Membrane processes for heating, ventilation, and air conditioning

Abstract This article reviews literature on using membranes in heating, ventilation, and air conditioning (HVAC) applications. Membranes enable the separation of one species from another, and membranes allowing the selective permeation of water vapor can be used to condition air in buildings, potentially more efficiently than conventional HVAC equipment. After a brief background on membrane technology, this review focuses on the following processes: vacuum membrane dehumidification; membrane energy recovery ventilation; liquid desiccant dehumidification; liquid desiccant regeneration; evaporative cooling; and humidification. It highlights the design, modeling, and experimental research on these topics, and suggests areas for further research.

[1]  R. Besant,et al.  Transient behavior of run-around heat and moisture exchanger system. Part І: Model formulation and verification , 2009 .

[2]  M. C. García-Payo,et al.  Thermal resistance technique for measuring the thermal conductivity of thin microporous membranes , 2004 .

[3]  J. Min,et al.  Performance analysis of a membrane-based enthalpy exchanger: Effects of the membrane properties on the exchanger performance , 2010 .

[4]  Xiu-Wei Li,et al.  Single-stage and double-stage photovoltaic driven regeneration for liquid desiccant cooling system , 2011 .

[5]  Haisheng Fan,et al.  Performance of a Run-Around System for HVAC Heat and Moisture Transfer Applications Using Cross-Flow Plate Exchangers Coupled with Aqueous Lithium Bromide , 2006 .

[6]  Carey J. Simonson,et al.  The Effect of Membrane Deflections on Flow Rate in Crossflow Air-to-Air Exchangers , 2008 .

[7]  Eric Kozubal,et al.  A desiccant-enhanced evaporative air conditioner: Numerical model and experiments , 2013 .

[8]  Anna Magrini,et al.  On the application of a membrane air—liquid contactor for air dehumidification , 1997 .

[9]  Mohammad Shakir Nasif,et al.  Membrane heat exchanger in HVAC energy recovery systems, systems energy analysis , 2010 .

[10]  Syed M. Zubair,et al.  Liquid desiccant based two-stage evaporative cooling system using reverse osmosis (RO) process for regeneration , 2007 .

[11]  S. Mochizuki,et al.  Theoretical analysis of pore size distribution effects on membrane transport , 1993 .

[12]  Carey J. Simonson,et al.  Transient behavior of run-around heat and moisture exchanger system. Part IІ: Sensitivity studies for a range of initial conditions , 2009 .

[13]  Ahmad Pesaran,et al.  Advanced Commercial Liquid-Desiccant Technology Development Study , 1998 .

[14]  Junghui Chen,et al.  Simulation study of a hybrid absorber–heat exchanger using hollow fiber membrane module for the ammonia–water absorption cycle , 2006 .

[15]  Carey J. Simonson,et al.  Performance analysis of a membrane liquid desiccant air-conditioning system , 2013 .

[16]  M. E. Findley,et al.  Mass and heat transfer relations in evaporation through porous membranes , 1969 .

[17]  Ahmed Hamza H. Ali,et al.  Characteristics of the membrane utilized in a compact absorber for lithium bromide–water absorption chillers , 2009 .

[18]  An analysis of simultaneous heat and water vapor exchange through a flat paper plate crossflow total heat exchanger , 1984 .

[19]  Wolfgang Albrecht,et al.  Selection of microporous hydrophobic membranes for use in gas/liquid contactors: An experimental approach , 2005 .

[20]  J. Niu,et al.  Membrane-based Enthalpy Exchanger: material considerations and clarification of moisture resistance , 2001 .

[21]  Andrew L. Zydney,et al.  Stagnant film model for concentration polarization in membrane systems , 1997 .

[22]  Dianne E. Wiley,et al.  Review of 3D CFD modeling of flow and mass transfer in narrow spacer-filled channels in membrane modules , 2010 .

[23]  Li-Zhi Zhang,et al.  Heat and Mass Transfer in a Total Heat Exchanger: Cross-Corrugated Triangular Ducts with Composite Supported Liquid Membrane , 2008 .

