An experimental study of flow friction and heat transfer in wavy microchannels with rectangular cross section

Abstract Experimental investigation has been conducted on the flow friction and heat transfer in sinusoidal microchannels with rectangular cross sections. The microchannels considered consist of ten identical wavy units with average width of about 205 μm, depth of 404 μm, wavelength of 2.5 mm and wavy amplitude of 0–259 μm. Each test piece is made of copper and contains 60–62 wavy microchannels in parallel. Deionized water is employed as the working fluid and the Reynolds numbers considered range from about 300 to 800. The experimental results, mainly the overall Nusselt number and friction factor, for wavy microchannels are compared with those of straight baseline channels with the same cross section and footprint length. It is found that the heat transfer performance of the present wavy microchannels is much better than that of straight baseline microchannels; at the same time the pressure drop penalty of the present wavy microchannels can be much smaller than the heat transfer enhancement. Conjugate simulation based on the classical continuum approach is also carried out for similar experimental conditions, the numerical results agree reasonably well with experimental data.

[1]  Ibrahim Hassan,et al.  MICROCHANNEL HEAT SINKS: AN OVERVIEW OF THE STATE-OF-THE-ART , 2004 .

[2]  Arun S. Mujumdar,et al.  Thermal characteristics of tree-shaped microchannel nets with/without loops , 2009 .

[3]  Raj M. Manglik,et al.  Low Reynolds number forced convection in three-dimensional wavy-plate-fin compact channels: fin density effects , 2005 .

[4]  J. Masliyah,et al.  Fully developed viscous flow and heat transfer in curved semicircular sectors , 1979 .

[5]  Kukjin Chun,et al.  Analysis of laminar convective heat transfer in micro heat exchanger for stacked multi-chip module , 2005 .

[6]  Steffen Hardt,et al.  Simulation of helical flows in microchannels , 2004 .

[7]  S. Garimella,et al.  Investigation of Liquid Flow in Microchannels , 2002 .

[8]  J. Taylor.  An Introduction to Error Analysis , 1982 .

[9]  S. Garimella,et al.  Thermally Developing Flow and Heat Transfer in Rectangular Microchannels of Different Aspect Ratios , 2006 .

[10]  Satish G. Kandlikar,et al.  Evaluation of Single Phase Flow in Microchannels for High Heat Flux Chip Cooling—Thermohydraulic Performance Enhancement and Fabrication Technology , 2004 .

[11]  David F. Fletcher,et al.  Thermohydraulics of square-section microchannels following a serpentine path , 2006 .

[12]  Arun S. Mujumdar,et al.  Numerical investigation of laminar heat transfer performance of various cooling channel designs , 2011 .

[13]  David F. Fletcher,et al.  Laminar flow and heat transfer in a periodic trapezoidal channel with semi-circular cross-section , 2006 .

[14]  H. Aref.  Stirring by chaotic advection , 1984, Journal of Fluid Mechanics.

[15]  W. Choi,et al.  Experimental investigation of flow friction for liquid flow in microchannels , 2000 .

[16]  M. A. Ebadian,et al.  Laminar forced convection in a helicoidal pipe with finite pitch , 1995 .

[17]  S. Garimella,et al.  Investigation of heat transfer in rectangular microchannels , 2005 .

[18]  David F. Fletcher,et al.  Low-Reynolds number heat transfer enhancement in sinusoidal channels , 2007 .

[19]  Tianliang Yang,et al.  Bifurcation and stability of forced convection in curved ducts of square cross-section , 2004 .

[20]  David F. Fletcher,et al.  Laminar Flow and Heat Transfer in a Periodic Serpentine Channel , 2005 .

[21]  R. Shah.  Laminar Flow Forced convection in ducts , 1978 .

[22]  Yogendra Joshi,et al.  PARAMETRIC NUMERICAL STUDY OF FLOW AND HEAT TRANSFER IN MICROCHANNELS WITH WAVY WALLS , 2011 .

[23]  R. M. Manglik,et al.  Enhanced heat transfer due to curvature-induced lateral vortices in laminar flows in sinusoidal corrugated-plate channels , 2004 .

[24]  R. Pease,et al.  High-performance heat sinking for VLSI , 1981, IEEE Electron Device Letters.

[25]  I. Mudawar,et al.  Experimental and numerical study of pressure drop and heat transfer in a single-phase micro-channel heat sink , 2002 .

[26]  J. D. Seader,et al.  Heat and mass transfer phenomena for viscous flow in curved circular tubes , 1972 .

[27]  F. Gerner,et al.  Developing convective heat transfer in deep rectangular microchannels , 1999 .

[28]  Steffen Hardt,et al.  Helical Flows and Chaotic Mixing in Curved Micro Channels , 2004 .

[29]  B. W. Webb,et al.  Characterization of frictional pressure drop for liquid flows through microchannels , 2002 .

[30]  T. Newell,et al.  An experimental study of flow and heat transfer in sinusoidal wavy passages , 1999 .

[31]  V. Narayanan,et al.  Optimization of fractal-like branching microchannel heat sinks for single-phase flows , 2010 .

[32]  David M. Pfund,et al.  Thermal Measurements in Rectangular Microchannels , 2002 .

[33]  C. Shu,et al.  Fluid flow and heat transfer in wavy microchannels , 2010 .

[34]  S. Garimella,et al.  TRANSPORT IN MICROCHANNELS - A CRITICAL REVIEW , 2003 .