The analysis of dark signals in the CMOS APS imagers from the characterization of test structures

The characteristics of dark signals have been investigated in the CMOS active pixel sensor (APS) with test structures fabricated using the deep-submicron CMOS technology. It is found that the periphery of the photodiode (PD) is the dominant source of dark currents in our test structure, and this factor is very sensitive to the distance between the sidewall of the shallow trench isolation and the n-type region of the PD. The dark currents from the transfer gate can be effectively reduced by the tail of p/sup +/ region on the surface of the transfer gate, and those from the floating diffusion (FD) node were estimated to be negligible in the normal operational mode. However, because of the enhanced thermal generation velocity caused by the severe process-induced damages, the FD node was considered as the main source of increased dark currents in the single frame capture mode. The characteristics of quantized dark currents causing the white pixels in the CMOS APS were examined using the dark current spectroscopy method. Three distinct deep-level bulk traps have been identified with the location in the silicon bandgap at |E/sub t/-E/sub i/|/spl sim/0.020 (eV), |E/sub t/-E/sub i/|/spl sim/0.082 (eV), and |E/sub t/-E/sub i/|/spl sim/0.058 (eV), and capture cross sections of 7.80/spl times/10/sup -15/ cm/sup 2/, 1.83/spl times/10/sup -13/ cm/sup 2/, and 1.46/spl times/10/sup -13/ cm/sup 2/ respectively.

[1]  A. Theuwissen,et al.  Leakage current modeling of test structures for characterization of dark current in CMOS image sensors , 2003 .

[2]  Ya-Chin King,et al.  An ultra-low dark current CMOS image sensor cell using n/sup +/ ring reset , 2002 .

[3]  Orly Yadid-Pecht,et al.  Empirical dark current modeling for complementary metal oxide semiconductor active pixel sensor , 2002 .

[4]  S. Wuu,et al.  A high performance active pixel sensor with 0.18um CMOS color imager technology , 2001, International Electron Devices Meeting. Technical Digest (Cat. No.01CH37224).

[5]  Heike Soltau,et al.  Metal contamination analysis of the epitaxial starting material for scientific CCDs , 2000 .

[6]  B. Kang,et al.  Oxidation-induced traps near SiO2/SiGe interface , 1999 .

[7]  Dahong Qian.  Temperature Characteristics of Gross Defects in Image Sensors , 1999 .

[8]  O. Yadid-Pecht,et al.  A snap-shot CMOS active pixel imager for low-noise, high-speed imaging , 1998, International Electron Devices Meeting 1998. Technical Digest (Cat. No.98CH36217).

[9]  Eric R. Fossum,et al.  CMOS image sensors: electronic camera-on-a-chip , 1997 .

[10]  A. Dickinson,et al.  Camera on a chip , 1996, 1996 IEEE International Solid-State Circuits Conference. Digest of TEchnical Papers, ISSCC.

[11]  W. J. Toren,et al.  Metal contamination characterization in CCD image sensors , 1995, Proceedings of International Electron Devices Meeting.

[12]  Takeshi Hamamoto,et al.  Sidewall damage in a silicon substrate caused by trench etching , 1991 .

[13]  J. Vallerga,et al.  Counting of deep-level traps using a charge-coupled device , 1987, IEEE Transactions on Electron Devices.

[14]  D. Schroder,et al.  The concept of generation and recombination lifetimes in semiconductors , 1982, IEEE Transactions on Electron Devices.

[15]  K. Tanikawa,et al.  Evaluation of dark‐current nonuniformity in a charge‐coupled device , 1976 .

[16]  D. Lang.  Deep‐level transient spectroscopy: A new method to characterize traps in semiconductors , 1974 .

[17]  Ching-Chun Wang,et al.  A study of CMOS technologies for image sensor applications , 2001 .

[18]  J. P. Lavine,et al.  Dark Current Spectroscopy Of Metals In Silicon , 1996 .

[19]  James P. Lavine,et al.  Probing Metal Defects in CCD Image Sensors , 1995 .

[20]  J. P. Lavine,et al.  Dark current quantization in CCD image sensors , 1992, 1992 International Technical Digest on Electron Devices Meeting.

[21]  S. Boughaba,et al.  DEEP LEVEL TRANSIENT SPECTROSCOPY CHARACTERIZATION OF TUNGSTEN-RELATED DEEP LEVELS IN SILICON , 1991 .

[22]  E. Savoye,et al.  The Effect of Heavy Metal Contamination on Defects in CCD Imagers Contamination Monitoring by Surface Photovoltage , 1990 .

[23]  G. W. Cullen,et al.  Silicon Wafers for CCD Imagers , 1987 .

[24]  A. S. Grove.  Physics and Technology of Semiconductor Devices , 1967 .