Palladium Nanoparticles Supported on Sulfonic Acid Functionalized Silica as Trifunctional Heterogeneous Catalysts for Heck and Suzuki Reactions

The arylation of acrylates and boronic acids with anilines, through in situ generated aryl diazonium salts, was successfully achieved by using trifunctional heterogeneous catalysts bearing Brønsted acid and metal active sites. The trifunctional materials were prepared by adsorption of palladium nanoparticles, generated by reduction of a solution of Pd(OAc)2 onto a commercially available sulfonic acid functionalized silica. These new trifunctional catalysts act as a 1) proton donor for the diazotization step, 2) counterion for the diazonium salt, and 3) Pd source for the coupling step. This unprecedented strategy, features mild and safe conditions as hazardous aryl diazonium salts are generated in situ and only produces environmentally friendly byproducts such as tBuOH, H2O, and N2.

[1]  N. Oger,et al.  Using Aryl Diazonium Salts in Palladium-Catalyzed Reactions under Safer Conditions , 2014 .

[2]  Jie Wu,et al.  Removal of amino groups from anilines through diazonium salt-based reactions. , 2014, Organic & biomolecular chemistry.

[3]  J. Majimel,et al.  On the peculiar recycling properties of charcoal-supported palladium oxide nanoparticles in Sonogashira reactions , 2014 .

[4]  M. McGuire,et al.  Multicomponent, flow diazotization/Mizoroki-Heck coupling protocol: dispelling myths about working with diazonium salts. , 2014, Chemistry.

[5]  Yanghui Zhang,et al.  Carboxylate‐Directed CH Functionalization , 2014 .

[6]  R. Giri,et al.  Palladium-Catalysed, Directed CH Coupling with Organometallics , 2014 .

[7]  D. Jacquemin,et al.  Heck–Matsuda Arylation of Olefins Through a Bicatalytic Approach: Improved Procedures and Rationalization , 2014 .

[8]  F. Felpin.  Ten Years of Adventures with Pd/C Catalysts: From Reductive Processes to Coupling Reactions , 2014, Synlett.

[9]  M. Boujtita,et al.  Stabilisation of carbon-supported palladium nanoparticles through the formation of an alloy with gold: application to the Sonogashira reaction. , 2013, Chemistry.

[10]  H. Miyamura,et al.  A heterogeneous layered bifunctional catalyst for the integration of aerobic oxidation and asymmetric C-C bond formation. , 2013, Chemical communications.

[11]  T. Laird.  Chemistry for Sustainable Technologies: A Foundation , 2013 .

[12]  J. Sotiropoulos,et al.  Chelation-assisted cross-coupling of anilines through in situ activation as diazonium salts with boronic acids under ligand-, base-, and salt-free conditions. , 2013, Chemistry.

[13]  B. Schmidt,et al.  From paracetamol to rolipram and derivatives - application of deacetylation-diazotation sequences and palladium-catalyzed matsuda-heck reaction , 2013 .

[14]  Guangbin Dong,et al.  Recent applications of arene diazonium salts in organic synthesis. , 2013, Organic & biomolecular chemistry.

[15]  B. Schmidt,et al.  A Deacetylation–Diazotation–Coupling Sequence: Palladium- Catalyzed CC Bond Formation with Acetanilides as Formal Leaving Groups , 2013 .

[16]  J. Sotiropoulos,et al.  Sustainable Heck-Matsuda reaction with catalytic amounts of diazonium salts: an experimental and theoretical study. , 2012, Chemistry.

[17]  M. Sanford,et al.  Controlling site selectivity in palladium-catalyzed C-H bond functionalization. , 2012, Accounts of chemical research.

[18]  A. Hajipour,et al.  Heck-type reaction of aryldiazonium silica sulfates , 2012, Monatshefte für Chemie - Chemical Monthly.

[19]  B. Schmidt,et al.  Selective arene functionalization through sequential oxidative and non-oxidative Heck reactions. , 2012, Chemical communications.

[20]  L. Gilbert,et al.  Industrial commitment to green and sustainable chemistry: using renewable materials & developing eco-friendly processes and ingredients in cosmetics , 2012 .

[21]  Roger A Sheldon,et al.  Fundamentals of green chemistry: efficiency in reaction design. , 2012, Chemical Society reviews.

[22]  Peter J Dunn,et al.  The importance of green chemistry in process research and development. , 2012, Chemical Society reviews.

[23]  A. Hajipour,et al.  Suzuki-Miyaura cross-coupling of aryldiazonium silica sulfates under mild and heterogeneous conditions , 2012 .

[24]  N. T. Patil,et al.  A one-pot catalysis: the strategic classification with some recent examples. , 2012, Organic & biomolecular chemistry.

[25]  H. Neumann,et al.  Convenient and general palladium-catalyzed carbonylative Sonogashira coupling of aryl amines. , 2011, Angewandte Chemie.

