Low-cost NDIR based sensor platform for sub-ppm gas detection

Abstract We report on a new low-cost non-dispersive infrared (NDIR) based sensor platform for sub-ppm gas detection. The aim of the sensor platform development was to create a cost-effective, mass-producible and highly accurate device. Due to its sensitivity, the platform is well suitable for measuring and detecting gases like carbon dioxide, methane, dinitrogen oxide, ammonia, ethanol vapour, refrigerants, etc. The sensor is based on the White-cell NDIR approach and realizes a path length of 1.28 m in a device with an external length of less than 10 cm. High mechanical accuracy of the optical system, temperature controlled optics, highly stable electronics and an optimized mirror surfaces allow a detection level as low as 0.007 ppm.

[1]  Hitoshi Mukai,et al.  Theoretical and experimental evaluation of the isotope effect of NDIR analyzer on atmospheric CO2 measurement , 2009 .

[2]  J. Mohan,et al.  Organic Spectroscopy: Principles And Applications , 2000 .

[3]  Gordon M. Barrow,et al.  Introduction to molecular spectroscopy. , 1962 .

[4]  Ralph P. Tatam,et al.  A low cost, optically efficient carbon dioxide sensor based on nondispersive infra-red (NDIR) measurement at 4.2μm , 2012, Photonics Europe.

[5]  Beer.  Bestimmung der Absorption des rothen Lichts in farbigen Flüssigkeiten , 1852 .

[6]  David W. Allan,et al.  Statis-tics of time and frequency data analysis , 1974 .

[7]  John Aurie Dean,et al.  Instrumental methods of analysis , 1951 .

[8]  Jens Zosel,et al.  The measurement of dissolved and gaseous carbon dioxide concentration , 2011 .

[9]  Carles Cané,et al.  Non-selective NDIR array for gas detection , 2007, SPIE Microtechnologies.

[10]  S. Svanberg,et al.  Atomic and Molecular Spectroscopy: Basic Aspects and Practical Applications , 1992 .

[11]  Daqiang Zhang,et al.  A Survey on Gas Sensing Technology , 2012, Sensors.

[12]  John U. White.  Long Optical Paths of Large Aperture , 1942 .

[13]  G. Stemme,et al.  An optical IR-source and CO/sub 2/-chamber system for CO/sub 2/ measurements , 2000, Journal of Microelectromechanical Systems.

[14]  C.M. Warnky,et al.  Demonstration of a quartic cell, a free-space true-time-delay device based on the white cell , 2006, Journal of Lightwave Technology.