Improved Modulation Mechanism of Parallel-Operated T-Type Three-Level PWM Rectifiers for Neutral-Point Potential Balancing and Circulating Current Suppression

In high-power applications, parallel-operated T-type three-level pulse width modulation (PWM) rectifiers (T3LPRs) are widely employed to improve the power capacity and system reliability. For parallel-operated T3LPRs, there are two important issues need to be properly addressed: 1) the neutral-point potential (NPP) balancing, and 2) the zero sequence circulating current (ZSCC) between the common ac and dc bus. In this paper, the fluctuation of NPP in a T3LPR and the generative mechanism of ZSCC in parallel-operated T3LPRs are first investigated. The zero sequence voltage (ZSV) difference between the parallel-operated T3LPRs is identified as the main excitation source of the ZSCC problem. Meanwhile, the disconnection of the neutral point and the control effect difference of NPP balancing in each T3LPR also affect the ZSCCs within the parallel-operated T3LPRs. To adjust the ZSV of T3LPRs, the dwell time of the positive small voltage vector in each switching period of the converter, which is usually adjusted to balance the NPP, is also required to be controlled to suppress ZSCC. Therefore, in this paper, to avoid the possible conflict, an improved modulation mechanism is designed to guarantee simultaneous ZSCC suppression and NPP balancing. The neutral points of each T3LPR are connected. Then, by adjusting the dwell time of the positive small voltage vector, the charging time of two dc capacitors is adjusted to balance the NPP, and the ZSV differences between different T3LPRs are adjusted to suppress ZSCCs. To avoid the control effect difference of independent NPP balancing in different T3LPRs, all T3LPRs share the same value marking the difference between two dc capacitor voltages. Thus, a communication with a greatly reduced baud rate requirement is needed for NPP balancing to transfer the difference between the two dc capacitor voltages. Moreover, no extra circuit is needed for ZSCC suppression. These approaches make the proposed improved space vector PWM strategy much more practical and easy to employ. The proposed method is verified with experiments on two 3-kW T3LPR prototypes.

[1]  Wenhua Liu,et al.  A neutral-point potential balancing algorithm for three-level NPC inverters using analytically injected zero-sequence voltage , 2003, Eighteenth Annual IEEE Applied Power Electronics Conference and Exposition, 2003. APEC '03..

[2]  Seshadri Gopalan.  A comparative study of control techniques for three phase PWM rectifier , 2016, 2016 10th International Conference on Intelligent Systems and Control (ISCO).

[3]  Dushan Boroyevich,et al.  A comprehensive study of neutral-point voltage balancing problem in three-level neutral-point-clamped voltage source PWM inverters , 2000 .

[4]  Dushan Boroyevich,et al.  Modeling and control of zero-sequence current in parallel multi-phase converters , 2000, 2000 IEEE 31st Annual Power Electronics Specialists Conference. Conference Proceedings (Cat. No.00CH37018).

[5]  Johann W. Kolar,et al.  Comparative Evaluation of Advanced Three-Phase Three-Level Inverter/Converter Topologies Against Two-Level Systems , 2013, IEEE Transactions on Industrial Electronics.

[6]  Zicheng Zhang,et al.  Space Vector Modulation for Circulating Current Suppression Using Deadbeat Control Strategy in Parallel Three-Level Neutral-Clamped Inverters , 2017, IEEE Transactions on Industrial Electronics.

[7]  Chung-Chuan Hou.  A Multicarrier PWM for Parallel Three-Phase Active Front-End Converters , 2013, IEEE Transactions on Power Electronics.

[8]  Zhongyi Quan,et al.  A three-level space vector modulation scheme for paralleled two converters to reduce zero-sequence circulating current and common mode voltage , 2016, 2016 IEEE Applied Power Electronics Conference and Exposition (APEC).

[9]  Ching-Tsai Pan,et al.  Modeling and Coordinate Control of Circulating Currents in Parallel Three-Phase Boost Rectifiers , 2007, IEEE Transactions on Industrial Electronics.

[10]  Juan C. Vasquez,et al.  Elimination of zero sequence circulating current between parallel operating three-level inverters , 2016, IECON 2016 - 42nd Annual Conference of the IEEE Industrial Electronics Society.

[11]  Xing Zhang,et al.  Modeling and Elimination of Zero-Sequence Circulating Currents in Parallel Three-Level T-Type Grid-Connected Inverters , 2015, IEEE Transactions on Power Electronics.

[12]  Yang Li,et al.  Circulating Current Analysis and Suppression for Configured Three-Limb Inductors in Paralleled Three-Level T-Type Converters With Space-Vector Modulation , 2017, IEEE Transactions on Power Electronics.

[13]  Dehong Xu,et al.  Design of hybrid AC-DC-AC topology for Uninterruptible Power Supply , 2015, 2015 IEEE 2nd International Future Energy Electronics Conference (IFEEC).

[14]  Zhe Chen,et al.  Zero-Sequence Voltage Modulation Strategy for Multiparallel Converters Circulating Current Suppression , 2017, IEEE Transactions on Industrial Electronics.

[15]  Li Zhang,et al.  A System-Level Control Strategy of Photovoltaic Grid-Tied Generation Systems for European Efficiency Enhancement , 2014, IEEE Transactions on Power Electronics.

[16]  A.M. Hava,et al.  A novel neutral point potential stabilization technique using the information of output current polarities and voltage vector , 2001, Conference Record of the 2001 IEEE Industry Applications Conference. 36th IAS Annual Meeting (Cat. No.01CH37248).

[17]  Joachim Holtz,et al.  A high-power multitransistor-inverter uninterruptable power supply system , 1988 .

[18]  Sun.  A Distributed Control Strategy based on DC Bus Signaling for Modular Photovoltaic Generation Systems with Battery Energy Storage , 2011 .

[19]  Jihong Wang,et al.  Overview of current development in electrical energy storage technologies and the application potential in power system operation , 2015 .

[20]  Xiang-dong Sun,et al.  Research on zero-sequence circulating current suppression strategy based on t-type three-level photovoltaic grid-connected inverters , 2016, 2016 IEEE 11th Conference on Industrial Electronics and Applications (ICIEA).

[21]  Peng Xu,et al.  A SiC-based T-type three-phase three-level gridtied inverter , 2015, 2015 IEEE 10th Conference on Industrial Electronics and Applications (ICIEA).

[22]  Seung-Ki Sul,et al.  Suppression of Circulating Current in parallel operation of three-level converters , 2016, 2016 IEEE Applied Power Electronics Conference and Exposition (APEC).