Layer-by-layer assembly of graphene oxide membranes via electrostatic interaction

Abstract We fabricated a novel type of water purification membrane by layer-by-layer assembling negatively charged graphene oxide (GO) nanosheets on a porous poly(acrylonitrile) support and interconnecting them with positively charged poly(allylamine hydrochloride) (PAH) via electrostatic interaction. A series of characterization techniques were used to confirm the successful assembly of multiple GO–PAH bilayers, quantify their composition and thickness, and understand the structure of the GO membrane. Quartz crystal microbalance-dissipation (QCM-D) results showed that each GO–PAH bilayer in the membrane is around 16.5 nm thick and dominated by GO (mass of GO is 2–5 times higher than that of PAH), indicating multiple layers of GO nanosheets exist in each bilayer. This is most likely because the mass-to-charge ratio of GO is much higher than that of PAH. Transport of water and selected solutes in the GO membrane was investigated in a pressurized system and also in a forward osmosis (FO) and pressure retarded osmosis (PRO) system. Water permeability of the GO membrane was found to be about one order of magnitude higher than that of a commercial FO membrane. The solute flux of the GO membrane for sucrose (as a representative uncharged species) was much lower than that for an ionic species, although the hydrated radius of the ions is comparable to that of sucrose. This is most likely because the GO–PAH bilayers tend to swell in ionic solutions. In solutions of low ionic strength, the GO membrane retained a tight structure and exhibited high rejection to sucrose (~99%), indicating an MWCO of around 342 or an equivalent pore size of around 1 nm. Therefore, at the present stage, the GO membrane can be well suited for applications such as FO-based emergency water purification using sugary draw solutions and water treatment not requiring high ionic strength.

[1]  Menachem Elimelech,et al.  Global challenges in energy and water supply: the promise of engineered osmosis. , 2008, Environmental science & technology.

[2]  Paula T. Hammond,et al.  Recent explorations in electrostatic multilayer thin film assembly , 1999 .

[3]  M. Elimelech,et al.  Organic fouling of forward osmosis membranes: Fouling reversibility and cleaning without chemical reagents , 2010 .

[4]  Baoxia Mi,et al.  Enabling graphene oxide nanosheets as water separation membranes. , 2013, Environmental science & technology.

[5]  S. Stankovich,et al.  Preparation and characterization of graphene oxide paper , 2007, Nature.

[6]  Guojun Zhang,et al.  Self-assembly of polyelectrolyte multilayer pervaporation membranes by a dynamic layer-by-layer technique on a hydrolyzed polyacrylonitrile ultrafiltration membrane , 2007 .

[7]  R. Ruoff,et al.  The chemistry of graphene oxide. , 2010, Chemical Society reviews.

[8]  L. Krasemann.  Self-assembled polyelectrolyte multilayer membranes with highly improved pervaporation separation of ethanol/water mixtures , 2001 .

[9]  B. D. Todd,et al.  Interfacial slip friction at a fluid-solid cylindrical boundary. , 2012, The Journal of chemical physics.

[10]  Linda Zou,et al.  Recent developments in forward osmosis : opportunities and challenges. , 2012 .

[11]  J. Grossman,et al.  Water desalination across nanoporous graphene. , 2012, Nano letters.

[12]  Chuyang Y. Tang,et al.  Synthesis and characterization of novel forward osmosis membranes based on layer-by-layer assembly. , 2011, Environmental science & technology.

[13]  J. Schlenoff,et al.  Polyelectrolyte Multilayers Containing a Weak Polyacid: Construction and Deconstruction , 2001 .

[14]  Gero Decher,et al.  Fuzzy Nanoassemblies: Toward Layered Polymeric Multicomposites , 1997 .

[15]  Imre Dékány,et al.  Evolution of surface functional groups in a series of progressively oxidized graphite oxides , 2006 .

[16]  I. V. Grigorieva,et al.  Precise and Ultrafast Molecular Sieving Through Graphene Oxide Membranes , 2014, Science.

[17]  Chuyang Y. Tang,et al.  Synthesis of high flux forward osmosis membranes by chemically crosslinked layer-by-layer polyelectr , 2011 .

