Removal of Escherichia coli by Intermittent Operation of Saturated Sand Columns Supplemented with Hydrochar Derived from Sewage Sludge

Hydrothermal carbonization (HTC) technology can convert various types of waste biomass into a carbon-rich product referred to as hydrochar. In order to verify the potential of hydrochar produced from stabilized sewage sludge to be an adsorbent for bacterial pathogen removal in water treatment, the Escherichia coli’s removal efficiency was determined by using 10 cm sand columns loaded with 1.5% (w/w) hydrochar. Furthermore, the removal of E. coli based on intermittent operation in larger columns of 50 cm was measured for 30 days. Since the removal of E. coli was not sufficient when the sand columns were supplemented with raw hydrochar, an additional cold-alkali activation of the hydrochar using potassium hydroxide was applied. This enabled more than 90% of E. coli removal in both the 10 cm and 50 cm column experiments. The enhancement of the E. coli removal efficiency could be attributed to the more hydrophobic surface of the KOH pre-treated hydrochar. The idle time during the intermittent flushing experiments in the sand-only columns without the hydrochar supplement had a significant effect on the E. coli removal (p < 0.05), resulting in a removal efficiency of 55.2%. This research suggested the possible utilization of hydrochar produced from sewage sludge as an adsorbent in water treatment for the removal of bacterial contaminants.

[1]  J. Yanik,et al.  Characterization of products from hydrothermal carbonization of orange pomace including anaerobic digestibility of process liquor. , 2015, Bioresource technology.

[2]  J. Schijven,et al.  Evaluation of data from the literature on the transport and survival of Escherichia coli and thermotolerant coliforms in aquifers under saturated conditions. , 2006, Water research.

[3]  C. Gerba,et al.  Effect of particulates on virus survival in seawater. , 1975, Journal - Water Pollution Control Federation.

[4]  E. Unur.  Functional nanoporous carbons from hydrothermally treated biomass for environmental purification , 2013 .

[5]  M. Sobsey,et al.  Characterisation of the biosand filter for E. coli reductions from household drinking water under controlled laboratory and field use conditions. , 2006, Water science and technology : a journal of the International Association on Water Pollution Research.

[6]  Rajasekhar Balasubramanian,et al.  Hydrothermal carbonization of sewage sludge for energy production with coal , 2013 .

[7]  A. Funke,et al.  Hydrothermal carbonization of biomass: A summary and discussion of chemical mechanisms for process engineering , 2010 .

[8]  A. W. Bhutto,et al.  Hydrothermal carbonization of oil palm shell , 2015, Korean Journal of Chemical Engineering.

[9]  Mark D Sobsey,et al.  Point of use household drinking water filtration: A practical, effective solution for providing sustained access to safe drinking water in the developing world. , 2009, Environmental science & technology.

[10]  Jingchun Tang,et al.  Characterization of potassium hydroxide (KOH) modified hydrochars from different feedstocks for enhanced removal of heavy metals from water , 2015, Environmental Science and Pollution Research.

[11]  D. Ludlow.  Activated Carbon Adsorption , 2006 .

[12]  Y Imae,et al.  Effect of temperature on motility and chemotaxis of Escherichia coli , 1976, Journal of bacteriology.

[13]  T. Schmidt,et al.  Pharmaceutical load in sewage sludge and biochar produced by hydrothermal carbonization. , 2015, The Science of the total environment.

[14]  S. Uhlenbrook,et al.  Determining minimum sticking efficiencies of six environmental Escherichia coli isolates. , 2009, Journal of contaminant hydrology.

[15]  N. Berge,et al.  Hydrothermal carbonization of biomass residuals: a comparative review of the chemistry, processes and applications of wet and dry pyrolysis , 2011 .

[16]  To Ngai,et al.  Investigation of the Effect of Grain Size, Flow Rate and Diffuser Design on the CAWST Biosand Filter Performance , 2015 .

[17]  Byoung-Gon Kim,et al.  Characteristics of the Treated Ground Calcium Carbonate Powder with Stearic Acid Using the Dry Process Coating System , 2009 .

