Experimental and numerical investigation of energy saving potential of centralized and decentralized pumping systems

Abstract In energy distribution systems, thermal energy is usually transferred by a heat carrier fluid via pumps. Improper design and unreasonable control of pumping systems result in inefficient operation which accounts for a significant part of electricity consumption in the industry. The need to save energy has been sharpened the focus on improving energy efficiency in pumping systems. The application of a decentralized pumping system with the variable-frequency drive can be considered a technological improvement that has potential in saving energy compared to the conventional centralized pumping system. In this paper, a reduced-scale experimental apparatus and computational fluid dynamic model are used to investigate the energy saving potential of decentralized and centralized pumping systems. The energy-saving potential of decentralized configuration and two types of centralized configurations are then compared. The results showed that the decentralized pumping system consumes less power than centralized pumping systems under the same conditions. When the flow rate is reduced to 80%, the power consumption of the decentralized configuration decreases by 47% while the consumption for a centralized configuration with constant pressure control decreases by only 19%. The decentralized pumping system can offer higher energy-saving potential under variable flow rate conditions, which is expected to extend to other fluid delivery systems for improving efficiency. Moreover, the computational fluid dynamic simulation results correspond well with experimental results. The maximum discrepancies of the developed model for prediction of gauge pressure and system total pressure loss are 7.2% and 9% respectively, which confirms the accuracy and applicability of this model.

[1]  Qi Cheng,et al.  Robust optimal design of chilled water systems in buildings with quantified uncertainty and reliability for minimized life-cycle cost , 2016 .

[2]  Shengwei Wang,et al.  Optimal control strategy of central air-conditioning systems of buildings at morning start period for enhanced energy efficiency and peak demand limiting , 2018 .

[3]  S. Umashankar,et al.  Real time simulation of Variable Speed Parallel Pumping system , 2017 .

[4]  Liu Yang,et al.  Thermal comfort and building energy consumption implications - A review , 2014 .

[5]  M. Wolfshtein.  The velocity and temperature distribution in one-dimensional flow with turbulence augmentation and pressure gradient , 1969 .

[6]  Andrew Kusiak,et al.  Modeling and optimization of HVAC energy consumption , 2010 .

[7]  Edward Lisowski,et al.  CFD analysis of pressure loss during flow by hydraulic directional control valve constructed from logic valves , 2013 .

[8]  Qun Chen,et al.  A direct optimal control strategy of variable speed pumps in heat exchanger networks and experimental validations , 2015 .

[9]  T. Shih,et al.  A new k-ϵ eddy viscosity model for high reynolds number turbulent flows , 1995 .

[10]  Hansjürg Leibundgut,et al.  Introduction and analysis of a concept for decentralized heat pumping in hydronic networks , 2012 .

[11]  Qun Chen,et al.  A thermal resistance-based method for the optimal design of central variable water/air volume chiller systems , 2015 .

[12]  Svend Svendsen,et al.  Improving the Dimensioning of Piping Networks and Network Layouts in Low-Energy District Heating Systems Connected to Low-Energy Buildings: A Case Study in Roskilde, Denmark , 2012 .

[13]  Shengwei Wang,et al.  A fast chiller power demand response control strategy for buildings connected to smart grid , 2015 .

[14]  B. Launder,et al.  The numerical computation of turbulent flows , 1990 .

[15]  Philip Leckner.  Ludwig's Applied Process Design for Chemical and Petrochemical Plants Volume 1, Fourth edition. By A. Kayode Coker , 2008 .

[16]  L. Parras,et al.  Numerical and experimental study of a HVAC wall diffuser , 2014 .

[17]  Shengwei Wang,et al.  Probabilistic optimal design concerning uncertainties and on-site adaptive commissioning of air-conditioning water pump systems in buildings , 2017 .

[18]  Ming Dong,et al.  Experimental performance analysis of a solar assisted ground source heat pump system under different heating operation modes , 2015 .

[19]  Arun Kumar,et al.  A review on modeling and simulation of building energy systems , 2016 .

[20]  Zhao Tianyi,et al.  On-line optimization control method based on extreme value analysis for parallel variable-frequency hydraulic pumps in central air-conditioning systems , 2012 .

[21]  Zhao Tianyi,et al.  An optimal differential pressure reset strategy based on the most unfavorable thermodynamic loop on-line identification for a variable water flow air conditioning system , 2016 .

[22]  Shengwei Wang,et al.  In-situ implementation and evaluation of an online robust pump speed control strategy for avoiding low delta-T syndrome in complex chilled water systems of high-rise buildings , 2016 .

[23]  Robert J. Moffat,et al.  Describing the Uncertainties in Experimental Results , 1988 .

[24]  Lu Zhitao,et al.  Diversity of energy-saving control strategy for a parallel chilled water pump based on variable differential pressure control in an air-conditioning system , 2015 .

[25]  G. Filo,et al.  Analysis of a proportional control valve flow coefficient with the usage of a CFD method , 2017 .

[26]  Zhenjun Ma,et al.  Supervisory and optimal control of central chiller plants using simplified adaptive models and genetic algorithm , 2011 .

[27]  S. Umashankar,et al.  A comprehensive review on energy efficiency enhancement initiatives in centrifugal pumping system , 2016 .

[28]  Pawel Olszewski,et al.  Parametric analysis of pumping station with parallel-configured centrifugal pumps towards self-learning applications , 2018, Applied Energy.

[29]  Pawel Olszewski,et al.  Genetic optimization and experimental verification of complex parallel pumping station with centrifugal pumps , 2016 .

[30]  Qinghua Wu,et al.  Modelling and operation optimization of an integrated energy based direct district water-heating system , 2014 .

[31]  Yang Hongxing,et al.  Experimental studies on a ground coupled heat pump with solar thermal collectors for space heating , 2011 .

[32]  Lin Duanmu,et al.  Electricity consumption and economic analyses of district heating system with distributed variable speed pumps , 2016 .

[33]  Nadia Maïzi,et al.  A convex mathematical program for pump scheduling in a class of branched water networks , 2017 .

[34]  Weibo Yang,et al.  Experimental performance evaluation and parametric study of a solar-ground source heat pump system operated in heating modes , 2018 .

[35]  Sandhya Patidar,et al.  Understanding the energy consumption and occupancy of a multi-purpose academic building , 2015 .

[36]  Daisuke Sumiyoshi,et al.  Energy Saving Effect of Integrated Piping in Building HVAC System , 2015 .