Fluorinated Metal Phthalocyanines: Interplay between Fluorination Degree, Films Orientation, and Ammonia Sensing Properties

In this work, the sensor response of MPcFx (M = Cu, Co, Zn; x = 0, 4, 16) films toward gaseous NH3 (10–50 ppm) was studied by a chemiresistive method and compared to that of unsubstituted MPc films to reveal the effects of central metals and F-substituents on the sensing properties. A combination of atomic force microscopy and X-ray diffraction techniques have been used to elucidate the structural features of thin MPcFx films deposited by organic molecular beam deposition. It has been shown that the sensor response of MPcF4 films to ammonia is noticeably higher than that of MPc films, which is in good correlation with the values of binding energy between the metal phthalocyanine and NH3 molecules, as calculated by the density functional theory (DFT) method. At the same time, in contrast to the DFT calculations, MPcF16 demonstrated the lesser sensor response compared with MPcF4, which appeared to be connected with the different structure and morphology of their films. The ZnPcF4 films were shown to exhibit a sensitivity to ammonia up to concentrations as low as 0.1 ppm, and can be used for the selective detection of ammonia in the presence of some reducing gases and volatile organic compounds. Moreover, the ZnPcF4 films can be used for the detection of NH3 in the gas mixture simulating exhaled air (N2 76%, O2 16%, H2O 5%, and CO2 3%).

[1]  S. Pandey,et al.  Highly Sensitive and Selective Chemiresistor Gas/Vapor Sensors based on Polyaniline Nanocomposite: A comprehensive review , 2016 .

[2]  Marc Debliquy,et al.  Influence of atmospheric pollutants on the conductance of phthalocyanine films , 1999 .

[3]  István Mayer,et al.  Bond order and valence: Relations to Mulliken's population analysis , 1984 .

[4]  P. Pandey,et al.  Resolving the Nanoscale Morphology and Crystallographic Structure of Molecular Thin Films: F16CuPc on Graphene Oxide , 2012 .

[5]  Mang Wang,et al.  High gas-sensitivity and selectivity of fluorinated zinc phthalocyanine film to some non-oxidizing gases at room temperature , 2005 .

[6]  Wen-Chau Liu,et al.  Ammonia sensing characteristic of a Pt nanoparticle/aluminum-doped zinc oxide sensor , 2018, Sensors and Actuators B: Chemical.

[7]  Kwang Soo Kim,et al.  Single crystal structure of copper hexadecafluorophthalocyanine (F16CuPc) ribbon. , 2010, Chemical communications.

[8]  H. Yoon,et al.  Chemo-Electrical Gas Sensors Based on Conducting Polymer Hybrids , 2017, Polymers.

[9]  R. Capuano,et al.  Solid-state gas sensors for breath analysis: a review. , 2014, Analytica chimica acta.

[10]  Yixiang Duan,et al.  Development of a polyaniline-based optical ammonia sensor , 2001 .

[11]  T. Basova,et al.  Thin Films of Unsubstituted and Fluorinated Palladium Phthalocyanines: Structure and Sensor Response toward Ammonia and Hydrogen , 2017 .

[12]  T. Basova,et al.  Thin films of tetrafluorosubstituted cobalt phthalocyanine: Structure and sensor properties , 2016 .

[13]  R. S. Mulliken.  Electronic Population Analysis on LCAO–MO Molecular Wave Functions. I , 1955 .

[14]  Nirav Joshi,et al.  Bending stress induced improved chemiresistive gas sensing characteristics of flexible cobalt-phthalocyanine thin films , 2013 .

[15]  N. Bârsan,et al.  Modeling of sensing and transduction for p-type semiconducting metal oxide based gas sensors , 2010 .

[16]  J. Meyer,et al.  Molecular Interactions in Thin Films of Hexadecafluorophthalocyaninatozinc (F16PcZn) as Compared to Islands of N,N‘-Dimethylperylene-3,4,9,10-biscarboximide (MePTCDI) , 1999 .

[17]  Bin Sun,et al.  Nanostructured polyaniline/poly(styrene-butadiene-styrene) composite fiber for use as highly sensitive and flexible ammonia sensor , 2017 .

[18]  S. Annapoorni,et al.  Flexible room temperature ammonia sensor based on polyaniline , 2017 .

[19]  A. Schäfer,et al.  Fully optimized contracted Gaussian basis sets of triple zeta valence quality for atoms Li to Kr , 1994 .

[20]  N. Armstrong,et al.  Electronic Energy Levels in Individual Molecules, Thin Films, and Organic Heterojunctions of Substituted Phthalocyanines , 2001 .

[21]  Shaohua Wu,et al.  Solution‐Processed Microporous Semiconductor Films for High‐Performance Chemical Sensors , 2016 .

[22]  M. Brinkmann,et al.  Orienting Semiconducting Nanocrystals on Nanostructured Polycarbonate Substrates: Impact of Substrate Temperature on Polymorphism and In-Plane Orientation , 2011 .

