Further examination of polysaccharides causing membrane fouling in membrane bioreactors (MBRs): Application of lectin affinity chromatography and MALDI-TOF/MS.

Membrane fouling remains a major obstacle for wider application of membrane bioreactors (MBRs) to wastewater treatment. Polysaccharides in mixed liquor suspensions in the reactors are thought to be mainly responsible for the evolution of membrane fouling in MBRs. However, details of polysaccharides causing membrane fouling in MBRs are still unknown. In this study, polysaccharides in a mixed liquor suspension of a pilot-scale MBR treating municipal wastewater were fractionated by using lectins, special proteins that bind to specific polysaccharides depending on their properties. Fouling potentials of the fractionated polysaccharides were assessed by bench-scale dead-end filtration tests. It was clearly shown that the degrees of fouling caused by fractionated polysaccharides were significantly different. The amounts of polysaccharides in each fraction could not explain the variations in the fouling, indicating the presence of polysaccharides with high specific fouling potentials. To investigate structures and origins of the polysaccharides with high fouling potentials, matrix-assisted laser desorption/ionization (MALDI)-time of flight (TOF)/mass spectrometry (MS) analysis was applied to the fractionated polysaccharides after partial hydrolysis. Several mass peaks obtained could be assigned to fragments of structures of polysaccharides (i.e., oligosaccharides) reported in a database/literature. This is the first report showing the plausible structures of polysaccharides in MBRs based on MS. A deeper understanding and effective control of membrane fouling in MBRs could be achieved with information obtained by the approach used in this study.

[1]  K. Xiao,et al.  Combined effect of membrane and foulant hydrophobicity and surface charge on adsorptive fouling duri , 2011 .

[2]  K. Keiding,et al.  Extraction of extracellular polymers from activated sludge using a cation exchange resin , 1996 .

[3]  Y Watanabe,et al.  Fouling potentials of polysaccharides in membrane bioreactors (MBRs) assessed by lectin affinity chromatography. , 2010, Water science and technology : a journal of the International Association on Water Pollution Research.

[4]  J. Gallagher,et al.  Carbohydrate-binding properties of lectins: A possible approach to lectin nomenclature and classification , 1984, Bioscience reports.

[5]  Michel Y. Jaffrin,et al.  Contribution of various constituents of activated sludge to membrane bioreactor fouling , 2000 .

[6]  David C. Stuckey,et al.  A REVIEW OF SOLUBLE MICROBIAL PRODUCTS (SMP) IN WASTEWATER TREATMENT SYSTEMS , 1999 .

[7]  Yoshimasa Watanabe,et al.  The difference in characteristics of foulants in submerged MBRs caused by the difference in the membrane flux , 2008 .

[8]  G. Amy,et al.  Toward a better identification of foulant species in MBR processes , 2008 .

[9]  I. Sutherland.  2.16 – Bacterial Exopolysaccharides , 2007 .

[10]  F. Smith,et al.  COLORIMETRIC METHOD FOR DETER-MINATION OF SUGAR AND RELATED SUBSTANCE , 1956 .

[11]  Yoshimasa Watanabe,et al.  Membrane fouling in pilot-scale membrane bioreactors (MBRs) treating municipal wastewater. , 2005, Environmental science & technology.

[12]  J. Chmelík,et al.  Determination of neutral oligosaccharides in vegetables by matrix-assisted laser desorption/ionization mass spectrometry , 2004 .

[13]  R. Cummings,et al.  [18] Lectin affinity chromatography of glycopeptides , 1987 .

[14]  Pierre Le-Clech,et al.  Fouling in membrane bioreactors used in wastewater treatment , 2006 .

[15]  D. Bagley,et al.  A Review of Biofouling and its Control in Membrane Separation Bioreactors , 2004, Water environment research : a research publication of the Water Environment Federation.

[16]  J. Tay,et al.  Staining of extracellular polymeric substances and cells in bioaggregates , 2007, Applied Microbiology and Biotechnology.

[17]  D. Violleau,et al.  Characterization and copper binding of humic and nonhumic organic matter isolated from the South Platte River: evidence for the presence of nitrogenous binding site. , 2003, Environmental science & technology.

[18]  F. Fan,et al.  Identification of wastewater sludge characteristics to predict critical flux for membrane bioreactor processes. , 2006, Water research.

[19]  M. Ferrando,et al.  Microfiltration of protein/dextran/polyphenol solutions: Characterization of fouling and chemical cleaning efficiency using confocal microscopy , 2009 .

[20]  Yoshimasa Watanabe,et al.  Changes in characteristics of soluble microbial products in membrane bioreactors associated with different solid retention times: Relation to membrane fouling. , 2009, Water research.

[21]  Thomas Melin,et al.  Polymeric compounds in activated sludge supernatant -- Characterisation and retention mechanisms at a full-scale municipal membrane bioreactor. , 2007, Water research.

[22]  C. Forster,et al.  A further examination into the composition of activated sludge surfaces in relation to their settlement characteristics , 1985 .

[23]  T. Endo.  Fractionation of glycoprotein-derived oligosaccharides by affinity chromatography using immobilized lectin columns. , 1996, Journal of chromatography. A.

[24]  Hiroaki Nakagawa,et al.  High-throughput protein glycomics: combined use of chemoselective glycoblotting and MALDI-TOF/TOF mass spectrometry. , 2004, Angewandte Chemie.

[25]  Tom Stephenson,et al.  Biomass characteristics and membrane aeration: toward a better understanding of membrane fouling in submerged membrane bioreactors (MBRs). , 2005, Biotechnology and bioengineering.

[26]  F. Meng,et al.  Comparison of membrane fouling during short-term filtration of aerobic granular sludge and activated sludge. , 2007, Journal of environmental sciences.

[27]  Anja Drews,et al.  Membrane fouling in membrane bioreactors—Characterisation, contradictions, cause and cures , 2010 .

[28]  A. Drews,et al.  Recent advances in membrane bioreactors (MBRs): membrane fouling and membrane material. , 2009, Water research.

[29]  D. Jenkins,et al.  The effect of organic loading on process performance and membrane fouling in a submerged membrane bioreactor treating municipal wastewater. , 2006, Water research.

[30]  Say Leong Ong,et al.  Membrane fouling of submerged membrane bioreactors: impact of mean cell residence time and the contributing factors. , 2006, Environmental science & technology.

[31]  G Amy,et al.  Impact of colloidal and soluble organic material on membrane performance in membrane bioreactors for municipal wastewater treatment. , 2006, Water research.

[32]  Simon Judd,et al.  Membrane Fouling in Membrane Bioreactors for Wastewater Treatment , 2002 .

[33]  Y. Watanabe,et al.  Bacterial community structures in MBRs treating municipal wastewater: relationship between community stability and reactor performance. , 2007, Water research.

[34]  Yoshimasa Watanabe,et al.  Difference in membrane fouling in membrane bioreactors (MBRs) caused by membrane polymer materials , 2006 .

[35]  El Hani Bouhabila,et al.  Fouling characterisation in membrane bioreactors , 2001 .

[36]  P. Wilderer,et al.  Composition and Distribution of Extracellular Polymeric Substances in Aerobic Flocs and Granular Sludge , 2005, Applied and Environmental Microbiology.