[26]  H. Neumann,et al.  Convenient and mild synthesis of nitroarenes by metal-free nitration of arylboronic acids. , 2011, Chemical communications.

[27]  F. Felpin,et al.  Aryl Diazonium versus Iodonium Salts: Preparation, Applications and Mechanisms for the Suzuki–Miyaura Cross-Coupling Reaction , 2011 .

[28]  A. Hajipour,et al.  Aryldiazonium silica sulfates as efficient reagents for Heck-type arylation reactions under mild conditions , 2011 .

[29]  I. Song,et al.  Direct synthesis of hydrogen peroxide from hydrogen and oxygen over palladium catalyst supported on SO3H-functionalized MCF silica: Effect of calcination temperature of mesostructured cellular foam silica , 2011 .

[30]  F. Felpin,et al.  Unprecedented substoichiometric use of hazardous aryl diazonium salts in the Heck-Matsuda reaction via a double catalytic cycle. , 2011, Organic letters.

[31]  F. Felpin,et al.  Recent advances in the Heck–Matsuda reaction in heterocyclic chemistry , 2011 .

[32]  C. R. Correia,et al.  Evolution And Synthetic Applications Of The Heck-matsuda Reaction: The Return Of Arenediazonium Salts To Prominence , 2011 .

[33]  Avelino Corma,et al.  Heterogeneous catalysts for the one-pot synthesis of chemicals and fine chemicals. , 2011, Chemical reviews.

[34]  S. Messaoudi,et al.  Transition-Metal-Catalyzed Direct C–H Alkenylation, Alkynylation, Benzylation, and Alkylation of (Hetero)arenes , 2010 .

[35]  T. Lambert,et al.  Multicatalysis: Advancing Synthetic Efficiency and Inspiring Discovery , 2010 .

[36]  F. Felpin,et al.  A useful, reliable and safer protocol for hydrogenation and the hydrogenolysis of O-benzyl groups: the in situ preparation of an active Pd(0)/C catalyst with well-defined properties. , 2010, Chemistry.

[37]  S. Jessel,et al.  Mizoroki–Heck Reactions with 4‐Phenoldiazonium Salts , 2010 .

[38]  J. Fierro,et al.  Direct synthesis of hydrogen peroxide on palladium catalyst supported on sulfonic acid-functionalized silica , 2010 .

[39]  P. Ellis,et al.  Catalyst Preparation for the 21st Century , 2010 .

[40]  J. Sotiropoulos,et al.  Room-temperature, ligand- and base-free Heck reactions of aryl diazonium salts at low palladium loading: sustainable preparation of substituted stilbene derivatives. , 2010, Chemistry.

[41]  M. Sefkow,et al.  One-pot, Pd-catalyzed synthesis of trans-dihydrobenzofurans from o-aminophenols. , 2010, Organic letters.

[42]  S. Baeck,et al.  Direct synthesis of hydrogen peroxide from hydrogen and oxygen over palladium catalyst supported on SO3H-functionalized mesoporous silica , 2010 .

[43]  B. Schmidt,et al.  Functionalized alkoxy arene diazonium salts from paracetamol. , 2010, Organic & biomolecular chemistry.

[44]  Jian Zhou.  Recent advances in multicatalyst promoted asymmetric tandem reactions. , 2010, Chemistry, an Asian journal.

[45]  L. Ackermann,et al.  Übergangsmetallkatalysierte direkte Arylierungen von (Hetero)Arenen durch C‐H‐Bindungsbruch , 2009 .

[46]  A. Kapdi,et al.  Transition-metal-catalyzed direct arylation of (hetero)arenes by C-H bond cleavage. , 2009, Angewandte Chemie.

[47]  F. Felpin,et al.  Heterogeneous palladium multi-task catalyst for sequential Heck-reduction–cyclization (HRC) reactions: influence of the support , 2009 .

[48]  O. Daugulis,et al.  Palladium- and copper-catalyzed arylation of carbon-hydrogen bonds. , 2009, Accounts of chemical research.

[49]  F. Felpin,et al.  Preparation of 2-quinolones by sequential Heck reduction-cyclization (HRC) reactions by using a multitask palladium catalyst. , 2009, Chemistry.

[50]  David Anthony Barrow,et al.  Heck reactions using segmented flow conditions , 2009 .

[51]  D. Vos,et al.  Heterogeneous Catalytic Transformation of Citronellal to Menthol in a Single Step on Ir-Beta Zeolite Catalysts , 2009 .

[52]  F. Felpin,et al.  Improved Suzuki–Miyaura Reactions of Aryldiazonium Salts with Boronic Acids by Tuning Palladium on Charcoal Catalyst Properties , 2009 .

[53]  F. Felpin,et al.  Synthesis of oxindoles by tandem Heck-reduction-cyclization (HRC) from a single bifunctional, in situ generated Pd/C catalyst. , 2009, The Journal of organic chemistry.

[54]  F. Felpin,et al.  Heck Cross‐Coupling of Aryldiazonium Tetrafluoroborate with Acrylates Catalyzed by Palladium on Charcoal , 2008 .

