Performance modeling of air cycle heat pump water heater in cold climate

Air (reverse Brayton) cycle has promising features in cold climate heat pump applications. In this study, an air cycle heat pump water heater (ACHPWH) simulation model considering the off-design performance of components was developed and validated with experimental data from literature. With this model, the performance of ACHPWH was numerically compared with two typical vapor compression heat pump water heaters (VCHPWH) under two different heating schemes, namely instantaneous heating and recirculation heating. For instantaneous heating, the COP of ACHPWH is comparable to that of VCHPWH when supplying high temperature water or operating at low ambient temperature. A significant improvement on annual performance would be achieved as well if higher efficient compressor and expander were applied in ACHPWH system. For recirculation heating, although the COP gap got larger, ACHPWH would save plenty of heating time when operating at low ambient temperature.

[1]  Aj Gigiel.  Air cycle refrigeration , 1995 .

[2]  Andrew C. Harvey,et al.  Research and development of an air-cycle heat-pump water heater , 1979 .

[3]  Shengming Liao,et al.  A correlation of optimal heat rejection pressures in transcritical carbon dioxide cycles , 2000 .

[4]  Pradeep Bansal,et al.  Thermal analysis of the defrost cycle in a domestic freezer. , 2010 .

[5]  Chun-Lu Zhang,et al.  An important feature of air heat pump cycle: Heating capacity in line with heating load , 2014 .

[6]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[7]  Stephen Spence,et al.  Design, construction and testing of an air-cycle refrigeration system for road transport , 2004 .

[8]  Chi-Chuan Wang,et al.  Heat transfer and friction characteristics of plain fin-and-tube heat exchangers, part II: Correlation , 2000 .

[9]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[10]  Shiming Deng,et al.  Improved indoor thermal comfort during defrost with a novel reverse-cycle defrosting method for air source heat pumps , 2010 .

[11]  C. Scarcella,et al.  A Comparison of Legionella pneumophila Occurrence in Hot Water Tanks and Instantaneous Devices in Domestic, Nosocomial, and Community Environments , 2000, Current Microbiology.

[12]  Chun-Lu Zhang,et al.  Regenerated air cycle potentials in heat pump applications , 2014 .

[13]  Dong Huang,et al.  Comparison between hot-gas bypass defrosting and reverse-cycle defrosting methods on an air-to-water heat pump , 2009 .

[14]  Tong Seop Kim,et al.  Off-design operating characteristics of an open-cycle air refrigeration system , 2012 .

[15]  Rodney Anthony Stewart,et al.  Residential water heaters in Brisbane, Australia: thinking beyond technology selection to enhance energy efficiency and level of service , 2014 .

[16]  Niccolo Giannetti,et al.  Thermodynamic analysis of regenerated air-cycle refrigeration in high and low pressure configuration , 2014 .

[17]  R. Bettocchi,et al.  Dynamic Modeling of Single-Shaft Industrial Gas Turbine , 1996 .

[18]  Zhang Lin,et al.  Experimental analysis on a novel frost-free air-source heat pump water heater system , 2014 .

[19]  Farouk Fardoun,et al.  Optimal management proposal for hybrid water heating system , 2014 .

[20]  Arif Hepbasli,et al.  A review of heat pump water heating systems , 2009 .

[21]  J. R. Szuch.  HYDES: A generalized hybrid computer program for studying turbojet or turbofan engine dynamics , 1974 .