The participation of bound chloride in passive film breakdown on steel in concrete

Abstract It is well known that solid calcium hydroxide may act to inhibit chloride induced corrosion of steel in concrete. This hypothesis has been recently extended to include the inhibitive and aggressive nature of other solids that exhibit pH dependent dissolution behaviour. Concrete constituents that resist a local fall in pH may inhibit corrosion, while bound chloride released by such a fall may participate in corrosion initiation. In this work the pH dependent solubility of chloride in concrete is demonstrated. It is shown that most of the bound chloride is released as the result of the rapid dissolution of at least two hydrated phases in chloride contaminated OPC concrete. This occurs at pH values that are high (above 11.5) compared to that considered necessary to sustain local passive film breakdown at the site of a nucleating pit. Thus, in theory, the corrosion risk presented by bound chloride at the steel–concrete interface may be very similar to that presented by free chloride.

[1]  C. L. Page,et al.  Investigations of reinforcement corrosion. 2. Electrochemical monitoring of steel in chloride-contaminated concrete , 1991 .

[2]  G. Glass,et al.  Corrosion inhibition in concrete arising from its acid neutralisation capacity , 2000 .

[3]  O. A. Kayyali,et al.  THE C1-/OH- RATIO IN CHLORIDE-CONTAMINATED CONCRETE - A MOST IMPORTANT CRITERION , 1995 .

[4]  F. P. Glasser,et al.  Friedel’s salt, Ca2Al(OH)6(Cl,OH)·2H2O: its solid solutions and their role in chloride binding , 1998 .

[5]  Stuart Lyon,et al.  CORROSION OF REINFORCEMENT STEEL EMBEDDED IN HIGH WATER-CEMENT RATIO CONCRETE CONTAMINATED WITH CHLORIDE , 1998 .

[6]  Nick R. Buenfeld,et al.  Neural network modelling of chloride binding , 1997 .

[7]  M. Pourbaix.  Thermodynamics and corrosion , 1990 .

[8]  Fredrik P. Glasser,et al.  A thermodynamic model for blended cements , 1992 .

[9]  A. K. Suryavanshi,et al.  The binding of chloride ions by sulphate resistant portland cement , 1995 .

[10]  P B Bamforth,et al.  AN INTERNATIONAL REVIEW OF CHLORIDE INGRESS INTO STRUCTURAL CONCRETE , 1997 .

[11]  Nick R. Buenfeld,et al.  Differential acid neutralisation analysis , 1999 .

[12]  G. Glass,et al.  The presentation of the chloride threshold level for corrosion of steel in concrete , 1997 .

[13]  M. H. Roberts,et al.  Effect of calcium chloride on the durability of pre-tensioned wire in prestressed concrete , 1962 .

[14]  K. Tuutti.  Corrosion of steel in concrete , 1982 .

[15]  P. Francis,et al.  The Use of Synthetic Environments for Corrosion Testing , 1988 .

[16]  C. Page.  Mechanism of corrosion protection in reinforced concrete marine structures , 1975, Nature.

[17]  G. T. Burstein.  Revealing corrosion pits , 1991, Nature.

[18]  G. Glass,et al.  The influence of chloride binding on the chloride induced corrosion risk in reinforced concrete , 2000 .

[19]  Josef Tritthart,et al.  Chloride binding in cement II. The influence of the hydroxide concentration in the pore solution of hardened cement paste on chloride binding , 1989 .

[20]  C. Page,et al.  Corrosion of reinforcement in concrete , 1990 .