Atomic Layer Deposition of Tin Monosulfide Thin Films

Thin film solar cells made from earth-abundant, non-toxic materials are needed to replace the current technology that uses Cu(In,Ga)(S,Se)2 and CdTe, which contain scarce and toxic elements. One promising candidate absorber material is tin monosulfide (SnS). In this report, pure, stoichiometric, single-phase SnS films were obtained by atomic layer deposition (ALD) using the reaction of bis(N,N′-diisopropylacetamidinato)tin(II) [Sn(MeC(N-iPr)2)2] and hydrogen sulfide (H2S) at low temperatures (100 to 200 °C). The direct optical band gap of SnS is around 1.3 eV and strong optical absorption (α > 104 cm−1) is observed throughout the visible and near-infrared spectral regions. The films are p-type semiconductors with carrier concentration on the order of 1016 cm−3 and hole mobility 0.82–15.3 cm2V−1s−1 in the plane of the films. The electrical properties are anisotropic, with three times higher mobility in the direction through the film, compared to the in-plane direction.

[1]  J. Campos-Alvarez,et al.  Structural, optical, and electrical properties of tin sulfide thin films grown by spray pyrolysis , 2009 .

[2]  Ivan P. Parkin,et al.  Atmospheric Pressure Chemical Vapor Deposition of Tin Sulfides (SnS, Sn2S3, and SnS2) on Glass , 1999 .

[3]  H. Gong,et al.  Photovoltaic Behavior of Nanocrystalline SnS/TiO2 , 2010 .

[4]  M. Garcı́a,et al.  Tin sulphide films deposited by plasma-enhanced chemical vapour deposition , 1996 .

[5]  C. D. Kartha,et al.  Unveiling the defect levels in SnS thin films for photovoltaic applications using photoluminescence technique , 2010 .

[6]  M. Nassary.  Temperature dependence of the electrical conductivity, Hall effect and thermoelectric power of SnS single crystals , 2005 .

[7]  Dirk Poelman,et al.  Optical and photoconductive properties of SnS thin films prepared by electron beam evaporation , 2003 .

[8]  Sailing He,et al.  Kinetics of Stop-Flow Atomic Layer Deposition for High Aspect Ratio Template Filling through Photonic Band Gap Measurements , 2010 .

[9]  R. C. Weast.  CRC Handbook of Chemistry and Physics , 1973 .

[10]  K. P. Vijayakumar,et al.  Optimization of parameters of chemical spray pyrolysis technique to get n and p-type layers of SnS , 2010 .

[11]  David B Mitzi,et al.  High‐Efficiency Solar Cell with Earth‐Abundant Liquid‐Processed Absorber , 2010, Advanced materials.

[12]  H. Wiedemeier,et al.  Refinement of the structures of GeS, GeSe, SnS and SnSe , 1978 .

[13]  Roy G. Gordon,et al.  Highly conformal atomic layer deposition of tantalum oxide using alkylamide precursors , 2003 .

[14]  Robert Miles,et al.  Photovoltaic properties of SnS based solar cells , 2006 .

[15]  I. Parkin,et al.  Deposition of tin sulfide thin films from tin(IV) thiolate precursors , 2001 .

[16]  Y. Hahn,et al.  Temperature-dependent structural and optical properties of SnS films , 2007 .

[17]  M. Ichimura,et al.  Pulsed electrodeposition of oxygen-free tin monosulfide thin films using lactic acid/sodium lactate buffered electrolytes , 2010 .

[18]  M. Ichimura,et al.  Electrochemical deposition of SnS thin films , 2000 .

[19]  F. Patolsky,et al.  Ohmic contacts to SnS films: Selection and estimation of thermal stability , 2008 .

[20]  M. Kul,et al.  Structural and optical properties of SnS semiconductor films produced by chemical bath deposition , 2009 .

[21]  M. Ristov,et al.  Chemical deposition of TIN(II) sulphide thin films , 1989 .

