Dynamic Percolation and Droplet Growth Behavior in Porous Electrodes of Polymer Electrolyte Fuel Cells

The percolating flow of liquid water in the gas-diffusion layer (GDL) of polymer electrolyte fuel cells (PEFCs) was studied ex situ using a simple water-injection experiment. Water was injected into the top of the sample so the droplet was free to detach from the bottom, allowing for uninterrupted study of the dynamic cycle of droplet appearance, growth, and detachment. Although droplets emerged from a single point on the GDL, the measured pressure response in the water phase was clearly not equivalent to a single needle. The behavior of the system was explained by the simultaneous filling and inflating of many menisci, resulting in extended periods with no droplet activity at the GDL surface, followed by the sudden eruption of a droplet at the breakthrough site as all interfaces deflated and their stored water was directed toward the droplet. A simple numerical model was presented that could qualitatively explain the observed behavior. Tests were performed on GDLs, with and without microporous layers (MP...

[1]  Zhigang Qi,et al.  Improvement of water management by a microporous sublayer for PEM fuel cells , 2002 .

[2]  Michael M. Daino,et al.  Water management studies in PEM fuel cells, part III: Dynamic breakthrough and intermittent drainage characteristics from GDLs with and without MPLs , 2010 .

[3]  Kateryna Artyushkova,et al.  Effects of Cathode Corrosion on Through-Plane Water Transport in Proton Exchange Membrane Fuel Cells. , 2013, Journal of the Electrochemical Society.

[4]  Adam Z. Weber,et al.  Effects of Microporous Layers in Polymer Electrolyte Fuel Cells , 2005 .

[5]  David Sinton,et al.  Dynamic water transport and droplet emergence in PEMFC gas diffusion layers , 2008 .

[6]  M. Pourkashanian,et al.  The effects of compression on single and multiphase flow in a model polymer electrolyte membrane fuel cell gas diffusion layer , 2015 .

[7]  Shohji Tsushima,et al.  Observation of dynamic liquid water transport in the microporous layer and gas diffusion layer of an operating PEM fuel cell by high-resolution soft X-ray radiography , 2013 .

[8]  C. Pan,et al.  Visualization and back pressure analysis of water transport through gas diffusion layers of proton exchange membrane fuel cell , 2012 .

[9]  Ahmet Kusoglu,et al.  A Critical Review of Modeling Transport Phenomena in Polymer-Electrolyte Fuel Cells , 2014 .

[10]  Demonstration of water management role of microporous layer by similarity model experiments , 2010 .

[11]  Xun Zhu,et al.  Emergence of droplets from a bundle of tubes into a micro-channel gas stream: Application to the two-phase dynamics in the cathode of proton exchange membrane fuel cell , 2014 .

[12]  J. Benziger,et al.  Water Flow in, Through, and Around the Gas Diffusion Layer , 2012 .

[13]  Tammo S. Steenhuis,et al.  Visualization of unstable water flow in a fuel cell gas diffusion layer , 2009 .

[14]  Chao-Yang Wang,et al.  Two-Phase Transport in Polymer Electrolyte Fuel Cells with Bilayer Cathode Gas Diffusion Media , 2005 .

[15]  Jin Hyun Nam,et al.  Microporous layer for water morphology control in PEMFC , 2009 .

[16]  T. Tanuma.  Innovative Hydrophilic Microporous Layers for Cathode Gas Diffusion Media , 2010 .

[17]  M. Fowler,et al.  Impact of Liquid Water on Reactant Mass Transfer in PEM Fuel Cell Electrodes , 2010 .

[18]  R. Borup,et al.  PEM Fuel Cell Degradation , 2010 .

[19]  S. Litster,et al.  Resolving the Three‐Dimensional Microstructure of Polymer Electrolyte Fuel Cell Electrodes using Nanometer‐Scale X‐ray Computed Tomography , 2012 .

[20]  Mark Pritzker,et al.  On the role of the microporous layer in PEMFC operation , 2009 .

[21]  Yannis Kevrekidis,et al.  Drops, slugs, and flooding in polymer electrolyte membrane fuel cells , 2008 .

[22]  Jong-Won Lee,et al.  A review of gas diffusion layer in PEM fuel cells: Materials and designs , 2012 .

[23]  R. Schweiss,et al.  Mitigation of Water Management in PEM Fuel Cell Cathodes by Hydrophilic Wicking Microporous Layers , 2010 .

[24]  Eunsook Lee,et al.  Development of a novel hydrophobic/hydrophilic double micro porous layer for use in a cathode gas di , 2011 .

[25]  G. Varisco,et al.  Water transport into PEFC gas diffusion layer: experimental characterization of diffusion and permeation , 2014 .

[26]  Chaoyang Wang,et al.  Visualization of Liquid Water Transport in a PEFC , 2004 .

[27]  A. Tamayol,et al.  Water permeation through gas diffusion layers of proton exchange membrane fuel cells , 2011 .

[28]  J. Banhart,et al.  In situ Synchrotron X‐ray Radiography Investigations of Water Transport in PEM Fuel Cells , 2009 .

[29]  M. Mortazavi,et al.  Liquid water breakthrough pressure through gas diffusion layer of proton exchange membrane fuel cell , 2014 .

[30]  A. Shukla,et al.  Diffusion layer parameters influencing optimal fuel cell performance , 2000 .

[31]  K. Sharp,et al.  Liquid droplet behavior and instability in a polymer electrolyte fuel cell flow channel , 2006 .

[32]  Rui Chen,et al.  3D reconstruction of a gas diffusion layer and a microporous layer , 2010 .

[33]  Chao-Yang Wang,et al.  Visualization and quantification of cathode channel flooding in PEM fuel cells , 2009 .

[34]  N. Djilali,et al.  Ex situ visualization of liquid water transport in PEM fuel cell gas diffusion layers , 2006 .

[35]  Matthew M. Mench,et al.  Investigation of Temperature-Driven Water Transport in Polymer Electrolyte Fuel Cell: Phase-Change-Induced Flow , 2009 .

[36]  Adam Z. Weber,et al.  Probing water distribution in compressed fuel-cell gas-diffusion layers using X-ray computed tomography , 2015 .

[37]  A. Weber,et al.  Modeling transport in polymer-electrolyte fuel cells. , 2004, Chemical reviews.

[38]  J. Gostick,et al.  Comment on Effect of gas diffusion layer properties on the time of breakthrough by Shahraeeni and , 2011 .

[39]  D. Baker,et al.  Heat and Water Transport in Hydrophobic Diffusion Media , 2009 .

[40]  Yun Wang,et al.  A review of polymer electrolyte membrane fuel cells: Technology, applications,and needs on fundamental research , 2011 .

[41]  Werner Lehnert,et al.  Investigation of water evolution and transport in fuel cells with high resolution synchrotron x-ray radiography , 2007 .

[42]  Mahlon Wilson,et al.  Scientific aspects of polymer electrolyte fuel cell durability and degradation. , 2007, Chemical reviews.

[43]  Adam Z. Weber,et al.  Liquid-Water Interactions with Gas-Diffusion-Layer Surfaces , 2014 .

[44]  Thomas W. Tighe,et al.  Water Transport Mechanisms in PEMFC Gas Diffusion Layers , 2010 .

[45]  M. Fowler,et al.  Characterization of the Capillary Properties of Gas Diffusion Media , 2009 .