[23]  T. Basova,et al.  Effect of fluorosubstitution on the structure of single crystals, thin films and spectral properties of palladium phthalocyanines , 2018 .

[24]  Duk-Dong Lee,et al.  Visible optical sensing of ammonia based on polyaniline film , 2003 .

[25]  Kangho Lee,et al.  Highly sensitive, transparent, and flexible gas sensors based on gold nanoparticle decorated carbon nanotubes , 2013 .

[26]  Hans W. Horn,et al.  Fully optimized contracted Gaussian basis sets for atoms Li to Kr , 1992 .

[27]  Osvaldo N. Oliveira,et al.  A review on chemiresistive room temperature gas sensors based on metal oxide nanostructures, graphene and 2D transition metal dichalcogenides , 2018, Microchimica Acta.

[28]  Gordon G. Wallace,et al.  Fabrication of an ammonia gas sensor using inkjet-printed polyaniline nanoparticles , 2008 .

[29]  S. Grimme,et al.  A consistent and accurate ab initio parametrization of density functional dispersion correction (DFT-D) for the 94 elements H-Pu. , 2010, The Journal of chemical physics.

[30]  D. Schlettwein,et al.  Fluorinated phthalocyanines as molecular semiconductor thin films , 2008 .

[31]  J. Perdew,et al.  Density-functional approximation for the correlation energy of the inhomogeneous electron gas. , 1986, Physical review. B, Condensed matter.

[32]  Z. Zou,et al.  Ammonia gas sensor based on flexible polyaniline films for rapid detection of spoilage in protein-rich foods , 2017, Journal of Materials Science: Materials in Electronics.

[33]  J. H. Lee,et al.  Highly sensitive and selective gas sensors using p-type oxide semiconductors: Overview , 2014 .

[34]  Robert S. Mulliken,et al.  Electronic Population Analysis on LCAO–MO Molecular Wave Functions. II. Overlap Populations, Bond Orders, and Covalent Bond Energies , 1955 .

[35]  Bin Wang,et al.  Enhanced NH 3 -sensing behavior of 2,9,16,23-tetrakis(2,2,3,3-tetrafluoropropoxy) metal(II) phthalocyanine/multi-walled carbon nanotube hybrids: An investigation of the effects of central metals , 2014 .

[36]  I. Mayer.  Bond orders and valences in the SCF theory: a comment , 1985 .

[37]  Stefan Grimme,et al.  Effect of the damping function in dispersion corrected density functional theory , 2011, J. Comput. Chem..

[38]  R. Caminiti,et al.  X-ray Powder Diffraction Structure Reinvestigation of the α and β Forms of Cobalt Phthalocyanine and Kinetics of the α → β Phase Transition , 1998 .

[39]  A. Pauly,et al.  Influence of peripheral electron-withdrawing substituents on the conductivity of zinc phthalocyanine in the presence of gases. Part 2 : oxidizing gases , 1998 .

[40]  A. Becke,et al.  Density-functional exchange-energy approximation with correct asymptotic behavior. , 1988, Physical review. A, General physics.

[41]  S. Rulyak,et al.  Breath Ammonia Testing for Diagnosis of Hepatic Encephalopathy , 2005, Digestive Diseases and Sciences.

[42]  A. Berg,et al.  Ammonia sensors and their applications - a review , 2005 .

[43]  D. Schlettwein,et al.  Spectroelectrochemical investigations on the reduction of thin films of hexadecafluorophthalocyaninatozinc (F16PcZn) , 1999 .

[44]  M. Mateos,et al.  New n-type molecular semiconductor–doped insulator (MSDI) heterojunctions combining a triphenodioxazine (TPDO) and the lutetium bisphthalocyanine (LuPc2) for ammonia sensing , 2018 .

[45]  Hongxiang Li,et al.  High-performance air-stable n-type transistors with an asymmetrical device configuration based on organic single-crystalline submicrometer/nanometer ribbons. , 2006, Journal of the American Chemical Society.

[46]  Kun-Wei Lin,et al.  Characteristics of a Pt/NiO thin film-based ammonia gas sensor , 2018 .

[47]  Peter Erk,et al.  The innovative momentum of crystal engineering , 2004 .

[48]  R. D. Gould.  Structure and electrical conduction properties of phthalocyanine thin films , 1996 .

[49]  Hal Westberg,et al.  Measurement of atmospheric ammonia at a dairy using differential optical absorption spectroscopy in the mid-ultraviolet , 2002 .

[50]  Yiqun Wu,et al.  Enhanced NH3-Sensitivity of Reduced Graphene Oxide Modified by Tetra-α-Iso-Pentyloxymetallophthalocyanine Derivatives , 2015, Nanoscale Research Letters.

[51]  Frank Neese,et al.  The ORCA program system , 2012 .

[52]  E. Faassen,et al.  Quantification and effects of molecular oxygen and water in zinc phthalocyanine layers , 2001 .