Effects of surface wettability and contact time on protein adhesion to biomaterial surfaces.

Atomic force microscopy (AFM) was used to directly measure the adhesion forces between three test proteins and low density polyethylene (LDPE) surfaces treated by glow discharge plasma to yield various levels of water wettability. The adhesion of proteins to the LDPE substrates showed a step dependence on the wettability of surfaces as measured by the water contact angle (theta). For LDPE surfaces with theta> approximately 60-65 degrees , stronger adhesion forces were observed for bovine serum albumin, fibrinogen and human FXII than for the surfaces with theta<60 degrees . Smaller adhesion forces were observed for FXII than for the other two proteins on all surfaces although trends were identical. Increasing the contact time from 0 to 50s for each protein-surface combination increased the adhesion force regardless of surface wettability. Time varying adhesion data was fit to an exponential model and free energies of protein unfolding were calculated. This data, viewed in light of previously published studies, suggests a 2-step model of protein denaturation, an early stage on the order of seconds to minutes where the outer surface of the protein interacts with the substrate and a second stage involving movement of hydrophobic amino acids from the protein core to the protein/surface interface. Impact statement: The work described in this manuscript shows a stark transition between protein adherent and protein non-adherent materials in the range of water contact angles 60-65 degrees , consistent with known changes in protein adsorption and activity. Time-dependent changes in adhesion force were used to calculate unfolding energies relating to protein-surface interactions. This analysis provides justification for a 2-step model of protein denaturation on surfaces.

[1]  James M. Anderson,et al.  Biological Responses to Materials , 2001 .

[2]  Marcus Textor,et al.  Bovine serum albumin adsorption onto colloidal Al2O3 particles: a new model based on zeta potential and UV-vis measurements. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[3]  M S Wagner,et al.  Characterization of adsorbed protein films by time of flight secondary ion mass spectrometry. , 2001, Journal of biomedical materials research.

[4]  C. Werner,et al.  Self-assembled monolayers with different terminating groups as model substrates for cell adhesion studies. , 2004, Biomaterials.

[5]  P. Luckham,et al.  Probing recognition process between an antibody and an antigen using atomic force microscopy , 1998 .

[6]  B. Logan,et al.  Residence time, loading force, pH, and ionic strength affect adhesion forces between colloids and biopolymer-coated surfaces. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[7]  Thomas A. Horbett,et al.  Chapter 13 Principles underlying the role of adsorbed plasma proteins in blood interactions with foreign materials , 1993 .

[8]  Yoon,et al.  Hydrophobic Interactions between Dissimilar Surfaces , 1997, Journal of colloid and interface science.

[9]  S. Shalaby,et al.  Direct correlation between adsorption-induced changes in protein structure and platelet adhesion. , 2005, Journal of biomedical materials research. Part A.

[10]  W J Brittain,et al.  Contact activation of the plasma coagulation cascade. I. Procoagulant surface chemistry and energy. , 1995, Journal of biomedical materials research.

[11]  R. Kane,et al.  Effect of surface wettability on the adhesion of proteins. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[12]  Takehisa Matsuda,et al.  Mechanistic aspects of protein/material interactions probed by atomic force microscopy , 2002 .

[13]  C. Siedlecki,et al.  Adhesion mode atomic force microscopy study of dual component protein films. , 2005, Ultramicroscopy.

[14]  R. Marchant,et al.  Surface-dependent Conformations of Human Fibrinogen Observed by Atomic Force Microscopy under Aqueous Conditions , 1999, Thrombosis and Haemostasis.

[15]  Christiane Wertz,et al.  Fibrinogen Relaxation Kinetics on Hydrophobic Surfaces , 2001 .

[16]  E. Vogler,et al.  Water and the acute biological response to surfaces. , 1999, Journal of biomaterials science. Polymer edition.

[17]  G. Belfort,et al.  Protein unfolding at interfaces: slow dynamics of alpha-helix to beta-sheet transition. , 2004, Proteins.

[18]  R. Marchant,et al.  Surface-dependent differences in fibrin assembly visualized by atomic force microscopy , 2001 .

[19]  Kinam Park,et al.  Protein interaction with surfaces: Separation distance‐dependent interaction energies , 1994 .

[20]  J. H. Lee,et al.  Platelet adhesion onto wettability gradient surfaces in the absence and presence of plasma proteins. , 1998, Journal of biomedical materials research.

[21]  B. Ratner,et al.  The role of adsorbed fibrinogen in platelet adhesion to polyurethane surfaces: a comparison of surface hydrophobicity, protein adsorption, monoclonal antibody binding, and platelet adhesion. , 2005, Journal of biomedical materials research. Part A.

[22]  C. Ziegler,et al.  Scanning-force techniques to monitor time-dependent changes in topography and adhesion force of proteins on surfaces , 2003, Analytical and bioanalytical chemistry.

[23]  M. Goldberg.  Investigating protein conformation, dynamics and folding with monoclonal antibodies. , 1991, Trends in biochemical sciences.

