Fault diagnosis and robust fault-tolerant control for linear over-actuated systems

This paper proposes a novel fault diagnosis and robust fault-tolerant control strategy for over-actuated systems which subject to actuator faults. Firstly, the considered fault is formulated into an additive term (which is referred to as virtual fault). Then an augmented state observer is used to estimate this virtual additive fault. To achieve fault isolation and estimation for the over-actuated system, which is more difficult than that of an ordinary system, this paper considers the actuator fault as a sparse signal and proposes a constrained sparse optimization approach to recover the actual multiplicative fault in the over-actuated system. Based on the fault diagnosis result, a robust fault-tolerant controller is designed by the virtual actuator approach, which aims to construct a reconfiguration block to force the output of the reconfigured faulty plant approximated the behavior of a nominal system. Finally, the proposed fault diagnosis and fault-tolerant scheme is applied to an ADMIRE model. Simulation results demonstrate the effectiveness of the proposed method.

[1]  Tor Arne Johansen,et al.  Fault tolerant control allocation using unknown input observers , 2014, Autom..

[2]  Aihua Zhang,et al.  Finite-time fault tolerant attitude control for over-activated spacecraft subject to actuator misalignment and faults , 2013 .

[3]  Yi Shen,et al.  Integrated Adaptive Fault-Tolerant H Infinity Output Feedback Control with Adaptive Fault Identification , 2012 .

[4]  J.-Y. Keller.  Fault isolation filter design for linear stochastic systems , 1999, Autom..

[5]  Bo Li,et al.  Robust attitude control design for spacecraft under assigned velocity and control constraints. , 2013, ISA transactions.

[6]  John L. Crassidis,et al.  Predictive Filtering for Nonlinear Systems , 1996 .

[7]  Didier Theilliol,et al.  Fault-tolerant Control Systems: Design and Practical Applications , 2009 .

[8]  Marcel Staroswiecki,et al.  Fault Accommodation for Nonlinear Dynamic Systems , 2006, IEEE Transactions on Automatic Control.

[9]  Jan H. Richter,et al.  Reconfigurable Control of Nonlinear Dynamical Systems: A fault-hiding Approach , 2011 .

[10]  Ke Zhang,et al.  Fast fault estimation and accommodation for dynamical systems , 2009 .

[11]  Yi Shen,et al.  Adaptive fault-tolerant robust control for a linear system with adaptive fault identification , 2013 .

[12]  Hong Wang,et al.  Actuator fault diagnosis: an adaptive observer-based technique , 1996, IEEE Trans. Autom. Control..

[13]  Thomas Steffen,et al.  Control Reconfiguration of Dynamical Systems: Linear Approaches and Structural Tests , 2005 .

[14]  Nathan van de Wouw,et al.  Reconfigurable control of piecewise affine systems with actuator and sensor faults: Stability and tracking , 2011, Autom..

[15]  Paul M. Frank,et al.  Fault diagnostics and fault tolerant control , 1998 .

[16]  Didier Theilliol,et al.  Virtual sensors design to active fault tolerant control system applied to a winding machine , 2010 .

[17]  Damiano Rotondo,et al.  A virtual actuator and sensor approach for fault tolerant control of LPV systems , 2014 .

[18]  Youmin Zhang,et al.  Optimal reliability design for over-actuated systems based on the MIT rule: Application to an octocopter helicopter testbed , 2014, Reliab. Eng. Syst. Saf..

[19]  Mohammad Javad Khosrowjerdi,et al.  Fault tolerant control using virtual actuator for continuous‐time Lipschitz nonlinear systems , 2014 .

[20]  J. Lunze,et al.  Reconfigurable control of Hammerstein systems after actuator failures: stability, tracking, and performance , 2010, Int. J. Control.

[21]  Yi Shen,et al.  Fault Diagnosis for Satellite Attitude Control Systems With Four Flywheels , 2014 .

[22]  Jie Chen,et al.  Robust Model-Based Fault Diagnosis for Dynamic Systems , 1998, The International Series on Asian Studies in Computer and Information Science.

[23]  Bin Jiang,et al.  Fault estimation and accommodation for linear MIMO discrete-time systems , 2005, IEEE Transactions on Control Systems Technology.

[24]  Damiano Rotondo,et al.  Model reference FTC for LPV systems using virtual actuators and set‐membership fault estimation , 2015 .

[25]  Mariem Sahnoun,et al.  Sensor fault detection and isolation filter for polytopic LPV systems: A winding machine application , 2013 .

[26]  Joel A. Tropp,et al.  Signal Recovery From Random Measurements Via Orthogonal Matching Pursuit , 2007, IEEE Transactions on Information Theory.

[27]  Jan H. Richter,et al.  Reconfigurable Control of Nonlinear Dynamical Systems , 2011 .

[28]  Youmin Zhang,et al.  Active fault-tolerant control system against partial actuator failures , 2002 .

[29]  Danny Dolev,et al.  Fault Identification Via Nonparametric Belief Propagation , 2009, IEEE Transactions on Signal Processing.

[30]  Ke Zhang,et al.  Observer-based integrated robust fault estimation and accommodation design for discrete-time systems , 2010, Int. J. Control.

[31]  Didier Theilliol,et al.  Fault diagnosis and accommodation of a three-tank system based on analytical redundancy. , 2002, ISA transactions.

[32]  Youmin Zhang,et al.  Bibliographical review on reconfigurable fault-tolerant control systems , 2003, Annu. Rev. Control..

[33]  Youmin Zhang,et al.  Robust Fault-Tolerant Control using on-line control re-allocation with application to aircraft , 2009, 2009 American Control Conference.