Gasification of wastes in a pilot fluidized bed gasifier

Abstract A technical assessment of fluidized bed (FB) gasification of various wastes was carried out by conducting tests in a 100 kW th pilot plant. Four feed stocks were tested: orujillo, meat and bone meal (MBM), dried sewage sludge (DSS) and compost from municipal solid waste (MSW). The air ratio (the ratio between the actual and stoichiometric air flow rates) was varied for each fuel between 0.23 and 0.43 giving temperatures in the range of 770–870 °C. Characterization of the process was made in terms of gas composition, heating value, gasification efficiency, carbon conversion and tar content. Comparison of the results to those previously obtained with wood pellets was made. It was found that orujillo is a suitable fuel to be gasified in FB, providing that the temperature in the bed is enough to reach high carbon conversion (higher than 850 °C). In the present work, orujillo was gasified by continuous removal of material from the bed to keep potassium concentration low, resulting in relatively low carbon conversion. However, improvement could be made if additives slowing the sintering of the bed material were used. MBM was easily gasified, even at relatively low temperatures (≈ 800 °C), but it produced a gas with a low heating value and high tar concentration, leading to very low process efficiency. Gasification of DSS and MSW fuels in a FB is challenging due to the amount and nature of the ash in these fuels, making operation at a high rate of ash removal necessary to maintain smooth conditions in the bed. The efficiency of the process is low, generating ashes which are difficult to dispose of.

[1]  Ajay K. Ray,et al.  Performance Improvement and Dynamical Behaviour Analysis of a Cascade of Two CSTRs , 2007 .

[2]  Contract Jor.  CONVERSION OF BIOMASS,{PRIVATE } PREDICTION AND SOLUTION METHODS FOR ASH AGGLOMERATION AND RELATED PROBLEMS , 1999 .

[3]  Susanna Nilsson,et al.  Devolatilization of wood and wastes in fluidized bed , 2010 .

[4]  Freek Kapteijn,et al.  Agglomeration in fluidized beds at high temperatures: Mechanisms, detection and prevention , 2008 .

[5]  M. B. Murillo,et al.  Understanding the Effect of the Transition Period during the Air Gasification of Dried Sewage Sludge in a Fluidized Bed Reactor , 2007 .

[6]  J. Werther,et al.  Experimental investigation and modeling of gasification of sewage sludge in the circulating fluidized bed , 2005 .

[7]  Animesh Dutta,et al.  An investigation of MSW gasification in a spout-fluid bed reactor , 2008 .

[8]  Jesús Arauzo,et al.  Influence of gas residence time and air ratio on the air gasification of dried sewage sludge in a bubbling fluidised bed , 2006 .

[9]  J. V. Doorn,et al.  Ten residual biomass fuels for circulating fluidized-bed gasification , 2001 .

[10]  A. Cabanillas,et al.  Gasification of leached orujillo (olive oil waste) in a pilot plant circulating fluidised bed reactor. Preliminary results , 2004 .

[11]  Todd Pugsley,et al.  Hydrogen production via gasification of meat and bone meal in two-stage fixed bed reactor system , 2009 .

[12]  Johannes W Judex,et al.  Gasification of dried sewage sludge: status of the demonstration and the pilot plant. , 2012, Waste management.

[13]  S.V.B. van Paasen,et al.  Gasification of non-woody biomass , 2006 .

[14]  E. Koukios,et al.  Agglomeration problems during fluidized bed gasification of olive-oil residue: evaluation of fractionation and leaching as pre-treatments☆ , 2003 .

[15]  A. Cabanillas,et al.  A Pilot Scale Circulating Fluidized Bed Plant for Orujillo Gasification , 2008 .

[16]  Tae-Young Mun,et al.  Air gasification of dried sewage sludge in a two-stage gasifier. Part 2: Calcined dolomite as a bed material and effect of moisture content of dried sewage sludge for the hydrogen production and tar removal , 2013 .

[17]  Pedro Ollero,et al.  Tar Reduction by Primary Measures in an Autothermal Air-Blown Fluidized Bed Biomass Gasifier , 2010 .

[18]  R. Bradley,et al.  Bovine spongiform encephalopathy (BSE): The current situation and research , 1991, European Journal of Epidemiology.

[19]  Luis F. Vilches,et al.  Plant optimisation and ash recycling in fluidised bed waste gasification , 2009 .

[20]  Pedro Ollero,et al.  Air–steam gasification of biomass in a fluidised bed: Process optimisation by enriched air , 2009 .

[21]  Anastasia Zabaniotou,et al.  Utilization of sewage sludge in EU application of old and new methods--A review , 2008 .

[22]  J.H.A. Kiel,et al.  Gasash: Improvement of the economics of biomass/waste gasification by higher carbon conversion and advanced ash management , 2006 .

[23]  José Corella,et al.  Olivine or Dolomite as In-Bed Additive in Biomass Gasification with Air in a Fluidized Bed: Which Is Better? , 2004 .

[24]  J. M. Andrés,et al.  Behaviour of dolomite, olivine and alumina as primary catalysts in air–steam gasification of sewage sludge , 2011 .

[25]  Pedro Ollero,et al.  Air—Steam Gasification of Biomass in a Fluidized Bed under Simulated Autothermal and Adiabatic Conditions , 2008 .

[26]  A. Gómez-Barea,et al.  Pilot-Plant Gasification of Olive Stone: a Technical Assessment , 2005 .

[27]  A. Dalai,et al.  Steam gasification of meat and bone meal in a two-stage fixed-bed reactor system , 2011 .

[28]  Esther Cascarosa,et al.  Co-gasification of meat and bone meal with coal in a fluidised bed reactor , 2011 .

[29]  Tae-Young Mun,et al.  Air gasification of dried sewage sludge in a two-stage gasifier: Part 1. The effects and reusability of additives on the removal of tar and hydrogen production , 2013 .

[30]  Hermann Hofbauer,et al.  Conversion of mixed plastic wastes in a dual fluidized bed steam gasifier , 2013 .

[31]  M. Aznar,et al.  Plastic waste elimination by co-gasification with coal and biomass in fluidized bed with air in pilot plant , 2006 .

[32]  Jesús Arauzo,et al.  Air Gasification of Dried Sewage Sludge in a Fluidized Bed: Effect of the Operating Conditions and In-Bed Use of Alumina , 2005 .

[33]  A. Gómez-Barea,et al.  Estimation of gas composition and char conversion in a fluidized bed biomass gasifier , 2013 .

[34]  Yang Wang,et al.  Co-gasification behavior of meat and bone meal char and coal char , 2011 .

[35]  J. M. Andrés,et al.  Air-steam gasification of sewage sludge in a bubbling bed reactor: Effect of alumina as a primary ca , 2011 .

[36]  Sanjeev Maken,et al.  Environmental aspects of gasification of Korean municipal solid waste in a pilot plant , 2006 .