[24]  B. Logan,et al.  Interaction forces measured using AFM between colloids and surfaces coated with both dextran and protein. , 2006, Langmuir : the ACS journal of surfaces and colloids.

[25]  R. Doolittle,et al.  Crystal structure of native chicken fibrinogen at 2.7 A resolution. , 2001, Biochemistry.

[26]  C. Dupont-Gillain,et al.  Use of AFM to probe the adsorption strength and time-dependent changes of albumin on self-assembled monolayers. , 2003, Journal of biomedical materials research. Part A.

[27]  K. Jandt,et al.  Does the nanometre scale topography of titanium influence protein adsorption and cell proliferation? , 2006, Colloids and surfaces. B, Biointerfaces.

[28]  J. Lhoest,et al.  Fibronectin adsorption, conformation, and orientation on polystyrene substrates studied by radiolabeling, XPS, and ToF SIMS. , 1998, Journal of biomedical materials research.

[29]  H. Noh,et al.  Volumetric interpretation of protein adsorption: mass and energy balance for albumin adsorption to particulate adsorbents with incrementally increasing hydrophilicity. , 2006, Biomaterials.

[30]  G. Whitesides,et al.  A Survey of Structure−Property Relationships of Surfaces that Resist the Adsorption of Protein , 2001 .

[31]  D. Castner,et al.  Biomedical surface science: Foundations to frontiers , 2002 .

[32]  J. Hörber,et al.  Direct observation of the anchoring process during the adsorption of fibrinogen on a solid surface by force-spectroscopy mode atomic force microscopy. , 1999, Proceedings of the National Academy of Sciences of the United States of America.

[33]  G. Whitesides,et al.  Effect of Surface Wettability on the Adsorption of Proteins and Detergents , 1998 .

[34]  G. Belfort,et al.  Protein unfolding at interfaces: Slow dynamics of α‐helix to β‐sheet transition , 2004 .

[35]  V. Hlady,et al.  Adsorption Kinetics, Conformation, and Mobility of the Growth Hormone and Lysozyme on Solid Surfaces, Studied with TIRF , 1997, Journal of colloid and interface science.

[36]  Christiane Wertz,et al.  Fibrinogen Adsorption on Hydrophilic and Hydrophobic Surfaces: Geometrical and Energetic Aspects of Interfacial Relaxations , 2002 .

[37]  C. Siedlecki,et al.  Time-dependent conformational changes in fibrinogen measured by atomic force microscopy. , 2004, Langmuir : the ACS journal of surfaces and colloids.

[38]  Christiane Wertz,et al.  Protein spreading kinetics at liquid-solid interfaces via an adsorption probe method. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[39]  Robert A Latour,et al.  Molecular simulation to characterize the adsorption behavior of a fibrinogen gamma-chain fragment. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[40]  M. Santore,et al.  Adsorption and Relaxation Kinetics of Albumin and Fibrinogen on Hydrophobic Surfaces: Single-Species and Competitive Behavior , 1999 .

[41]  B. Logan,et al.  Interaction forces between colloids and protein-coated surfaces measured using an atomic force microscope. , 2005, Environmental science & technology.

[42]  P. Claesson,et al.  Three-Component Langmuir-Blodgett Films with a Controllable Degree of Polarity , 1994 .

[43]  Håkan Wennerström,et al.  Role of hydration and water structure in biological and colloidal interactions , 1996, Nature.

[44]  David Farrar,et al.  Interpretation of protein adsorption: surface-induced conformational changes. , 2005, Journal of the American Chemical Society.

[45]  P. A. Martic,et al.  Protein Adsorption and Conformational Change on Small Polymer Particles , 1990 .

[46]  M. Bos,et al.  Determination of the orientation distribution of adsorbed fluorophores using TIRF. II. Measurements on porphyrin and cytochrome c. , 1995, Biophysical journal.

[47]  Sit Ps,et al.  Surface-dependent conformations of human fibrinogen observed by atomic force microscopy under aqueous conditions. , 1999 .

[48]  D. Letourneur,et al.  Toward New Biomaterials , 2000, Infection Control &#x0026; Hospital Epidemiology.

[49]  D. Castner,et al.  Characterization of adsorbed protein films by time of flight secondary ion mass spectrometry. , 2001, Journal of biomedical materials research.

[50]  C. Haynes,et al.  Globular proteins at solid/liquid interfaces , 1994 .

[51]  K. Chittur,et al.  FTIR/ATR for protein adsorption to biomaterial surfaces. , 1998, Biomaterials.

[52]  Sang Jin Lee,et al.  Proliferation rate of fibroblast cells on polyethylene surfaces with wettability gradient , 2004 .

[53]  T. Matsuda,et al.  Adhesion Forces of the Blood Plasma Proteins on Self-Assembled Monolayer Surfaces of Alkanethiolates with Different Functional Groups Measured by an Atomic Force Microscope , 1999 .

[54]  J. Satulovsky,et al.  Kinetics of protein adsorption and desorption on surfaces with grafted polymers. , 2005, Biophysical journal.