Modeling of light scattering from micro- and nanotextured surfaces

We present a calculation routine for the angular and spectral dependence of scattered light after transmission through textured interfaces. Based on a modified Rayleigh–Sommerfeld integral, the treatment requires only measured surface profiles, and the refractive indices of the two materials adjacent to the textured interface but no fitting parameter. For typical surface morphologies used in solar cell fabrication, the calculations correctly reproduce the angle resolved scattering at 543 nm and the total scattered light intensity in the spectral range from 400 to 2000 nm. The model is then applied to predict the behavior of the interface between ZnO and silicon in a thin film solar cell which is not experimentally accessible.

[1]  M. Zeman,et al.  A scattering model for surface-textured thin films , 2009 .

[2]  C. Ballif,et al.  Influence of the ZnO buffer on the guided mode structure in Si/ZnO/Ag multilayers , 2009 .

[3]  Martin A. Green,et al.  Self-consistent optical parameters of intrinsic silicon at 300 K including temperature coefficients , 2008 .

[4]  C. Ballif,et al.  Plasmonic absorption in textured silver back reflectors of thin film solar cells , 2008 .

[5]  F. Lederer,et al.  Local versus global absorption in thin-film solar cells with randomly textured surfaces , 2008 .

[6]  Christophe Ballif,et al.  Optical management in high‐efficiency thin‐film silicon micromorph solar cells with a silicon oxide based intermediate reflector , 2008 .

[7]  J. Schubert,et al.  Thin Solid Films , 2008 .

[8]  Carsten Rockstuhl,et al.  Light localization at randomly textured surfaces for solar-cell applications , 2007 .

[9]  Christophe Ballif,et al.  Opto-electronic properties of rough LP-CVD ZnO:B for use as TCO in thin-film silicon solar cells , 2007 .

[10]  Helmut Stiebig,et al.  Thin-film silicon solar cells with efficient periodic light trapping texture , 2007 .

[11]  Alexei A. Maradudin,et al.  Light scattering and nanoscale surface roughness , 2007 .

[12]  Helmut Stiebig,et al.  Optical properties of thin‐film silicon solar cells with grating couplers , 2006 .

[13]  Arvind Shah,et al.  Low pressure chemical vapour deposition of ZnO layers for thin-film solar cells: temperature-induced morphological changes , 2005 .

[14]  M. Zeman,et al.  Effect of surface roughness of ZnO:Al films on light scattering in hydrogenated amorphous silicon solar cells , 2003 .

[15]  Marko Topič,et al.  Analysis of light scattering in amorphous Si:H solar cells by a one‐dimensional semi‐coherent optical model , 2003 .

[16]  M. Zeman,et al.  Optical modeling of a-Si:H solar cells with rough interfaces: Effect of back contact and interface roughness , 2000 .

[17]  J E Harvey,et al.  Diffracted radiance: a fundamental quantity in nonparaxial scalar diffraction theory. , 1999, Applied optics.

[18]  B. Rech,et al.  Texture etched ZnO:Al coated glass substrates for silicon based thin film solar cells , 1999 .

[19]  J. Bennett,et al.  Calculation of the power spectral density from surface profile data. , 1995, Applied optics.

[20]  G. Tao,et al.  Accurate generation rate profiles in a-Si :H solar cells with textured TCO substrates , 1994 .

[21]  S. Guha,et al.  Study of back reflectors for amorphous silicon alloy solar cell application , 1991 .

[22]  M. Yano,et al.  Design of textured Al electrode for a hydrogenated amorphous silicon solar cell , 1990 .

[23]  Arthur R. McGurn,et al.  Some aspects of light scattering from a randomly rough metal surface , 1985 .

[24]  Brown,et al.  Resonant light scattering from a randomly rough surface. , 1985, Physical review. B, Condensed matter.

[25]  R. Annan.  Photovoltaics. , 1985, Science.

[26]  James E. Harvey,et al.  Fourier treatment of near‐field scalar diffraction theory , 1979 .

[27]  C. K. Carniglia,et al.  Scalar Scattering Theory for Multilayer Optical Coatings , 1979 .

[28]  J. Bennett,et al.  Relation between the angular dependence of scattering and the statistical properties of optical surfaces , 1979 .

[29]  J. Goodman.  Introduction to Fourier optics , 1969 .

[30]  P. Beckmann,et al.  The scattering of electromagnetic waves from rough surfaces , 1963 .

[31]  H. E. Bennett,et al.  Relation between Surface Roughness and Specular Reflectance at Normal Incidence , 1961 .

[32]  S. Rice.  Reflection of electromagnetic waves from slightly rough surfaces , 1951 .