[22]  Shivram S. Garje,et al.  Tribenzyltin(IV)chloride Thiosemicarbazones: Novel Single Source Precursors for Growth of SnS Thin Films , 2008 .

[23]  I. Parkin,et al.  The first single source deposition of tin sulfide coatings on glass: aerosol-assisted chemical vapour deposition using [Sn(SCH2CH2S)(2)] , 2001 .

[24]  Rajamohan Ganesan,et al.  Thickness Effect on the Physical Properties of Evaporated SnS Films , 2007 .

[25]  K. Reddy,et al.  Preparation and characterisation of sprayed tin sulphide films grown at different precursor concentrations , 2007 .

[26]  W. Albers,et al.  The preparation and the electrical and optical properties of SnS crystals , 1960 .

[27]  F. Patolsky,et al.  Temperature dependent structural properties of nanocrystalline SnS structures , 2009 .

[28]  A. L. Patterson.  The Scherrer Formula for X-Ray Particle Size Determination , 1939 .

[29]  W. M. Haynes.  CRC Handbook of Chemistry and Physics , 1990 .

[30]  R. Miles,et al.  Thermally evaporated thin films of SnS for application in solar cell devices , 2009 .

[31]  L. Makinistian,et al.  On the band gap location and core spectra of orthorhombic IV–VI compounds SnS and SnSe , 2009 .

[32]  Steven M. George,et al.  Tin Monosulfide Thin Films Grown by Atomic Layer Deposition Using Tin 2,4-Pentanedionate and Hydrogen Sulfide , 2010 .

[33]  Jin-seong Park,et al.  Synthesis and characterization of volatile, thermally stable, reactive transition metal amidinates. , 2003, Inorganic chemistry.

[34]  R. Gordon,et al.  Low Temperature Atomic Layer Deposition of Tin Oxide , 2010 .

[35]  K. Weiser,et al.  Suppression of interference fringes in absorption measurements on thin films , 1986 .

[36]  H. R. Chandrasekhar,et al.  Infrared and Raman spectra of the IV-VI compounds SnS and SnSe , 1977 .

[37]  P. K. Nair,et al.  Simplified chemical deposition technique for good quality SnS thin films , 1991 .

[38]  D. A. Guseinova,et al.  Optical spectra and energy band structure of layer‐type AIVBVI compounds , 1986 .

[39]  K. Ramesh,et al.  Microstructure dependent physical properties of evaporated tin sulfide films , 2006 .

[40]  I. Parkin,et al.  Deposition of tin sulfide thin films from novel, volatile (fluoroalkythiolato)tin(IV) precursors , 2001 .

[41]  K. Ramakrishna Reddy,et al.  Growth of polycrystalline SnS films by spray pyrolysis , 1998 .

[42]  H. J. Vink,et al.  Investigations on SnS , 1961 .

[43]  Hiran B.M. Anaya,et al.  Tin Sulfide Thin Films by Pulse Electrodeposition: Structural, Morphological, and Optical Properties , 2010 .

[44]  J. Loferski,et al.  Theoretical Considerations Governing the Choice of the Optimum Semiconductor for Photovoltaic Solar Energy Conversion , 1956 .

[45]  R. Engelken,et al.  Optimization of photoconductivity in vacuum-evaporated tin sulfide thin films , 1999 .

[46]  P. K. Nair,et al.  Polymorphic Tin Sulfide Thin Films of Zinc Blende and Orthorhombic Structures by Chemical Deposition , 2008 .

[47]  B. Ghosh,et al.  Fabrication of SnS thin films by the successive ionic layer adsorption and reaction (SILAR) method , 2008 .

[48]  Honglie Shen,et al.  Preparation of SnS films with zinc blende structure by successive ionic layer adsorption and reaction method , 2010 .

[49]  I. Parkin,et al.  Synthesis and thermal decomposition studies of homo- and heteroleptic tin(IV) thiolates and dithiocarbamates: molecular precursors for tin sulfides , 2002 .

[50]  B. Ghosh,et al.  Characteristics of metal/p-SnS Schottky barrier with and without post-deposition annealing , 2009 .