Numerical investigation on integrated system of mechanical refrigeration and thermosyphon for free cooling of data centers

Abstract The cooling energy consumption of data centers is increasing rapidly and free cooling attracts growing concern. To achieve the independent running of free cooling system all the year round, integrated system of mechanical refrigeration and thermosyphon (ISMT) is an ideal method. In this study, a distributed-parameter simulation model of an ISMT is built and validated by experimental data. The simulation results show that for thermosyphon mode, the cooling capacity increases with increasing air flow rate, temperature difference and pipe diameter, while decreases with increasing pipe length. For refrigeration mode, decreasing outdoor air temperature or increasing indoor air flow rate will improve the cooling capacity and reduce the input power of the compressor. For dual mode, applicable outdoor temperature range and indoor air flow rate range exist and the cooling capacity drops below that of refrigeration mode beyond these ranges. The critical values are 19 °C and 0.5 m 3  s −1 , respectively.

[1]  Clark W. Bullard,et al.  Air-side thermal hydraulic performance of multi-louvered fin aluminum heat exchangers , 2002 .

[2]  Sandeep K. S. Gupta,et al.  Thermodynamic feasibility of harvesting data center waste heat to drive an absorption chiller , 2012 .

[3]  G. Rovelli,et al.  Determination of aerosol deliquescence and crystallization relative humidity for energy saving in free-cooled data centers , 2015, International Journal of Environmental Science and Technology.

[4]  Harvey Thompson,et al.  Computational fluid dynamic investigation of liquid rack cooling in data centres , 2012 .

[5]  Takashi Okazaki,et al.  Development of vapor compression refrigeration cycle with a natural-circulation loop , 1999 .

[6]  X. Tian,et al.  Investigation into the energy consumption of a data center with a thermosyphon heat exchanger , 2011 .

[7]  Baolong Wang,et al.  Energy consumption model of integrated air conditioner with thermosyphon in mobile phone base station. , 2014 .

[8]  Guoyuan Ma,et al.  Energy-saving analysis of telecommunication base station with thermosyphon heat exchanger , 2013 .

[9]  Hao Tian,et al.  A combined cooling solution for high heat density data centers using multi-stage heat pipe loops , 2015 .

[10]  Jinkyun Cho,et al.  Measurements and predictions of the air distribution systems in high compute density (Internet) data centers , 2009 .

[11]  J. Koomey.  Worldwide electricity used in data centers , 2008 .

[12]  Michael Pecht,et al.  A multiple stage approach to mitigate the risks of telecommunication equipment under free air cooling conditions , 2012 .

[13]  Xianting Li,et al.  Heat recovery from Internet data centers for space heating based on an integrated air conditioner with thermosyphon , 2015 .

[14]  Suresh V. Garimella,et al.  Technological drivers in data centers and telecom systems: Multiscale thermal, electrical, and energy management , 2013 .

[15]  S. Patankar.  Airflow and Cooling in a Data Center , 2010 .

[16]  Eric Arquis,et al.  Simulation of a temperature adaptive control strategy for an IWSE economizer in a data center , 2014 .

[17]  Zhang Hainan,et al.  Free cooling of data centers: A review , 2014 .

[18]  Mi Sandar Mon,et al.  Heat Exchanger Design , 2008 .

[19]  Zhang Hainan,et al.  Integrated system of mechanical refrigeration and thermosyphon for free cooling of data centers , 2015 .

[20]  Stéphane Le Masson,et al.  Two-phase thermosyphon loop for cooling outdoor telecommunication equipments , 2013 .

[21]  R. Lockhart.  Proposed Correlation of Data for Isothermal Two-Phase, Two-Component Flow in Pipes , 1949 .

[22]  H. Jaster,et al.  Condensation heat transfer in a mixed flow regime , 1976 .

[23]  Baolong Wang,et al.  Development of an integrated air conditioner with thermosyphon and the application in mobile phone base station , 2013 .

[24]  Xiaodong Qian,et al.  Entransy and exergy analyses of airflow organization in data centers , 2015 .

[25]  Ashok A. Kaniyal,et al.  The potential role of data-centres in enabling investment in geothermal energy , 2012 .

[26]  S. Kandlikar.  A General Correlation for Saturated Two-Phase Flow Boiling Heat Transfer Inside Horizontal and Vertical Tubes , 1990 .

[27]  Jackson Braz Marcinichen,et al.  Two-phase Cooling of Datacenters: Reduction in Energy Costs and Improved Efficiencies , 2010 .

[28]  M. Shah.  A general correlation for heat transfer during film condensation inside pipes , 1979 .

[29]  Hoon Kang,et al.  Performance optimization of a hybrid cooler combining vapor compression and natural circulation cycles , 2009 .

[30]  Masud Behnia,et al.  Cooling solutions in an operational data centre: A case study , 2011 .

[31]  Zhen Li,et al.  Modelling and applications of annual energy-using simulation module of separated heat pipe heat exchanger , 2013 .

[32]  Cullen E. Bash,et al.  Computational Fluid Dynamics Modeling of High Compute Density Data Centers to Assure System Inlet Air Specifications , 2001 .

[33]  Marco Moscatelli,et al.  Aerosol corrosion prevention and energy-saving strategies in the design of green data centers. , 2013, Environmental science & technology.

[34]  G. I. Meijer,et al.  Cooling Energy-Hungry Data Centers , 2010, Science.

[35]  Sašo Medved,et al.  Parametric study on the advantages of weather-predicted control algorithm of free cooling ventilation system , 2014 .