Probing water distribution in compressed fuel-cell gas-diffusion layers using X-ray computed tomography

Abstract X-ray computed tomography was used to investigate geometrical land and channel effects on spatial liquid-water distribution in gas-diffusion layers (GDLs) of polymer-electrolyte fuel cells under different levels of compression. At low compression, a uniform liquid-water front was observed due to water redistribution and uniform porosity; however, at high compression, the water predominantly advanced at locations under the channel for higher liquid pressures. At low compression, no apparent correlation between the spatial liquid water and porosity distributions was observed, whereas at high compression, a strong correlation was shown, indicating a potential for smart GDL architecture design with modulated porosity.

[1]  F. Marone,et al.  Progress in In Situ X-Ray Tomographic Microscopy of Liquid Water in Gas Diffusion Layers of PEFC , 2011 .

[2]  Heinrich Riesemeier,et al.  Influence of cracks in the microporous layer on the water distribution in a PEM fuel cell investigated by synchrotron radiography , 2013 .

[3]  A. Weber,et al.  Effective-Diffusivity Measurement of Partially-Saturated Fuel-Cell Gas-Diffusion Layers , 2012 .

[4]  Volker Schmidt,et al.  Three-dimensional study of compressed gas diffusion layers using synchrotron X-ray imaging , 2014 .

[5]  Christoph Ziegler,et al.  Enhancing liquid water transport by laser perforation of a GDL in a PEM fuel cell , 2008 .

[6]  Arvind R. Kalidindi,et al.  Computational and Experimental Analysis of Water Transport at Component Interfaces in Polymer Electrolyte Fuel Cells , 2014 .

[7]  M. Bahrami,et al.  Deformation of PEM fuel cell gas diffusion layers under compressive loading: An analytical approach , 2014 .

[8]  Mark Pritzker,et al.  Capillary pressure and hydrophilic porosity in gas diffusion layers for polymer electrolyte fuel cells , 2006 .

[9]  Z. Lua,et al.  Water management studies in PEM fuel cells , Part II : Ex situ investigation of flow maldistribution , pressure drop and two-phase flow pattern in gas channels , 2009 .

[10]  Sze Huey Tan,et al.  The Correlation Coefficient , 2009 .

[11]  D. Gerteisen,et al.  Stability and performance improvement of a polymer electrolyte membrane fuel cell stack by laser perforation of gas diffusion layers , 2010 .

[12]  Marco Stampanoni,et al.  Determination of Liquid Water Distribution in Porous Transport Layers , 2008 .

[13]  Ingo Manke,et al.  Grand canonical Monte Carlo study on water agglomerations within a polymer electrolyte membrane fuel cell gas diffusion layer , 2013 .

[14]  Chaoyang Wang,et al.  Two-Phase Modeling and Flooding Prediction of Polymer Electrolyte Fuel Cells , 2005 .

[15]  J. Newman,et al.  Modeling Two-Phase Behavior in PEFCs , 2004 .

[16]  Michael M. Daino,et al.  Water management studies in PEM fuel cells, part III: Dynamic breakthrough and intermittent drainage characteristics from GDLs with and without MPLs , 2010 .

[17]  A. MacDowell,et al.  Tomographic Imaging of Water Injection and Withdrawal in PEMFC Gas Diffusion Layers , 2010, ECS Transactions.

[18]  A. L. Edwards,et al.  An introduction to linear regression and correlation. , 1985 .

[19]  D. Gerteisen,et al.  Coupling of a continuum fuel cell model with a discrete liquid water percolation model , 2014 .

[20]  John Banhart,et al.  Synchrotron X-ray tomography for investigations of water distribution in polymer electrolyte membrane fuel cells , 2011 .

[21]  Ingo Manke,et al.  The influence of porous transport layer modifications on the water management in polymer electrolyte membrane fuel cells , 2013 .

[22]  Jin Hyun Nam,et al.  Effective diffusivity and water-saturation distribution in single- and two-layer PEMFC diffusion medium , 2003 .

[23]  M Stampanoni,et al.  Implementation of a fast method for high resolution phase contrast tomography. , 2006, Optics express.

[24]  Nitis Mukhopadhyay,et al.  Correlation Coefficient , 2011, International Encyclopedia of Statistical Science.

[25]  Ahmet Kusoglu,et al.  A Critical Review of Modeling Transport Phenomena in Polymer-Electrolyte Fuel Cells , 2014 .

[26]  A. Weber,et al.  Effective diffusivity in partially-saturated carbon-fiber gas diffusion layers: effect of through-plane saturation distribution , 2015 .

[27]  Evan J. See,et al.  Two-phase flow in GDL and reactant channels of a proton exchange membrane fuel cell , 2014 .

[28]  Aimy Bazylak,et al.  Synchrotron X-ray radiographic investigations of liquid water transport behavior in a PEMFC with MPL-coated GDLs , 2013 .

[29]  Takashi Sasabe,et al.  Effects of polytetrafluoroethylene treatment and compression on gas diffusion layer microstructure using high-resolution X-ray computed tomography , 2014 .

[30]  S. Hirai,et al.  Effect of liquid water distribution in gas diffusion media with and without microporous layer on PEM fuel cell performance , 2013 .

[31]  Evaporation , 1941, Science.

[32]  A. Weber,et al.  Modeling transport in polymer-electrolyte fuel cells. , 2004, Chemical reviews.

[33]  Marco Stampanoni,et al.  Investigation of liquid water in gas diffusion layers of polymer electrolyte fuel cells using X-ray tomographic microscopy , 2011 .

[34]  E. Médici,et al.  Evaporation, two phase flow, and thermal transport in porous media with application to low-temperature fuel cells , 2013 .

[35]  Olli Himanen,et al.  Inhomogeneous compression of PEMFC gas diffusion layer: Part II. Modeling the effect , 2007 .

[36]  Heinrich Riesemeier,et al.  Visualization of the water distribution in perforated gas diffusion layers by means of synchrotron X-ray radiography , 2012 .

[37]  Jeff T. Gostick,et al.  Random Pore Network Modeling of Fibrous PEMFC Gas Diffusion Media Using Voronoi and Delaunay Tessellations , 2013 .