A Micromachined Pressure Sensor with Integrated Resonator Operating at Atmospheric Pressure

A novel resonant pressure sensor with an improved micromechanical double-ended tuning fork resonator packaged in dry air at atmospheric pressure is presented. The resonator is electrostatically driven and capacitively detected, and the sensor is designed to realize a low cost resonant pressure sensor with medium accuracy. Various damping mechanisms in a resonator that is vibrating at atmospheric pressure are analyzed in detail, and a formula is developed to predict the overall quality factor. A trade-off has been reached between the quality factor, stress sensitivity and drive capability of the resonator. Furthermore, differential sense elements and the method of electromechanical amplitude modulation are used for capacitive detection to obtain a large signal-to-noise ratio. The prototype sensor chip is successfully fabricated using a micromachining process based on a commercially available silicon-on-insulator wafer and is hermetically encapsulated in a custom 16-pin Kovar package. Preliminary measurements show that the fundamental frequency of the resonant pressure sensor is approximately 34.55 kHz with a pressure sensitivity of 20.77 Hz/kPa. Over the full scale pressure range of 100–400 kPa and the whole temperature range of −20–60 °C, high quality factors from 1,146 to 1,772 are obtained. The characterization of the prototype sensor reveals the feasibility of a resonant pressure sensor packaged at atmospheric pressure.

[1]  J. Greenwood.  Silicon in mechanical sensors , 1988 .

[2]  Yoshida Takashi,et al.  Three-dimensional micromachining of silicon pressure sensor integrating resonant strain gauge on diaphragm , 1990 .

[3]  W. E. Langlois.  Isothermal squeeze films , 1961 .

[4]  R. M. Langdon,et al.  Resonator sensors-a review , 1985 .

[5]  Weiwei Xing,et al.  Non-linear dynamics of an electrothermally excited resonant pressure sensor , 2012 .

[6]  Kurt E. Petersen,et al.  Resonant beam pressure sensor fabricated with silicon fusion bonding , 1991, TRANSDUCERS '91: 1991 International Conference on Solid-State Sensors and Actuators. Digest of Technical Papers.

[7]  Kyoichi Ikeda,et al.  Various applications of resonant pressure sensor chip based on 3-D micromachining , 1999 .

[8]  P. Parsons,et al.  Resonant sensor for high accuracy pressure measurement using silicon technology , 1992 .

[9]  M. K. Andrews,et al.  A resonant pressure sensor based on a squeezed film of gas , 1993 .

[10]  William C. Tang,et al.  Viscous air damping in laterally driven microresonators , 1994, Proceedings IEEE Micro Electro Mechanical Systems An Investigation of Micro Structures, Sensors, Actuators, Machines and Robotic Systems.

[11]  Peter Enoksson,et al.  A low-pressure encapsulated deep reactive ion etched resonant pressure sensor electrically excited and detected using `burst' technology , 2000 .

[12]  Jan Věříš,et al.  Temperature compensation of silicon resonant pressure sensor , 1996 .

[13]  Junbo Wang,et al.  Stress Isolation Used In MEMS Resonant Pressure Sensor Package , 2011 .

[14]  Shanhong Xia,et al.  Design and modeling of a silicon nitride beam resonant pressure sensor for temperature compensation , 2005, 2005 IEEE International Conference on Information Acquisition.

[15]  D. Angelidis,et al.  Resonant sensors for high accuracy pressure measurement using silicon technology , 1992, Proceedings of the IEEE 1992 National Aerospace and Electronics Conference@m_NAECON 1992.

[16]  Olivier Lefort,et al.  A new micromachined silicon high-accuracy pressure sensor , 1995 .

[17]  M. Agarwal,et al.  Temperature Dependence of Quality Factor in MEMS Resonators , 2006, Journal of Microelectromechanical Systems.

[18]  A. Fourrier,et al.  Stable and Reliable Q-Factor in Resonant MEMS with Getter Film , 2006, 2006 IEEE International Reliability Physics Symposium Proceedings.

[19]  Junbo Wang,et al.  A novel laterally driven micromachined resonant pressure sensor , 2010, 2010 IEEE Sensors.

[20]  Shanhong Xia,et al.  Thermally excited SiN beam resonant pressure sensor , 2001, Symposium on Design, Test, Integration, and Packaging of MEMS/MOEMS.

[21]  Jacob K. White,et al.  Air damping in laterally oscillating microresonators: a numerical and experimental study , 2003 .

[22]  Vladimir Vaganov,et al.  Construction problems in sensors , 1991 .

[23]  Junbo Wang,et al.  Design and experiment of a laterally driven micromachined resonant pressure sensor for barometers , 2010 .

[24]  William A. Wakeham,et al.  Validation of an accurate vibrating-wire densimeter: Density and viscosity of liquids over wide ranges of temperature and pressure , 1996 .

[25]  Henrik Jakobsen,et al.  An integrated resonant accelerometer microsystem for automotive applications , 1997, Proceedings of International Solid State Sensors and Actuators Conference (Transducers '97).

[26]  William A. Wakeham,et al.  Electromechanical model for vibrating-wire instruments , 1998 .

[27]  Junbo Wang,et al.  A micromachined resonant pressure sensor with DETFs resonator and differential structure , 2009, 2009 IEEE Sensors.

[28]  Steve Beeby.  Resonance: picking up good vibrations , 1996 .

[29]  Julian W. Gardner,et al.  A laterally driven micromachined resonant pressure sensor , 1996 .

[30]  Diogenes Thomas Angelidis,et al.  Optical micromachined pressure sensor for aerospace applications , 1992 .

[31]  Junbo Wang,et al.  A novel resonant pressure sensor with boron diffused silicon resonator , 2009, International Conference on Optical Instruments and Technology.

[32]  K. Ikeda,et al.  Silicon pressure sensor integrates resonant strain gauge on diaphragm , 1990 .

[33]  P. Kinnell,et al.  Advances in Silicon Resonant Pressure Transducers , 2009 .

[34]  Liu Haobing,et al.  Layout controlled one-step dry etch and release of MEMS using deep RIE on SOI wafer , 2006, Journal of Microelectromechanical Systems.

[35]  John Greenwood,et al.  High accuracy pressure measurement with a silicon resonant sensor , 1993 .

[36]  S. Sherman,et al.  Single-chip surface micromachined integrated gyroscope with 50°/h Allan deviation , 2002, IEEE J. Solid State Circuits.

[37]  J. Marek,et al.  A precision yaw rate sensor in silicon micromachining , 1997 .

[38]  Y. Zhuang,et al.  Improved oxytetracycline production in Streptomyces rimosus M4018 by metabolic engineering of the G6PDH gene in the pentose phosphate pathway. , 2011, Enzyme and microbial technology.

[39]  J. Greenwood,et al.  A high accuracy resonant pressure sensor by fusion bonding and trench etching , 1999 .

[40]  John Greenwood,et al.  Miniature silicon resonant pressure sensor , 1988 .

[41]  David W. Burns,et al.  Sealed-cavity resonant microbeam pressure sensor , 1995 .

[42]  Shangchun Fan,et al.  An electrothermally excited dual beams silicon resonant pressure sensor with temperature compensation , 2011 .