Nanoscale Morphology of Conjugated Polymer/Fullerene‐Based Bulk‐ Heterojunction Solar Cells

The relation between the nanoscale morphology and associated device properties in conjugated polymer/fullerene bulk-heterojunction “plastic solar cells” is investigated. We perform complementary measurements on solid-state blends of poly[2-methoxy-5-(3,7-dimethyloctyloxy)]-1,4-phenylenevinylene (MDMO-PPV) and the soluble fullerene C60 derivative 1-(3-methoxycarbonyl) propyl-1-phenyl [6,6]C61 (PCBM), spin-cast from either toluene or chlorobenzene solutions. The characterization of the nanomorphology is carried out via scanning electron microscopy (SEM) and atomic force microscopy (AFM), while solar-cell devices were characterized by means of current–voltage (I–V) and spectral photocurrent measurements. In addition, the morphology is manipulated via annealing, to increase the extent of phase separation in the thin-film blends and to identify the distribution of materials. Photoluminescence measurements confirm the demixing of the materials under thermal treatment. Furthermore the photoluminescence of PCBM clusters with sizes of up to a few hundred nanometers indicates a photocurrent loss in films of the coarser phase-separated blends cast from toluene. For toluene-cast films the scale of phase separation depends strongly on the ratio of MDMO-PPV to PCBM, as well as on the total concentration of the casting solution. Finally we observe small beads of 20–30 nm diameter, attributed to MDMO-PPV, in blend films cast from both toluene and chlorobenzene.

[1]  Hiroshi Fujiwara,et al.  p‐i‐n like behavior in three‐layered organic solar cells having a co‐deposited interlayer of pigments , 1992 .

[2]  P. Flory.  Principles of polymer chemistry , 1953 .

[3]  Benjamin J. Schwartz,et al.  Conjugated polymer aggregates in solution: Control of interchain interactions , 1999 .

[4]  J. Hummelen,et al.  Polymer Photovoltaic Cells: Enhanced Efficiencies via a Network of Internal Donor-Acceptor Heterojunctions , 1995, Science.

[5]  Dieter Meissner,et al.  Photocurrent spectroscopy for the investigation of charge carrier generation and transport mechanisms in organic p/n-junction solar cells , 2000 .

[6]  Vladimir Dyakonov,et al.  The polymer–fullerene interpenetrating network: one route to a solar cell approach , 2002 .

[7]  Masao Doi,et al.  Introduction to Polymer Physics , 1996 .

[8]  Mats Andersson,et al.  High Quantum Efficiency Polythiophene , 1998 .

[9]  Jean-Michel Nunzi,et al.  Organic photovoltaic materials and devices , 2002 .

[10]  Alan J. Heeger,et al.  Charge separation and photovoltaic conversion in polymer composites with internal donor/acceptor heterojunctions , 1995 .

[11]  C. Brabec,et al.  2.5% efficient organic plastic solar cells , 2001 .

[12]  Alan J. Heeger,et al.  A photoluminescence study of poly(phenylene vinylene) derivatives: The effect of intrinsic persistence length , 1994 .

[13]  Jean Manca,et al.  Morphology of MDMO-PPV:PCBM bulk heterojunction organic solar cells studied by AFM, KFM, and TEM , 2003, SPIE Optics + Photonics.

[14]  D. Meissner,et al.  Photovoltaics of interconnected networks , 2001 .

[15]  C. Brabec,et al.  Plastic Solar Cells , 2001 .

[16]  Wolfgang Brütting,et al.  Exciton diffusion and optical interference in organic donor–acceptor photovoltaic cells , 2001 .

[17]  M. S. Dresselhaus,et al.  Structure of Fullerenes , 1996 .

[18]  L. S. Roman,et al.  Modeling photocurrent action spectra of photovoltaic devices based on organic thin films , 1999 .

[19]  C. Tang.  Two‐layer organic photovoltaic cell , 1986 .

[20]  N. Arnold,et al.  Modeling the optical absorption within conjugated polymer/fullerene-based bulk-heterojunction organic solar cells , 2003 .

[21]  Ronn Andriessen,et al.  Disclosure of the nanostructure of MDMO-PPV:PCBM bulk hetero-junction organic solar cells by a combination of SPM and TEM , 2003 .

[22]  Dieter Meissner,et al.  Organic Solar Cells , 1991 .

[23]  David Braun,et al.  Semiconducting polymer‐buckminsterfullerene heterojunctions: Diodes, photodiodes, and photovoltaic cells , 1993 .

[24]  Dieter Meissner,et al.  Electroabsorption studies of phthalocyanine/perylene solar cells , 2000 .

[25]  C. A. Walsh,et al.  Efficient photodiodes from interpenetrating polymer networks , 1995, Nature.

[26]  Jenny Nelson.  Organic photovoltaic films , 2002 .

[27]  L. B. Ebert.  Science of fullerenes and carbon nanotubes , 1996 .

[28]  Stephen C. Moratti,et al.  EXCITON DIFFUSION AND DISSOCIATION IN A POLY(P-PHENYLENEVINYLENE)/C60 HETEROJUNCTION PHOTOVOLTAIC CELL , 1996 .