An earth block with a compressive strength higher than 45 MPa

Abstract This paper presents the results of a compressive strength test carried out on an extruded earth block of dimensions 40.7 × 13.6 × 4.8 (cm3). The failure of the block was not detected by the press used, which reached its highest load (2500 kN). This would correspond to a compressive strength of the block greater than 45 MPa! This value is obviously an aberration and the discussion developed in the paper, based on results from the literature, aims to explain this result and propose solutions for measuring the compressive strength of such products.

[1]  S. Lenci,et al.  Experimental analysis and modelling of the mechanical behaviour of earthen bricks , 2011 .

[2]  Jean-Claude Morel,et al.  Strength and elasto-plastic properties of non-industrial building materials manufactured with clay as a natural binder , 2009 .

[3]  M. Olivier,et al.  Comportement des sols fins argileux pendant un essai de compactage statique: détermination des paramètres pertinents , 1999 .

[4]  S. Lenci,et al.  Mechanical properties of adobe walls in a Roman Republican domus at Suasa , 2010 .

[5]  David G. Toll,et al.  The strength of unstabilised rammed earth materials , 2009 .

[6]  Peter Walker,et al.  Compressive strength of extruded unfired clay masonry units , 2009 .

[7]  D. Silveira,et al.  Mechanical properties of adobe bricks in ancient constructions , 2012 .

[8]  Peter Walker.  Strength and Durability Testing of Earth Blocks , 2000 .

[9]  Peter Walker,et al.  Compressive strength testing of compressed earth blocks , 2007 .

[10]  Jean-Claude Morel,et al.  A model to measure compressive strength of compressed earth blocks with the ‘3 points bending test’ , 2002 .

[11]  P. Lourenço,et al.  Handmade Clay Bricks: Chemical, Physical and Mechanical Properties , 2010 .

[12]  Hamid R. Ronagh,et al.  Experimental investigation and nonlinear FE analysis of historical masonry buildings - a case study , 2012 .

[13]  P. Walker.  Strength, durability and shrinkage characteristics of cement stabilised soil blocks , 1995 .

[14]  Hugo Houben,et al.  Earth Construction: A Comprehensive Guide , 1994 .

[15]  Peter Walker.  Characteristics of pressed earth block in compression , 1997 .