Gas-Lifting Characteristics of Methane-Water Mixture and Its Potential Application for Self-Eruption Production of Marine Natural Gas Hydrates

A gas-lifting production method was firstly proposed to transport the methane-water mixture from natural gas hydrates deposits through marine vertical pipe in this work. Aiming at UBGH2-6 site, SH7 site and GMGS2-8 site, the gas-lifting performance of methane-water mixture in the vertical pipe was investigated by numerical calculation. The potential of Natural gas hydrates (NGH) self-eruption production induced by the gas-lifting process under ideal conditions was also studied based on the energy analysis. The calculation results indicate that the gas-lifting method has great advantage in avoiding the secondary hydrates formation in marine vertical pipe and reducing energy consumption. The gas-lifting process in the vertical pipe is testified to be spontaneous in UBGH2-6 site and SH7 site during the initial 4000 and 1000 days, respectively, which indicates the energy consumption for methane-water mixture transportation is saved. Sufficient heat supply for the hydrate dissociation is crucial for the NGH self-eruption production. Sensitivity analysis indicates that the water-gas ratio has more significant influences on gas-lifting performance in the vertical pipe compared to the flow rate. With the decrease of water-gas ratio, the bottomhole pressure decreases rapidly. Thus, the reduction of water production is effective to improve the gas-lifting performance.

[1]  Hoon Kiang Tan,et al.  Review of gas hydrate dissociation kinetic models for energy recovery , 2016 .

[2]  R. Boswell,et al.  Current perspectives on gas hydrate resources , 2011 .

[3]  Carolyn A. Koh,et al.  Clathrate hydrates of natural gases , 1990 .

[4]  John H. Weare,et al.  The prediction of methane solubility in natural waters to high ionic strength from 0 to 250°C and from 0 to 1600 bar , 1992 .

[5]  Khalid Aziz,et al.  Analysis of Vertical Two-phase Flow Calculations: Crude Oil-gas Flow In Well Tubing , 1980 .

[6]  Cem Sarica,et al.  A Comprehensive Mechanistic Model for Upward Two-Phase Flow in Wellbores , 1994 .

[7]  George J. Moridis,et al.  Evaluation of Gas Production Potential from Marine Gas Hydrate Deposits in Shenhu Area of South China Sea , 2010 .

[8]  Youxue Zhang,et al.  Dynamics of CO2-driven lake eruptions , 1996, Nature.

[9]  Gang Li,et al.  Experimental and Numerical Studies on Gas Production from Methane Hydrate in Porous Media by Depressurization in Pilot-Scale Hydrate Simulator , 2012 .

[10]  George J. Moridis,et al.  Evaluation of the Gas Production Potential of Some Particularly Challenging Types of Oceanic Hydrate Deposits , 2011 .

[11]  Youxue Zhang,et al.  Energetics of gas-driven limnic and volcanic eruptions , 2000 .

[12]  M. Reagan,et al.  Strategies for gas production from oceanic Class 3 hydrate accumulations , 2007 .

[13]  Lionel Wilson,et al.  Explosive volcanic eruptions — IV. The control of magma properties and conduit geometry on eruption column behaviour , 1980 .

[14]  Gang Li,et al.  Evaluation of Gas Production from Marine Hydrate Deposits at the GMGS2-Site 8, Pearl River Mouth Basin, South China Sea , 2016 .

[15]  Yu Zhang,et al.  Investigation into optimization condition of thermal stimulation for hydrate dissociation in the sandy reservoir , 2015 .

[16]  Afshin J. Ghajar,et al.  A flow pattern independent drift flux model based void fraction correlation for a wide range of gas–liquid two phase flow , 2014 .

[17]  James P. Brill,et al.  A Study of Two-Phase Flow in Inclined Pipes , 1973 .

[18]  G. Soave.  Equilibrium constants from a modified Redlich-Kwong equation of state , 1972 .

[19]  L. Durlofsky,et al.  Drift-Flux Modeling of Two-Phase Flow in Wellbores , 2005 .

[20]  George J. Moridis,et al.  Evaluation of the Gas Production Potential of Marine Hydrate Deposits in the Ulleung Basin of the Korean East Sea , 2007 .

[21]  C. S. Kabir,et al.  Simplified two-phase flow modeling in wellbores , 2010 .

[22]  Stephen A. Holditch,et al.  Natural gas-hydrates — A potential energy source for the 21st Century , 2007 .

[23]  George J. Moridis,et al.  Toward Production From Gas Hydrates: Current Status, Assessment of Resources, and Simulation-Based Evaluation of Technology and Potential , 2008 .

[24]  Alexei Vasilievich Milkov.  How and Why the Global Estimates of Hydrate-Bound Gas in Marine Sediments Decreased Over the Last Thirty Years, and What This Means for Resources and Global Change Evaluations , 2003 .

[25]  Youxue Zhang,et al.  Methane escape from gas hydrate systems in marine environment, and methane‐driven oceanic eruptions , 2003 .

[26]  I︠u︡. F. Makogon,et al.  Hydrates of natural gas , 1981 .

[27]  J. P. Brill,et al.  Pressure Drop Correlations for Inclined Two-Phase Flow , 1985 .

[28]  Behl,et al.  Carbon isotopic evidence for methane hydrate instability during quaternary interstadials , 2000, Science.

[29]  Mike Priegnitz,et al.  Gas Production from Methane Hydrate: A Laboratory Simulation of the Multistage Depressurization Test in Mallik, Northwest Territories, Canada , 2016 .

[30]  K. Brown,et al.  Experimental Study of Pressure Gradients Occurring During Continuous Two-Phase Flow in Small-Diameter Vertical Conduits , 1965 .

[31]  Mamoru Ishii,et al.  One-dimensional drift–flux model for two-phase flow in a large diameter pipe , 2003 .

[32]  M. Reagan,et al.  Feasibility of gas production from a gas hydrate accumulation at the UBGH2-6 site of the Ulleung basin in the Korean East Sea , 2013 .

[33]  G. W. Govier,et al.  Pressure Drop In Wells Producing Oil And Gas , 1972 .

[34]  Yoshihiro Masuda,et al.  Key Findings of the World’s First Offshore Methane Hydrate Production Test off the Coast of Japan: Toward Future Commercial Production , 2017 .

[35]  James P. Brill,et al.  Multiphase Flow in Wells , 1987 .

[36]  Martin J. Blunt.  Three-Phase Flow , 2017 .

[37]  J. Orkiszewski.  Predicting Two-Phase Pressure Drops in Vertical Pipe , 1967 .