affected by the sputtering method used; they are enhanced by photo-excitation through irradiation using ultraviolet (UV) light, and reduced by carbonization induced by long-term processing or by water-treatment. The PE films, especially photo-excited PE film, are characterized by a smooth surface, a high atomic density with a high hydrogen content, and dangling-bond longevity. Photo-excited PE film are capable of detecting linear hydrocarbon (>C 12 ) vapors below the ppb level. Pre-sorption with water vapor at 9% relative humidity (RH) can enhance the sensing abilities of sensors for petroleum hydrocarbons. The effect of this water treatment on petroleum hydrocarbon sorption is especially prominent for d -phenylalanine-sputtered film.

[1]  A. Bell,et al.  Structural Characterization of Plasma-Polymerized Hydrocarbons , 1976 .

[2]  J. Fortuin.  Low constant vapour concentrations obtained by a dynamic method based on diffusion , 1956 .

[3]  Irving Langmuir.  THE CONSTITUTION AND FUNDAMENTAL PROPERTIES OF SOLIDS AND LIQUIDS. PART I. SOLIDS. , 1916 .

[4]  R. C. Weast.  CRC Handbook of Chemistry and Physics , 1973 .

[5]  S. Kondo,et al.  Plasma-Induced Surface Radicals of Low-Density Polyethylene Studied by Electron Spin Resonance1 , 1998 .

[6]  H. Schlitt,et al.  Concentrations of selected organic pollutants in indoor and outdoor air in Northern Italy , 1986 .

[7]  Alexis T. Bell,et al.  Plasma Polymerization of Saturated and Unsaturated Hydrocarbons , 1974 .

[8]  G. Lugg,et al.  Diffusion coefficients of some organic and other vapors in air , 1968 .

[9]  J. Israelachvili.  Intermolecular and surface forces , 1985 .

[10]  Y. Ishikawa,et al.  Self-assembly of bilayer membranes in organic solvents by novel amphiphilic compounds , 1989 .

[11]  H. Kuwano,et al.  Organic Gas Sorption Characteristics of Plasma-Deposited Amino Acid Films , 1994 .

[12]  H. Kuwano,et al.  Chemical Sensing System Using Plasma Polymer Films and Pattern Recognition Algorithm , 1994 .

[13]  M. Kuzuya,et al.  Nature of plasma-induced surface radicals of powdered polyethylene studied by electron spin resonance , 1993 .

[14]  A. Hodgson.  A Review and a Limited Comparison of Methods for Measuring Total Volatile Organic Compounds in Indoor Air , 1995 .