Large eddy simulation of combustion characteristics in a kerosene fueled rocket-based combined-cycle engine combustor

Abstract This study reports combustion characteristics of a rocket-based combined-cycle engine combustor operating at ramjet mode numerically. Compressible large eddy simulation with liquid kerosene sprayed and vaporized is used to study the intrinsic unsteadiness of combustion in such a propulsion system. Results for the pressure oscillation amplitude and frequency in the combustor as well as the wall pressure distribution along the flow-path, are validated using experimental data, and they show acceptable agreement. Coupled with reduced chemical kinetics of kerosene, results are compared with the simultaneously obtained Reynolds–Averaged Navier–Stokes results, and show significant differences. A flow field analysis is also carried out for further study of the turbulent flame structures. Mixture fraction is used to determine the most probable flame location in the combustor at stoichiometric condition. Spatial distributions of the Takeno flame index, scalar dissipation rate, and heat release rate reveal that different combustion modes, such as premixed and non-premixed modes, coexisted at different sections of the combustor. The RBCC combustor is divided into different regions characterized by their non-uniform features. Flame stabilization mechanism, i.e., flame propagation or fuel auto-ignition, and their relative importance, is also determined at different regions in the combustor.

[1]  S. Menon,et al.  LES of Supersonic Combustion of Hydrocarbon Spray in a SCRAMJET , 2004 .

[2]  Zhang Yan,et al.  Influencing factors on the mode transition in a dual-mode scramjet , 2014 .

[3]  Ten-See Wang,et al.  Thermophysics Characterization of Kerosene Combustion , 2000 .

[4]  Gianluca Iaccarino,et al.  Characterizing the operability limits of the HyShot II scramjet through RANS simulations , 2011 .

[5]  Gaurav Tomar,et al.  Multiscale simulations of primary atomization , 2010 .

[6]  Thomas Sattelmayer,et al.  Unsteady RANS Investigation of a Hydrogen-Fueled Staged Supersonic Combustor with Lobed Injectors , 2014 .

[7]  Kevin W. Flaherty,et al.  Operability Benefits of Airbreathing Hypersonic Propulsion for Flexible Access to Space , 2010 .

[8]  Thierry Poinsot,et al.  Analysis of unsteady reacting flows and impact of chemistry description in Large Eddy Simulations of side-dump ramjet combustors , 2010 .

[9]  Ajay P. Kothari,et al.  Rocket Based Combined Cycle Hypersonic Vehicle Design for Orbital Access , 2011 .

[10]  Ning Qin,et al.  Large eddy simulation of a hydrogen-fueled scramjet combustor with dual cavity , 2015 .

[11]  Xianggeng Wei,et al.  Large Eddy Simulation of Effects of Primary Rocket jet on Low Frequency Combustion Instability in a RBCC Combustor , 2015 .

[12]  L. Gicquel,et al.  LES to Ease Understanding of Complex Unsteady Combustion Features of Ramjet Burners , 2011 .

[13]  Klaus Hannemann,et al.  Injection and mixing in a scramjet combustor: DES and RANS studies , 2013 .

[14]  T. Takeno,et al.  A numerical study on flame stability at the transition point of jet diffusion flames , 1996 .

[16]  Vigor Yang,et al.  Dynamics Combustion Characteristics in Scramjet Combustors with Transverse Fuel Injection , 2005 .

[17]  Thomas M. Krivanek,et al.  Design and Fabrication of the ISTAR Direct-Connect Combustor Experiment at the NASA Hypersonic Tunnel Facility , 2005 .

[18]  Wen Bao,et al.  Nonlinear characteristics and detection of combustion modes for a hydrocarbon fueled scramjet , 2015 .

[19]  Goro Masuya,et al.  Mechanism and Control of Combustion-Mode Transition in a Scramjet Engine , 2012 .

[20]  O. Uzol,et al.  Unsteady RANS for Simulation of High Swirling Non-Premixed Methane-Air Flame , 2014 .

[21]  Suresh Menon,et al.  Application of the localized dynamic subgrid-scale model to turbulent wall-bounded flows , 1997 .

[22]  J. Driscoll,et al.  Combustion characteristics of a dual-mode scramjet combustor with cavity flameholder , 2009 .

[23]  F. Tanner.  Liquid Jet Atomization and Droplet Breakup Modeling of Non-Evaporating Diesel Fuel Sprays , 1997 .

[24]  Heeseok Koo,et al.  LES-based Eulerian PDF approach for the simulation of scramjet combustors , 2013 .

[25]  Min Liu,et al.  A novel vibration isolation system for reaction wheel on space telescopes , 2014 .

[26]  Christer Fureby,et al.  Reacting flow in an industrial gas turbine combustor: LES and experimental analysis , 2015 .

[27]  T. Poinsot,et al.  Theoretical and numerical combustion , 2001 .

[28]  Fuhua Ma,et al.  Acoustic Characterization of an Ethylene-Fueled Scramjet Combustor with a Cavity Flameholder , 2010 .

[29]  C. Law,et al.  Chemical explosive mode analysis for a turbulent lifted ethylene jet flame in highly-heated coflow , 2012 .

[30]  Jian Li,et al.  A Comprehensive Study of Combustion Oscillations in a Hydrocarbon-Fueled Scramjet Engine , 2007 .

[31]  Daren Yu,et al.  Analysis of combustion mode and operating route for hydrogen fueled scramjet engine , 2013 .

[32]  P. Moin,et al.  A dynamic subgrid‐scale model for compressible turbulence and scalar transport , 1991 .

[33]  Jacqueline H. Chen,et al.  Direct numerical simulation of turbulent combustion: fundamental insights towards predictive models , 2005 .

[34]  Sadatake Tomioka,et al.  Multi-objective design and trajectory optimization of space transport systems with RBCC propulsion via evolutionary algorithms and pseudospectral methods , 2014 .