[24]  Marek Gryta,et al.  Osmotic MD and other membrane distillation variants , 2005 .

[25]  J. Woods,et al.  Combining liquid desiccant dehumidification with a dew-point evaporative cooler: A design analysis , 2013 .

[26]  A. Ito,et al.  Dehumidification and humidification of air by surface-soaked liquid membrane module with triethylene glycol , 2008 .

[27]  Li-Zhi Zhang,et al.  Heat and mass transfer in a cross-flow membrane-based enthalpy exchanger under naturally formed boundary conditions , 2007 .

[28]  Thomas Melin,et al.  Liquid membranes for gas/vapor separations , 2008 .

[29]  Yi Jiang,et al.  Analysis of thermal performance and energy savings of membrane based heat recovery ventilator , 2000 .

[30]  Li-Zhi Zhang,et al.  Fluid flow and heat mass transfer in membrane parallel-plates channels used for liquid desiccant air dehumidification , 2012 .

[31]  S. Jain,et al.  Experimental performance of indirect air–liquid membrane contactors for liquid desiccant cooling systems , 2013 .

[32]  Jay Burch,et al.  Generalized guidance for considering pore-size distribution in membrane distillation , 2011 .

[33]  James Clerk Maxwell.  Illustrations of the Dynamical Theory of Gases , 1860 .

[34]  K. Daou,et al.  Desiccant cooling air conditioning : a review , 2006 .

[35]  Hisham Ettouney,et al.  A Novel Air Conditioning System: Membrane Air Drying and Evaporative Cooling , 2000 .

[36]  Saffa Riffat,et al.  Review of Heat Recovery Technologies for Building Applications , 2012, Energies.

[37]  Masashi Asaeda,et al.  EXPERIMENTAL STUDIES OF DEHUMIDIFICATION OF AIR BY AN IMPROVED CERAMIC MEMBRANE , 1986 .

[38]  P. Meares,et al.  The diffusion of electrolytes in a cation-exchange resin membrane I. Theoretical , 1955, Proceedings of the Royal Society of London. Series A. Mathematical and Physical Sciences.

[39]  Andrew Lowenstein,et al.  A Zero Carryover Liquid-Desiccant Air Conditioner for Solar Applications , 2006 .

[40]  Kamaruzzaman Sopian,et al.  Survey of hybrid liquid desiccant air conditioning systems , 2013 .

[41]  C. Isetti,et al.  Three-fluid membrane contactors for improving the energy efficiency of refrigeration and air-handling systems , 2013 .

[42]  The occurrence and characterization of fouling during membrane evaporative cooling , 2008 .

[43]  C. Bai,et al.  A study on performance improvement of corrugated type total heat exchanger considering the structure of flow passage on surface , 2009 .

[44]  Li-Zhi Zhang,et al.  Coupled heat and mass transfer in a counter flow hollow fiber membrane module for air humidification , 2011 .

[45]  Yun Li,et al.  Applications of membrane distillation technology in energy transformation process-basis and prospect , 2009 .

[46]  Edward L Cussler,et al.  Hollow fiber air drying , 1992 .

[47]  Takeshi Matsuura,et al.  Preparation and Characterization of Polyvinylidene Fluoride Membranes for Membrane Distillation , 2001 .

[48]  Li-Zhi Zhang,et al.  Synthesis and characterization of a PVA/LiCl blend membrane for air dehumidification , 2008 .

[49]  Li-Zhi Zhang,et al.  Laminar flow and heat transfer in plate-fin triangular ducts in thermally developing entry region , 2007 .

[50]  Walter Mérida,et al.  Effectiveness correlations for heat and mass transfer in membrane humidifiers , 2009 .

[51]  Cai-Hang Liang,et al.  Heat and moisture transfer in application scale parallel-plates enthalpy exchangers with novel membrane materials , 2008 .

[52]  A. Chiari.  Air humidification with membrane contactors: experimental and theoretical results , 2000 .

[53]  Klaus-Viktor Peinemann,et al.  Hollow fiber membrane contactor for air humidity control: Modules and membranes , 2006 .

