Room-temperature hydrogen sensor based on palladium nanowires

Palladium (Pd) nanowires, synthesized by template-nanomanufacturing techniques, has been studied for hydrogen gas-sensing applications at room temperature. In this study, parallel arrays of Pd nanowires were fabricated by electrodeposition from an aqueous plating solution onto the surface of highly oriented pyrolytic graphite (HOPG). The nanowires were then transferred onto a polystyrene film and silver electrical contact pads were fabricated by shadow masking. The morphology of the nanowires was analyzed using atomic force microscope (AFM) in noncontact mode and the diameter of the observed nanowires was measured to be approximately 250 nm. Scanning electron microscope (SEM) images revealed that the nanowires fabricated by this procedure were parallel and continuous. Electrodes were patterned by shadow masking and the I-V characteristics of the nanowires were studied. Experimental results indicated that the sensors are highly sensitive to hydrogen, showing a two-order change in conductance. The morphology of the nanowires was analyzed using SEM and AFM in order to understand the properties responsible for the high sensitivity of the nanowires. SEM images showed that the nanowires contain nanogaps in absence of H/sub 2/. Upon exposure to H/sub 2/, the Pd absorbed hydrogen, resulting in the expansion of Pd grains. This expansion results in the closing of the nanogaps. The expansion occurred due to the phase transition from /spl alpha/ to /spl beta/ and the Pd lattice expansion.

[1]  M. Atashbar,et al.  Mechanical and electrical characterization of /spl beta/-Ga/sub 2/O/sub 3/ nanostructures for sensing applications , 2005, IEEE Sensors Journal.

[2]  M. Atashbar,et al.  Mechanical and electrical characterization of beta-Ga2O3 nanostructures for sensing applications , 2005 .

[3]  Palladium nanowire hydrogen sensor , 2003, Proceedings of IEEE Sensors 2003 (IEEE Cat. No.03CH37498).

[4]  An innovative approach to gas sensing using carbon nanotubes thin films: sensitivity, selectivity and stability response analysis , 2003, Proceedings of IEEE Sensors 2003 (IEEE Cat. No.03CH37498).

[5]  S. C. Pyke,et al.  Resolution of hydrogen and carbon monoxide on metal gate GaN MODFET sensors , 2003, Proceedings of IEEE Sensors 2003 (IEEE Cat. No.03CH37498).

[6]  I. Eisele,et al.  Combined ammonia and hydrogen gas sensor , 2003, Proceedings of IEEE Sensors 2003 (IEEE Cat. No.03CH37498).

[7]  Chun-Sing Lee,et al.  Silicon nanowires as chemical sensors , 2003 .

[8]  Qian Wang,et al.  Toward Large Arrays of Multiplex Functionalized Carbon Nanotube Sensors for Highly Sensitive and Selective Molecular Detection. , 2003, Nano letters.

[9]  L. Chan,et al.  The formation and characterization of palladium nanowires in growing carbon nanotubes using microwave plasma-enhanced chemical vapor deposition , 2003 .

[10]  Single-electron transistor structures based on silicon-on-insulator silicon nanowire fabrication by scanning probe lithography and wet etching , 2002 .

[11]  M. Grunze,et al.  Noble and Coinage Metal Nanowires by Electrochemical Step Edge Decoration , 2002 .

[12]  Polysilicon mesoscopic wires coated by Pd as high sensitivity H2 sensors , 2002 .

[13]  R. Lauf.  Development of Low-cost Hydrogen Sensors , 2001 .

[14]  C. Lieber,et al.  Nanowire Nanosensors for Highly Sensitive and Selective Detection of Biological and Chemical Species , 2001, Science.

[15]  R. Chen,et al.  Carbon Nanotube Chemical and Mechanical Sensors , 2001 .

[16]  R. Penner,et al.  Molybdenum nanowires by electrodeposition. , 2000, Science.

[17]  Kong,et al.  Nanotube molecular wires as chemical sensors , 2000, Science.

[18]  H. Meixner,et al.  Comparision of a.c. and d.c. measurement techniques using semiconducting Ga2O3 sensors , 1995 .

[19]  R. Vasquez.  Highly Oriented Pyrolytic Graphite by XPS , 1992 .

[20]  A. Moore.  HIGHLY ORIENTED PYROLYTIC GRAPHITE AND ITS INTERCALATION COMPOUNDS , 1981 .

[21]  F. A. Lewis,et al.  The Palladium-Hydrogen System , 1967, Platinum Metals Review.