High Enthalpy Studies of Capsule Heating in an Expansion Tunnel Facility

Measurements were made on an Orion heat shield model to demonstrate the capability of the new LENS-XX expansion tunnel facility to make high quality measurements of heat transfer distributions at flow velocities from 3 km/s (h(sub 0) = 5 MJ/kg) to 8.4 km/s (h(sub 0) = 36 MJ/kg). Thirty-nine heat transfer gauges, including both thin-film and thermocouple instruments, as well as four pressure gauges, and high-speed Schlieren were used to assess the aerothermal environment on the capsule heat shield. Only results from laminar boundary layer runs are reported. A major finding of this test series is that the high enthalpy, low-density flows displayed surface heating behavior that is observed to be consistent with some finite-rate recombination process occurring on the surface of the model. It is too early to speculate on the nature of the mechanism, but the response of the gages on the surface seems generally repeatable and consistent for a range of conditions. This result is an important milestone in developing and proving a capability to make measurements in a ground test environment and extrapolate them to flight for conditions with extreme non-equilibrium effects. Additionally, no significant, isolated stagnation point augmentation ("bump") was observed in the tests in this facility. Cases at higher Reynolds number seemed to show the greatest amount of overall increase in heating on the windward side of the model, which may in part be due to small-scale particulate.

[1]  M. Maclean,et al.  Analysis and Ground Test of Aerothermal Effects on Spherical Capsule Geometries , 2008 .

[2]  Graham V. Candler,et al.  The solution of the Navier-Stokes equations using Gauss-Seidel line relaxation , 1989 .

[3]  Richard A. Thompson,et al.  A review of reaction rates and thermodynamic and transport properties for the 11-species air model for chemical and thermal nonequilibrium calculations to 30000 K , 1989 .

[4]  P. V. Marrone,et al.  Chemical Relaxation with Preferential Dissociation from Excited Vibrational Levels , 1963 .

[5]  Chul Park,et al.  Assessment of two-temperature kinetic model for ionizing air , 1987 .

[6]  H. Lomax,et al.  Thin-layer approximation and algebraic model for separated turbulent flows , 1978 .

[7]  C. Park,et al.  Nonequilibrium Hypersonic Aerothermodynamics , 1989 .

[8]  William L. Oberkampf,et al.  Guide for the verification and validation of computational fluid dynamics simulations , 1998 .

[9]  Robert L. Trimpi,et al.  A Preliminary Theoretical Study of the Expansion Tube, a New Device for Producing High-Enthalpy Short-Duration Hypersonic Gas Flows , 1962 .

[10]  Roger C. Millikan,et al.  Systematics of Vibrational Relaxation , 1963 .

[11]  Graham V. Candler,et al.  Review of Chemical-Kinetic Problems of Future NASA Missions, II: Mars Entries , 1993 .

[12]  Grant Palmer,et al.  A Comparison of Methods to Compute High-Temperature Gas Thermal Conductivity , 2003 .

[13]  Matthew MacLean,et al.  Experimental Characterization of the LENS Expansion Tunnel Facility Including Blunt Body Surface Heating , 2011 .

[14]  Chul Park,et al.  Operating Characteristics of a 60- and 10-cm Electric Arc-Driven Shock Tube—Part I: The Driver , 1990 .

[15]  James Brown,et al.  Turbulence Model Validation for Hypersonic Flows , 2002 .

[16]  Ann L Gaitonde,et al.  49th AIAA Aerospace Sciences Meeting, Orlando , 2011 .

[17]  G. Candler,et al.  Thermal rate constants of the O2+N→NO+O reaction based on the A2′ and A4′ potential-energy surfaces , 1997 .

[18]  M. Maclean,et al.  Numerical Assessment of Data in Catalytic and Transitional Flows for Martian Entry , 2006 .

[19]  Aaron T. Dufrene,et al.  Effect of Surface Catalysis on Measured Heat Transfer in an Expansion Tunnel Facility , 2012 .

[20]  Grant Palmer,et al.  Comparison of methods to compute high-temperature gas viscosity , 2002 .

[21]  Holden,et al.  Experimental Studies of the Aerothermal Characteristics of the Project Orion CEV heat Shield in High Speed Transitional and Turbulent Flows , 2009 .

[22]  F. Menter.  Two-equation eddy-viscosity turbulence models for engineering applications , 1994 .

[23]  Christopher J. Roy,et al.  Grid Convergence Error Analysis for Mixed-Order Numerical Schemes , 2001 .

[24]  D. Driver,et al.  Finite-Rate Surface Chemistry Model, II: Coupling to Viscous Navier-Stokes Code , 2011 .

[25]  Peter A. Jacobs,et al.  Superorbital expansion tube operation: Estimates of flow conditions via numerical simulation , 2005 .

[26]  J. Marschall,et al.  Finite-Rate Surface Chemistry Model, I: Formulation and Reaction System Examples , 2011 .

[27]  John I. Erdos,et al.  Dual Mode Shock-Expansion/Reflected-Shock Tunnel , 1997 .

[28]  Timothy Wadhams,et al.  Characterization of the New LENS Expansion Tunnel Facility , 2010 .

[29]  Joanna Austin,et al.  Design and Characterization of a Hypervelocity Expansion Tube Facility , 2007 .

[30]  G. Candler,et al.  Data-Parallel Line Relaxation Method for the Navier -Stokes Equations , 1998 .

[31]  Chul Park,et al.  Operating characteristics of a 60- and 10-cm electric arc-driven shock tube. I - The driver. II - The driven section , 1990 .

[32]  John D. Ramshaw,et al.  Self-Consistent Effective Binary Diffusion in Multicomponent Gas Mixtures , 1990 .

[33]  M. Wright,et al.  Recommended Collision Integrals for Transport Property Computations Part 1: Air Species , 2005 .

[34]  S. A. Losev,et al.  Relaxation Processes in Shock Waves , 1967 .

[35]  Hsien K. Cheng,et al.  Boundary-Layer Displacement and Leading-Edge Bluntness Effects in High-Temperature Hypersonic Flow , 1961 .

[36]  Graham V. Candler,et al.  Thermal rate constants of the N 2 +O→NO+N reaction using ab initio 3 A″ and 3 A' potential energy surfaces , 1996 .

[37]  B. Aupoix,et al.  Improved Turbulence Models For Compressible Boundary Layers , 1998 .

[38]  Timothy Wadhams,et al.  Numerical and Experimental Characterization of High Enthalpy Flow in an Expansion Tunnel Facility , 2010 .

[39]  M. Bonnefoy,et al.  37th AIAA Thermophysics Conference , 2004 .

[40]  P. Spalart.  A One-Equation Turbulence Model for Aerodynamic Flows , 1992 .