[54]  Xiaowei Liu,et al.  Evaluation of moisture diffusivities in various membranes , 2010 .

[55]  Li-Zhi Zhang.  Coupled heat and mass transfer through asymmetric porous membranes with finger-like macrovoids structure , 2009 .

[56]  J. Pellegrino,et al.  Heat and mass transfer in liquid-to-liquid membrane contactors: Design approach and model applicability , 2013 .

[57]  D. Kosar.  Laboratory Evaluation of Energy Recovery Ventilators , 2013 .

[58]  Xiu-Wei Li,et al.  Photovoltaic–electrodialysis regeneration method for liquid desiccant cooling system , 2009 .

[60]  Richard D. Noble,et al.  Perspective on ionic liquids and ionic liquid membranes , 2011 .

[61]  Abdulghani A. Al-Farayedhi,et al.  Regeneration of liquid desiccants using membrane technology , 1999 .

[62]  Jianlei Niu,et al.  Energy requirements for conditioning fresh air and the long-term savings with a membrane-based energy recovery ventilator in Hong Kong , 2001 .

[63]  Norman N. Li.  Advanced membrane technology and applications , 2008 .

[64]  Li-Zhi Zhang.  Fabrication of a lithium chloride solution based composite supported liquid membrane and its moisture permeation analysis , 2005, Journal of Membrane Science.

[65]  Dianne E. Wiley,et al.  Novel spacer design improves observed flux , 2004 .

[66]  Mohamed Khayet,et al.  A framework for better understanding membrane distillation separation process , 2006 .

[67]  Ben Richard Hughes,et al.  A review of sustainable cooling technologies in buildings , 2011 .

[68]  Li-Zhi Zhang,et al.  One-step fabrication and analysis of an asymmetric cellulose acetate membrane for heat and moisture recovery , 2011 .

[69]  Ruzhu Wang,et al.  Performance of energy recovery ventilator with various weathers and temperature set-points , 2007 .

[70]  Gregory M. Dobbs,et al.  Development of a High Latent Effectiveness Energy Recovery Ventilator with Integration into Rooftop Package Equipment , 2006 .

[71]  J. G. Wijmans,et al.  The solution-diffusion model: a review , 1995 .

[72]  Matthias Wessling,et al.  Mixed gas water vapor/N transport in poly(ethylene oxide) poly(butylene terephthalate) block copolymers , 2005 .

[73]  Drew W. Johnson,et al.  Analysis of heat and mass transfer phenomena in hollow fiber membranes used for evaporative cooling , 2003 .

[74]  Ahmed Hamza H. Ali,et al.  Design of a compact absorber with a hydrophobic membrane contactor at the liquid–vapor interface for lithium bromide–water absorption chillers , 2010 .

[75]  Eric Kozubal,et al.  Development and Analysis of Desiccant Enhanced Evaporative Air Conditioner Prototype , 2012 .

[76]  E. Drioli,et al.  Membrane Distillation and Related Operations—A Review , 2005 .

[77]  Eric Favre,et al.  Vacuum versus sweeping gas operation for binary mixtures separation by dense membrane processes , 2004 .

[78]  Li-Zhi Zhang.  An analytical solution for heat mass transfer in a hollow fiber membrane based air-to-air heat mass exchanger , 2010 .

[79]  S. Bergero,et al.  Experimental and theoretical analysis of air humidification/dehumidification processes using hydrophobic capillary contactors , 2001 .

[80]  Saffa Riffat,et al.  An experimental study on the performance of enthalpy recovery system for building applications , 2011 .

[81]  Andrew Lowenstein,et al.  Review of Liquid Desiccant Technology for HVAC Applications , 2008 .

[82]  Akira Ito,et al.  Dehumidification of air by a hygroscopic liquid membrane supported on surface of a hydrophobic microporous membrane , 2000 .

[83]  P. Scovazzo,et al.  Isothermal dehumidification or gas drying using vacuum sweep dehumidification , 2013 .

[84]  Satish Kumar,et al.  Predicting the effect of membrane spacers on mass transfer , 2008 .