[18]  L. Lefferts,et al.  Development of monolith with a carbon-nanofiber-washcoat as a structured catalyst support in liquid phase , 2003 .

[19]  G Shama,et al.  Hydrothermal carbonisation of sewage sludge: effect of process conditions on product characteristics and methane production. , 2015, Bioresource technology.

[20]  G. W. Small.  Spectrometric Identification of Organic Compounds , 1992 .

[21]  Byron James Buzunis,et al.  Intermittently operated slow sand filtration: a new water treatment process , 1995 .

[22]  John C. Buckhouse,et al.  Indicator Bacterial Survival in Stream Sediments , 1992 .

[23]  I. Tan,et al.  Mesoporous and adsorptive properties of palm date seed activated carbon prepared via sequential hydrothermal carbonization and sodium hydroxide activation , 2015 .

[24]  G. A. Burton,et al.  Survival of pathogenic bacteria in various freshwater sediments , 1987, Applied and environmental microbiology.

[25]  M. Sillanpää,et al.  Adsorption behavior of hydrothermally treated municipal sludge & pulp and paper industry sludge. , 2013, Bioresource technology.

[26]  Pusker Regmi,et al.  Removal of copper and cadmium from aqueous solution using switchgrass biochar produced via hydrothermal carbonization process. , 2012, Journal of environmental management.

[27]  Robin J. White,et al.  Black perspectives for a green future: hydrothermal carbons for environment protection and energy storage , 2012 .

[28]  A. B. Fuertes,et al.  Chemical and structural properties of carbonaceous products obtained by hydrothermal carbonization of saccharides. , 2009, Chemistry.

[29]  Jay X. Tang,et al.  Amplified effect of Brownian motion in bacterial near-surface swimming , 2008, Proceedings of the National Academy of Sciences.

[30]  P. Lens,et al.  Removal of rotavirus and adenovirus from artificial ground water using hydrochar derived from sewage sludge , 2015, Journal of applied microbiology.

[31]  Xingzhong Yuan,et al.  The migration and transformation behaviors of heavy metals during the hydrothermal treatment of sewage sludge. , 2016, Bioresource technology.

[32]  N J D Graham,et al.  Sewage sludge-based adsorbents: a review of their production, properties and use in water treatment applications. , 2009, Water research.

[33]  Anastasia Zabaniotou,et al.  Utilization of sewage sludge in EU application of old and new methods--A review , 2008 .

[34]  M. Titirici,et al.  Characterization of Hydrothermal Carbonization Materials , 2013 .

[35]  M. Sobsey,et al.  Reductions of E. coli, echovirus type 12 and bacteriophages in an intermittently operated household-scale slow sand filter. , 2008, Water research.

[36]  M. Sobsey,et al.  Virus attenuation by microbial mechanisms during the idle time of a household slow sand filter. , 2011, Water research.

[37]  J. Mumme,et al.  Influence of digestion temperature and organic loading rate on the continuous anaerobic treatment of process liquor from hydrothermal carbonization of sewage sludge. , 2015, Bioresource technology.

[38]  Xiaowei Lu,et al.  Thermal conversion of municipal solid waste via hydrothermal carbonization: comparison of carbonization products to products from current waste management techniques. , 2012, Waste management.

[39]  M. Barnett,et al.  An Assessment of U(VI) removal from groundwater using biochar produced from hydrothermal carbonization. , 2011, Journal of environmental management.

[40]  M. Thommes,et al.  Quenched solid density functional theory and pore size analysis of micro-mesoporous carbons , 2009 .

[41]  Rolf Krebs,et al.  Hydrothermal carbonization as an energy-efficient alternative to established drying technologies for sewage sludge : a feasibility study on a laboratory scale , 2013 .

[42]  P. Cornelius,et al.  Effect of Sediment Particle Size and Temperature on Fecal Bacteria Mortality Rates and the Fecal Coliform/Fecal Streptococci Ratio , 1996 .