[18]  Lu Ouyang,et al.  Multilayer polyelectrolyte films as nanofiltration membranes for separating monovalent and divalent cations , 2008 .

[19]  Xue Li,et al.  Emerging forward osmosis (FO) technologies and challenges ahead for clean water and clean energy applications , 2012 .

[20]  Chuyang Y. Tang,et al.  Characterization of novel forward osmosis hollow fiber membranes , 2010 .

[21]  Chao Gao,et al.  Ultrathin Graphene Nanofiltration Membrane for Water Purification , 2013 .

[22]  Amy E. Childress,et al.  Forward osmosis: Principles, applications, and recent developments , 2006 .

[23]  N. Kotov,et al.  Ultrathin graphite oxide–polyelectrolyte composites prepared by self‐assembly: Transition between conductive and non‐conductive states , 1996 .

[24]  Restructuring of Graphene Oxide Sheets into Monodisperse Nanospheres , 2012 .

[25]  Michael F. Rubner,et al.  pH-Dependent Thickness Behavior of Sequentially Adsorbed Layers of Weak Polyelectrolytes , 2000 .

[26]  Shaomin Liu,et al.  Graphene facilitated visible light photodegradation of methylene blue over titanium dioxide photocatalysts , 2013 .

[27]  Baoxia Mi,et al.  Graphene Oxide Membranes for Ionic and Molecular Sieving , 2014, Science.

[28]  Cong-jie Gao,et al.  Surface modification of thin film composite polyamide membranes by electrostatic self deposition of polycations for improved fouling resistance , 2009 .

[29]  Menachem Elimelech,et al.  Relating performance of thin-film composite forward osmosis membranes to support layer formation and , 2011 .

[30]  M. Bruening,et al.  High-flux nanofiltration membranes prepared by adsorption of multilayer polyelectrolyte membranes on polymeric supports. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[31]  I. Grigorieva,et al.  Unimpeded Permeation of Water Through Helium-Leak–Tight Graphene-Based Membranes , 2011, Science.

[32]  W. Lu,et al.  Improved synthesis of graphene oxide. , 2010, ACS nano.

[33]  I. Vankelecom,et al.  Multilayered polyelectrolyte complex based solvent resistant nanofiltration membranes prepared from weak polyacids , 2012 .

[34]  G. Wallace,et al.  Processable aqueous dispersions of graphene nanosheets. , 2008, Nature nanotechnology.

[35]  Menachem Elimelech,et al.  High performance thin-film composite forward osmosis membrane. , 2010, Environmental science & technology.

[36]  P. J. Ollivier,et al.  Layer-by-Layer Assembly of Ultrathin Composite Films from Micron-Sized Graphite Oxide Sheets and Polycations , 1999 .

[37]  Merlin L. Bruening,et al.  Ultrathin, Multilayered Polyelectrolyte Films as Nanofiltration Membranes , 2003 .

[38]  R. Hoogenboom,et al.  Layer-by-layer preparation of polyelectrolyte multilayer membranes for separation , 2014 .

[39]  Johannes Schmitt,et al.  Fine-Tuning of the film thickness of ultrathin multilayer films composed of consecutively alternating layers of anionic and cationic polyelectrolytes , 1992 .

[40]  O. Coronell,et al.  Reliable, bench-top measurements of charge density in the active layers of thin-film composite and nanocomposite membranes using quartz crystal microbalance technology , 2013 .

[41]  Tom Depuydt,et al.  Forward and pressure retarded osmosis: potential solutions for global challenges in energy and water supply. , 2013, Chemical Society reviews.

[42]  Ngai Yin Yip,et al.  Thin-film composite pressure retarded osmosis membranes for sustainable power generation from salinity gradients. , 2011, Environmental science & technology.

[43]  Wanqin Jin,et al.  Use of Polyelectrolyte Layer-by-Layer Assemblies as Nanofiltration and Reverse Osmosis Membranes , 2003 .

[44]  Dan Li,et al.  Controllable corrugation of chemically converted graphene sheets in water and potential application for nanofiltration. , 2011, Chemical communications.