The Jeffcott rotor is a two-degree-of-freedom linear model with a disk at the midspan of a massless elastic shaft. This model, executing lateral whirling motions, has been widely used in the linear analyses of rotor vibrations. In the Jeffcott rotor, the natural frequency of a forward-whirling mode p f (>0) and that of a backward-whirling mode p b (<0) have the relation of internal resonance p f :p b = 1: (-1). Recently, many researchers analyzed nonlinear phenomena by using the Jeffcott rotor with nonlinear elements. However, they did not take this internal resonance relationship into account. Furthermore in many practical rotating machines, the effect of gyroscopic moments are relatively small. Therefore, the one-to-one internal resonance relationship holds approximately between forward and backward natural frequencies in such machinery. In this paper, nonlinear phenomena in the vicinity of the major critical speed and the rotational speeds of twice and three times the major critical speed are investigated in the Jeffcott rotor and rotor systems with a small gyroscopic moment. The influences of internal resonance on the nonlinear resonances are studied in detail. The following were clarified theoretically and experimentally: (a) the shape of resonance curves becomes far more complex than that of a single resonance; (b) almost periodic motions occur; (c) these phenomena are influenced remarkably by the asymmetrical nonlinearity and gyroscopic moment; and (d) the internal resonance phenomena are strongly influenced by the degree of the discrepancies among critical speeds. The results teach us that the usage of the Jeffcott rotor in nonlinear analyses of rotor systems may induce incorrect results.
[1]
Yukio Ishida,et al.
Theoretical discussions on vibrations of a rotating shaft with nonlinear spring characteristics
,
1977
.
[2]
S. T. Noah,et al.
Bifurcation analysis for a modified Jeffcott rotor with bearing clearances
,
1990
.
[3]
Yukio Ishida,et al.
Nonlinear Vibrations and Chaos in Rotordynamics
,
1994
.
[4]
J. J. Stoker.
Nonlinear Vibrations in Mechanical and Electrical Systems
,
1950
.
[5]
F. F. Ehrich,et al.
High Order Subharmonic Response of High Speed Rotors in Bearing Clearance
,
1988
.
[6]
Ali H. Nayfeh,et al.
Modal Interactions in Dynamical and Structural Systems
,
1989
.
[7]
P. R. Sethna.
Steady-State Undamped Vibrations of a Class of Nonlinear Discrete Systems
,
1960
.
[8]
Kimihiko Yasuda,et al.
On the Internal Resonance in a Nonlinear Two-Degree-of-Freedom System : Forced Vibrations Near the Lower Resonance Point When the Natural Frequencies are in the Ratio 1 : 2
,
1977
.
[9]
Yukio Ishida,et al.
Super-Summed-and-Differential Harmonic Oscillations in a Symmetrical Rotating Shaft System
,
1984
.