[55]  Z. Boskovic,et al.  Copper + nickel-in-charcoal (Cu-Ni/C): a bimetallic, heterogeneous catalyst for cross-couplings. , 2008, Organic letters.

[56]  François-Xavier Felpin,et al.  Heterogeneous multifunctional catalysts for tandem processes: an approach toward sustainability. , 2008, ChemSusChem.

[57]  Jeffrey T. Kuethe,et al.  Suzuki–Miyaura Cross-Coupling of 2-Nitroarenediazonium Tetrafluoroborates: Synthesis of Unsymmetrical 2-Nitrobiphenyls and Highly Functionalized Carbazoles , 2008 .

[58]  A. Wagner,et al.  A one-pot synthesis of (E)-disubstituted alkenes by a bimetallic [Rh-Pd]-catalyzed hydrosilylation/hiyama cross-coupling sequence. , 2007, Chemistry.

[59]  F. Felpin,et al.  Suzuki-Miyaura reactions of arenediazonium salts catalyzed by PD(0)/C. One-pot chemoselective double cross-coupling reactions. , 2007, Organic letters.

[60]  C. Apesteguía,et al.  Design of catalyst systems for the one-pot synthesis of menthols from citral , 2007 .

[61]  I. Kozhevnikov,et al.  Pd–heteropoly acid as a bifunctional heterogeneous catalyst for one-pot conversion of citronellal to menthol , 2007 .

[62]  Mark E. Scott,et al.  Aryl-aryl bond formation by transition-metal-catalyzed direct arylation. , 2007, Chemical reviews.

[63]  M. Moreno-Mañas,et al.  Diazonium salts as substrates in palladium-catalyzed cross-coupling reactions. , 2006, Chemical Reviews.

[64]  D. Vos,et al.  Pt/H-beta zeolites as productive bifunctional catalysts for the one-step citronellal-to-menthol conversion , 2006 .

[65]  S. Mahajani,et al.  Synthesis of methyl isobutyl ketone from acetone over metal-doped ion exchange resin catalyst , 2006 .

[66]  E. N. Santos,et al.  Tandem catalysis: a taxonomy and illustrative review , 2004 .

[67]  C. Apesteguía,et al.  Highly selective synthesis of menthols from citral in a one-step process , 2004 .

[68]  Hoon Han,et al.  Cooperative multi-catalyst systems for one-pot organic transformations. , 2004, Chemical Society reviews.

[69]  D. D. De Vos,et al.  Ir-Beta zeolite as a heterogeneous catalyst for the one-pot transformation of citronellal to menthol. , 2004, Chemical communications.

[70]  J. Fierro,et al.  Direct synthesis of hydrogen peroxide solution with palladium-loaded sulfonic acid polystyrene resins , 2004 .

[71]  M. Kantam,et al.  A trifunctional catalyst for one-pot synthesis of chiral diols via Heck coupling-N-oxidation-asymmetric dihydroxylation: application for the synthesis of diltiazem and taxol side chain. , 2003, The Journal of organic chemistry.

[72]  K. Park,et al.  Sequential actions of palladium and cobalt nanoparticles immobilized on silica: one-pot synthesis of bicyclic enones by catalytic allylic alkylation and Pauson-Khand reaction. , 2002, Organic letters.

[73]  Paul T Anastas,et al.  Green chemistry: science and politics of change. , 2002, Science.

[74]  Paul T Anastas,et al.  Origins, current status, and future challenges of green chemistry. , 2002, Accounts of chemical research.

[75]  C. Song,et al.  Palladium-imidazolium carbene catalyzed Mizoroki-Heck coupling with aryl diazonium ions. , 2002, Organic letters.

[76]  M. Andrus,et al.  Palladium-imidazolium carbene catalyzed aryl, vinyl, and alkyl Suzuki-Miyaura cross coupling. , 2001, Organic letters.

[77]  N. Ravasio,et al.  Bifunctional copper catalysts. Part II. Stereoselective synthesis of (-)-menthol starting from (+)-citronellal , 2000 .

[78]  G. Neri,et al.  Role of the support in the hydrogenation of citronellal on ruthenium catalysts , 1999 .

[79]  Y. Fujioka,et al.  Syntheses and Physical Properties of Several symmetrical Sexiphenyls , 1980 .

[80]  C. Rondestvedt,et al.  Diels-Alder Reaction of Cinnamic Acid Derivatives with Cyclopentadiene , 1955 .

[81]  H. Widdecke,et al.  Saturated and Unsaturated Ketones Manufactured by Heterogeneous Catalysis , 1991 .

[82]  J. C. Emmett,et al.  Thyroid hormone analogues. Synthesis of 3'-substituted 3,5-diiodo-L-thyronines and quantitative structure-activity studies of in vitro and in vivo thyromimetic activities in rat liver and heart. , 1988, Journal of medicinal chemistry.