Seebeck Effect and Mechanical Properties of Carbon Nanotube-Carbon Fiber/Cement Nanocomposites

Carbon nanotubes (CNTs) were homogeneously dispersed in a mixed solution by surface-active agents and ultrasonics, and then mixed with short carbon fibers before added into cement paste. Seebeck effect, microstructure, and mechanical properties of the fabricated composites were measured. Results show that the addition of CNTs to carbon fiber/cement composites results in improvement in the compressive and splitting tensile strengths of the composites. The addition of 0.5% by weight of cement of CNTs to carbon fiber/cement composites results in the highest increase in the compressive and splitting tensile strengths by 18.4% and 21.8%, respectively. The doping of CNTs leads to a highest increase (up to 260%) reaching 23.5 μV K−1 in the positive thermoelectric power of the carbon fiber/cement composites, when CNTs addition reaches 0.5% by weight of cement. The microscopic observation shows that CNTs act as fillers, which result in a dense microstructure of cement paste.

[1]  E. Kwon,et al.  A self-sensing carbon nanotube/cement composite for traffic monitoring , 2009, Nanotechnology.

[2]  Cohen,et al.  Is the intrinsic thermoelectric power of carbon nanotubes positive? , 2000, Physical review letters.

[3]  Surendra P. Shah,et al.  Highly concentrated carbon nanotube admixture for nano-fiber reinforced cementitious materials , 2012 .

[4]  D.D.L. Chung,et al.  Seebeck effect in steel fiber reinforced cement , 2000 .

[5]  Wu Yao,et al.  Sensing Properties of Carbon Nanotube–Carbon Fiber/Cement Nanocomposites , 2012 .

[6]  W. Yao,et al.  Assessment on the Electrical Conductivity of Additive Fillers into Carbon Fiber-Cement Based Composites , 2011 .

[7]  P. McEuen,et al.  Thermal transport measurements of individual multiwalled nanotubes. , 2001, Physical Review Letters.

[8]  M. Tian,et al.  Thermoelectric power behavior in carbon nanotubule bundles from 4.2 to 300 K , 1998 .

[9]  W. Yao,et al.  Measurements of Thermoelectric Behavior and Microstructure of Carbon Nanotubes/Carbon Fiber-Cement Based Composite , 2011 .

[10]  P. Ajayan.  Nanotubes from Carbon. , 1999, Chemical reviews.

[11]  Viktor Mechtcherine,et al.  Dispersion of carbon nanotubes and its influence on the mechanical properties of the cement matrix , 2012 .

[12]  M. Dresselhaus,et al.  New Directions for Low‐Dimensional Thermoelectric Materials , 2007 .

[13]  A. M. Rao,et al.  Evidence for charge transfer in doped carbon nanotube bundles from Raman scattering , 1997, Nature.

[14]  A. Chaipanich,et al.  Compressive strength and microstructure of carbon nanotubes–fly ash cement composites , 2010 .

[15]  Charles M. Lieber,et al.  Nanobeam Mechanics: Elasticity, Strength, and Toughness of Nanorods and Nanotubes , 1997 .

[16]  W. Zhi.  Study on the Seebeck Effect in Steel-slag Concrete , 2008 .

[17]  Modulation of thermoelectric power of individual carbon nanotubes. , 2003, Physical review letters.

[18]  D.D.L. Chung,et al.  Seebeck effect in carbon fiber-reinforced cement , 1999 .

[19]  J. Beaudoin,et al.  Electrical percolation phenomena in cement composites containing conductive fibres , 1996, Journal of Materials Science.

[20]  M. Pinar Mengüç,et al.  Thermoelectric power generation using doped MWCNTs , 2009 .

[21]  D. Ingram,et al.  Some electronic properties of polyacrylonitrile-based carbon fibres , 1972 .

[22]  Zettl,et al.  Extreme oxygen sensitivity of electronic properties of carbon nanotubes , 2000, Science.

[23]  A. Majumdar.  Thermoelectricity in Semiconductor Nanostructures , 2004, Science.

[24]  Xiaohua Zhao,et al.  Mechanical behavior and microstructure of cement composites incorporating surface-treated multi-walled carbon nanotubes , 2005 .

[25]  S. Iijima.  Helical microtubules of graphitic carbon , 1991, Nature.

[26]  D.D.L. Chung,et al.  Enhancing the Seebeck effect in carbon fiber-reinforced cement by using intercalated carbon fibers , 2000 .

[27]  Zhuoqiu Li,et al.  Thermoelectric percolation phenomena in carbon fiber-reinforced concrete , 1998 .

[28]  WuYAO,et al.  Smart Behavior of Carbon Fiber Reinforced Cement-based Composite , 2003 .

[29]  R. Misra,et al.  Micro- and nano-scale deformation processes during scratch damage in high density polyethylene , 2003 .

[30]  Keru Wu,et al.  Study on the Deformation Characteristics of the Sheet Hydroforming with a Movable Die , 2009 .

[31]  Takaaki Koga,et al.  Low-dimensional thermoelectric materials , 1999, Flexible Thermoelectric Polymers and Systems.

[32]  S. H. Alsayed,et al.  Hybrid effect of carbon nanotube and nano-clay on physico-mechanical properties of cement mortar , 2011 .

[33]  W. M. Haynes.  CRC Handbook of Chemistry and Physics , 1990 .

[34]  D. Chung.  Cement reinforced with short carbon fibers: a multifunctional material , 2000 .

[35]  Zhuoqiu Li,et al.  Study on the Hole Conduction Phenomenon in Carbon Fiber-Reinforced Concrete , 1998 .

[36]  Jing Xu,et al.  Modeling of conductivity in carbon fiber-reinforced cement-based composite , 2010 .