Vertical and Lateral Copper Transport through Graphene Layers.

A different mechanism was found for Cu transport through multi-transferred single-layer graphene serving as diffusion barriers on the basis of time-dependent dielectric breakdown tests. Vertical and lateral transport of Cu dominates at different stress electric field regimes. The classic E-model was modified to project quantitatively the effectiveness of the graphene Cu diffusion barrier at low electric field based on high-field accelerated stress data. The results are compared to industry-standard Cu diffusion barrier material TaN. 3.5 Å single-layer graphene shows the mean time-to-fail comparable to 4 nm TaN, while two-time and three-time transferred single-layer graphene stacks give 2× and 3× improvements, respectively, compared to single-layer graphene at a 0.5 MV/cm electric field. The influences of graphene grain boundaries on Cu vertical transport through the graphene layers are explored, revealing that large-grain (10-15 μm) single-layer graphene gives a 2 orders of magnitude longer lifetime than small-grain (2-3 μm) graphene. As a result, it is more effective to further enhance graphene barrier reliability by improving single-layer graphene quality through increasing grain sizes or using single-crystalline graphene than just by increasing thickness through multi-transfer. These results may also be applied for graphene as barriers for other metals.

[1]  K. Kamaras,et al.  Anomalies in thickness measurements of graphene and few layer graphite crystals by tapping mode atomic force microscopy , 2008, 0812.0690.

[2]  Geoffrey Yeap,et al.  Smart mobile SoCs driving the semiconductor industry: Technology trend, challenges and opportunities , 2013, 2013 IEEE International Electron Devices Meeting.

[3]  Kai Yan,et al.  Toward clean and crackless transfer of graphene. , 2011, ACS nano.

[4]  T. Wong.  Time Dependent Dielectric Breakdown in Copper Low-k Interconnects: Mechanisms and Reliability Models , 2012, Materials.

[5]  T. Sullivan,et al.  A Comprehensive Study of Low-k SiCOH TDDB Phenomena and Its Reliability Lifetime Model Development , 2006, 2006 IEEE International Reliability Physics Symposium Proceedings.

[6]  B. Cho,et al.  Penetration and lateral diffusion characteristics of polycrystalline graphene barriers. , 2014, Nanoscale.

[7]  Toh-Ming Lu,et al.  Metal-Dielectric Interfaces in Gigascale Electronics , 2012 .

[8]  Luigi Colombo,et al.  Evolution of graphene growth on Ni and Cu by carbon isotope labeling. , 2009, Nano letters.

[9]  William J. Padgett,et al.  Weibull Distribution , 2011, International Encyclopedia of Statistical Science.

[10]  A. M. van der Zande,et al.  Impermeable atomic membranes from graphene sheets. , 2008, Nano letters.

[11]  Y. Hayashi,et al.  Highly-Reliable Low-Resistance Cu Interconnects with PVD-Ru/Ti Barrier Metal toward Automotive LSIs , 2008, 2008 International Interconnect Technology Conference.

[12]  J. W. McPherson,et al.  Time dependent dielectric breakdown physics - Models revisited , 2012, Microelectron. Reliab..

[13]  Michael S. Arnold,et al.  Cu diffusion barrier: Graphene benchmarked to TaN for ultimate interconnect scaling , 2015, 2015 Symposium on VLSI Technology (VLSI Technology).

[14]  R. Murali,et al.  Resistivity of Graphene Nanoribbon Interconnects , 2009, IEEE Electron Device Letters.

[15]  Hui Long,et al.  Mass transport mechanism of cu species at the metal/dielectric interfaces with a graphene barrier. , 2014, ACS nano.

[16]  J. Vlassak,et al.  Nucleation and Adhesion of ALD Copper on Cobalt Adhesion Layers and Tungsten Nitride Diffusion Barriers , 2005 .

[17]  K. Banerjee,et al.  Comparison of E and 1/E TDDB models for SiO/sub 2/ under long-term/low-field test conditions , 1998, International Electron Devices Meeting 1998. Technical Digest (Cat. No.98CH36217).

[18]  C. N. Lau,et al.  Superior thermal conductivity of single-layer graphene. , 2008, Nano letters.

[19]  K. Novoselov,et al.  Giant intrinsic carrier mobilities in graphene and its bilayer. , 2007, Physical review letters.

[20]  Low resistive and highly reliable Cu dual-damascene interconnect technology using self-formed MnSi/sub x/O/sub y/ barrier layer , 2005, Proceedings of the IEEE 2005 International Interconnect Technology Conference, 2005..

[21]  J. McPherson,et al.  Complementary model for intrinsic time-dependent dielectric breakdown in SiO2 dielectrics , 2000 .

[22]  Larry Zhao,et al.  A new perspective of barrier material evaluation and process optimization , 2009, 2009 IEEE International Interconnect Technology Conference.

[23]  Suzumura Naohito,et al.  A NEW TDDB DEGRADATION MODEL BASED ON CU ION DRIFT IN CU INTERCONNECT DIELECTRICS , 2007 .

[24]  Panayotis C. Andricacos,et al.  Damascene copper electroplating for chip interconnections , 1998, IBM J. Res. Dev..

[25]  Hitoshi Itoh,et al.  Formation of a manganese oxide barrier layer with thermal chemical vapor deposition for advanced large-scale integrated interconnect structure , 2008 .

[26]  J. McPherson,et al.  UNDERLYING PHYSICS OF THE THERMOCHEMICAL E MODEL IN DESCRIBING LOW-FIELD TIME-DEPENDENT DIELECTRIC BREAKDOWN IN SIO2 THIN FILMS , 1998 .

[27]  Sunny Chugh,et al.  Enhanced electrical and thermal conduction in graphene-encapsulated copper nanowires. , 2015, Nano letters.

[28]  M. Arnold,et al.  Improving Graphene Diffusion Barriers via Stacking Multiple Layers and Grain Size Engineering , 2013 .

[29]  K. C. Boyko,et al.  Time Dependent Dielectric Breakdown of 210? Oxides , 1989 .

[30]  Byung-Sung Kim,et al.  Wafer-Scale Growth of Single-Crystal Monolayer Graphene on Reusable Hydrogen-Terminated Germanium , 2014, Science.

[31]  Andre K. Geim,et al.  Raman spectrum of graphene and graphene layers. , 2006, Physical review letters.

[32]  Jen Fin Lin,et al.  1-nm-thick graphene tri-layer as the ultimate copper diffusion barrier , 2014 .

[33]  Junyong Kang,et al.  Oxidation resistance of graphene-coated Cu and Cu/Ni alloy. , 2011, ACS nano.

[34]  Po-Wen Chiu,et al.  Scalable graphite/copper bishell composite for high-performance interconnects. , 2014, ACS nano.

[35]  Chandreswar Mahata,et al.  Graphene as an atomically thin barrier to Cu diffusion into Si. , 2014, Nanoscale.