Effects of channel dimension, heat flux, and mass flux on flow boiling regimes in microchannels

Abstract Experiments are conducted with a perfluorinated dielectric fluid, Fluorinert FC-77, to investigate the effects of channel size and mass flux (225–1420 kg/m2s) on microchannel flow boiling regimes by means of high-speed photography. Seven different silicon test pieces with parallel microchannels of widths ranging from 100 to 5850 μm, all with a depth of 400 μm, are considered. Flow visualizations are performed with a high-speed digital video camera while local measurements of the heat transfer coefficient are simultaneously obtained. The visualizations and the heat transfer data show that flow regimes in the microchannels of width 400 μm and larger are similar, with nucleate boiling being dominant in these channels over a wide range of heat flux. In contrast, flow regimes in the smaller microchannels are different and bubble nucleation at the walls is suppressed at a relatively low heat flux for these sizes. Two types of flow regime maps are developed and the effects of channel width on the flow regime transitions are discussed.

[1]  Y. Zohar,et al.  Forced convection boiling in a microchannel heat sink , 2001 .

[2]  A. Dukler,et al.  A model for predicting flow regime transitions in horizontal and near horizontal gas‐liquid flow , 1976 .

[3]  S. Garimella,et al.  Measurements and High-Speed Visualizations of Flow Boiling of a Dielectric Fluid in a Silicon Microchannel Heat Sink † , 2006 .

[4]  S. Garimella,et al.  A COMPARATIVE ANALYSIS OF STUDIES ON HEAT TRANSFER AND FLUID FLOW IN MICROCHANNELS , 2001, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[5]  S. Garimella,et al.  TRANSPORT IN MICROCHANNELS - A CRITICAL REVIEW , 2003 .

[6]  Suresh V. Garimella,et al.  Microchannel size effects on local flow boiling heat transfer to a dielectric fluid , 2008 .

[7]  I. Mudawar,et al.  Fluid flow and heat transfer characteristics of low temperature two-phase micro-channel heat sinks – Part 1: Experimental methods and flow visualization results , 2008 .

[8]  M. Cooper.  SATURATION NUCLEATE POOL BOILING - A SIMPLE CORRELATION , 1984 .

[9]  Dong Liu,et al.  On-Chip Thermal Management With Microchannel Heat Sinks and Integrated Micropumps , 2006, Proceedings of the IEEE.

[10]  Albert Mosyak,et al.  Two-phase flow patterns in parallel micro-channels , 2003 .

[11]  P. Kew,et al.  Correlations for the prediction of boiling heat transfer in small-diameter channels , 1997 .

[12]  M. Cooper.  Heat Flow Rates in Saturated Nucleate Pool Boiling-A Wide-Ranging Examination Using Reduced Properties , 1984 .

[13]  Yehuda Taitel,et al.  FLOW PATTERN TRANSITION IN TWO PHASE FLOW , 1990 .

[14]  S. Garimella,et al.  An investigation of flow boiling regimes in microchannels of different sizes by means of high-speed visualization , 2008, 2008 11th Intersociety Conference on Thermal and Thermomechanical Phenomena in Electronic Systems.

[15]  Thomas W. Kenny,et al.  Phase change phenomena in silicon microchannels , 2005 .

[16]  Effects of Dissolved Air on Subcooled Flow Boiling of a Dielectric Coolant in a Microchannel Heat Sink , 2006 .

[17]  Predrag Stojan Hrnjak,et al.  Visualization of two-phase refrigerant and refrigerant-oil flow in a microchannel , 2007 .

[18]  J. Taylor.  An Introduction to Error Analysis , 1982 .

[19]  Masahiro Kawaji,et al.  The effect of channel diameter on adiabatic two-phase flow characteristics in microchannels ☆ , 2004 .

[20]  M. Ishii,et al.  Flow regime transition criteria for upward two-phase flow in vertical tubes , 1984 .

[21]  John R. Thome,et al.  Characterization of diabatic two-phase flows in microchannels: Flow parameter results for R-134a in a 0.5 mm channel , 2006 .

[22]  P. Cheng,et al.  Effects of inlet/outlet configurations on flow boiling instability in parallel microchannels , 2008 .

[23]  Keith Cornwell,et al.  Flow boiling of refrigerant R141B in small tubes , 2001 .

[24]  Satish G. Kandlikar.  Heat Transfer Mechanisms During Flow Boiling in Microchannels , 2004 .

[25]  S. Garimella,et al.  Prediction of the onset of nucleate boiling in microchannel flow , 2005 .

[26]  Suresh V. Garimella,et al.  Refrigerant flow boiling heat transfer in parallel microchannels as a function of local vapor quality , 2008 .

[27]  Shizuo Saitoh,et al.  Effect of tube diameter on boiling heat transfer of R-134a in horizontal small-diameter tubes , 2005 .

[28]  D. Pinjala,et al.  Experimental characterization of flow boiling heat dissipation in a microchannel heat sink with different orientations , 2005, 2005 7th Electronic Packaging Technology Conference.

[29]  J. Henahan.  In the Abstract , 1893, Nature.

[30]  Srinivas Garimella,et al.  Two-phase flow regimes in round, square and rectangular tubes during condensation of refrigerant R134a , 2003 .

[31]  X. Peng,et al.  Forced convection and flow boiling heat transfer for liquid flowing through microchannels , 1993 .

[32]  H. Honda,et al.  Enhanced boiling heat transfer from electronic components by use of surface microstructures , 2004 .

[33]  Microchannel Size Effects on Two-Phase Local Heat Transfer and Pressure Drop in Silicon Microchannel Heat Sinks with a Dielectric Fluid , 2007 .

[34]  K. Aziz,et al.  A flow pattern map for gas—liquid flow in horizontal pipes , 1974 .

[35]  M. Vaillancourt,et al.  Two-Phase Flow Regime Transitions in Microchannels: A Comparative Experimental Study , 2005 .

[36]  S. Garimella,et al.  Review and Comparative Analysis of Studies on Saturated Flow Boiling in Small Channels , 2008 .

[37]  T. Karayiannis,et al.  Flow boiling and flow regimes in small diameter tubes , 2004 .

[38]  A. Kawahara,et al.  Investigation of two-phase flow pattern, void fraction and pressure drop in a microchannel , 2002 .

[39]  John P. McHale,et al.  Measurements of Bubble Nucleation Characteristics in Pool Boiling of a Wetting Liquid on Smooth and Roughened Surfaces , 2008 .

[40]  Man Wong,et al.  Size and shape effects on two-phase flow patterns in microchannel forced convection boiling , 2003 .