[85]  Li-Zhi Zhang,et al.  Energy performance of independent air dehumidification systems with energy recovery measures , 2005, Energy.

[86]  A. B. de Haan,et al.  Novel spacers for mass transfer enhancement in membrane separations , 2005 .

[87]  Experimental velocity measurements and effect of flow maldistribution on predicted permeator performances , 1998 .

[88]  Li-Zhi Zhang,et al.  Convective mass transport in cross-corrugated membrane exchangers , 2005 .

[89]  Jay Burch,et al.  Design and experimental characterization of a membrane-based absorption heat pump , 2011 .

[90]  J. Niu,et al.  Effectiveness Correlations for Heat and Moisture Transfer Processes in an Enthalpy Exchanger With Membrane Cores , 2002 .

[91]  Arun Majumdar,et al.  Advanced Research Projects Agency ‐ Energy , 2010 .

[92]  E. Rideal,et al.  Permeation, diffusion and solution of gases in organic polymers , 1939 .

[93]  R. Besant,et al.  Steady-state performance of a run-around membrane energy exchanger (RAMEE) for a range of outdoor air conditions , 2011 .

[94]  Li-Zhi Zhang,et al.  Heat and mass transfer in plate-fin sinusoidal passages with vapor-permeable wall materials , 2008 .

[95]  Carey J. Simonson,et al.  The elastic and moisture transfer properties of polyethylene and polypropylene membranes for use in liquid-to-air energy exchangers , 2007 .

[96]  E. Cussler,et al.  Membrane Modules for Building Ventilation , 2002 .

[97]  Li-xia Pei,et al.  Selective permeation of moisture and VOCs through polymer membranes used in total heat exchangers for indoor air ventilation. , 2012, Indoor air.

[98]  Anna Chiari,et al.  Performance analysis of a liquid desiccant and membrane contactor hybrid air-conditioning system , 2010 .

[99]  David F. Fletcher,et al.  Simulation of Unsteady Flow and Vortex Shedding for Narrow Spacer-Filled Channels , 2003 .

[100]  S. Jain,et al.  Experimental performance of a liquid desiccant dehumidification system under tropical climates , 2011 .

[101]  M. Kevin Drost,et al.  Recent Developments in Microtechnology-Based Chemical Heat Pumps , 2000 .

[102]  Jay Burch,et al.  Modeling of a membrane-based absorption heat pump , 2009 .

[103]  Eric Kozubal,et al.  Desiccant Enhanced Evaporative Air-Conditioning (DEVap): Evaluation of a New Concept in Ultra Efficient Air Conditioning , 2011 .

[104]  Kim Dam-Johansen,et al.  Characterization of microporous membranes for use in membrane contactors , 1997 .

[105]  G. Lipscomb,et al.  Sources of Non‐ideal Flow Distribution and Their Effect on the Performance of Hollow Fiber Gas Separation Modules , 2005 .

[106]  Matthias Wessling,et al.  Transport of water vapor and inert gas mixtures through highly selective and highly permeable polymer membranes , 2005 .

[107]  Marcel Mulder,et al.  Basic Principles of Membrane Technology , 1991 .

[108]  Eric Kozubal,et al.  Heat transfer and pressure drop in spacer-filled channels for membrane energy recovery ventilators , 2013 .

[109]  Li-Zhi Zhang.  Thermally Developing Forced Convection and Heat Transfer in Rectangular Plate-Fin Passages Under Uniform Plate Temperature , 2007 .

[110]  Li-Zhi Zhang.  Flow Maldistribution and Performance Deteriorations in Membrane-Based Heat and Mass Exchangers , 2009 .

[111]  Yi Jiang,et al.  HEAT AND MASS TRANSFER IN A MEMBRANE-BASED ENERGY RECOVERY VENTILATOR , 1999 .

[112]  Mohammad Rasouli,et al.  Applicability and optimum control strategy of energy recovery ventilators in different climatic conditions , 2010 .

[113]  Edward L Cussler,et al.  Mass transfer in various hollow fiber geometries , 1992 .

[114]  Y. Mi,et al.  Theoretical study on concentration polarization in gas separation membrane processes , 1999 .