Direct measurement of electrospray droplets in submicron diameter using a freezing method and a TEM image processing technique

Abstract The size distributions of electrospray droplets from the Taylor cone in cone-jet mode are directly measured by using a freezing method and a transmission electron microscope (TEM) image processing technique. These results are compared with the data obtained by an aerodynamic size spectrometer (TSI Aerosizer DSP). The use of glycerol seeded with NaI and a freezing method make it possible to sample droplets with their original sizes preserved. Since pictures of droplets are taken with TEM with very low vapor pressure of the solution, evaporation is suppressed by freezing. For liquid flow rates below 1 nl/s, the measured droplet diameters by the TEM image processing technique and the aerosizer are in the range of 0.25–0.32 and 0.30– 0.40 μm , respectively. Both results are to some extent qualitatively in agreement with previous scaling law, however, they are two or three factors greater than those of the scaling law because of the much higher viscosity of the solution. Comparing the TEM data with the aerosizer measurements, it has been revealed that the TEM image processing technique can afford more accurate values of droplet size distributions in the submicron range of 0.1– 0.4 μm .

[1]  M. Cloupeau,et al.  Electrostatic spraying of liquids in cone-jet mode , 1989 .

[2]  E. Davis,et al.  MASS TRANSFER FROM A SINGLE MICRO-DROPLET TO A GAS FLOWING AT LOW REYNOLDS NUMBER , 1987 .

[3]  David Y. H. Pui,et al.  Experimental investigation of scaling laws for electrospraying: Dielectric constant effect , 1997 .

[4]  J. Giddings,et al.  NEW METHOD FOR PREDICTION OF BINARY GAS-PHASE DIFFUSION COEFFICIENTS , 1966 .

[5]  A. Naqwi.  IN SITU MEASUREMENT OF SUBMICRON DROPLETS IN ELECTROSPRAYS USING A PLANAR PHASE DOPPLER SYSTEM , 1994 .

[6]  David P. H. Smith,et al.  The Electrohydrodynamic Atomization of Liquids , 1986, IEEE Transactions on Industry Applications.

[7]  Bernard Vonnegut,et al.  PRODUCTION OF MONODISPERSE LIQUID PARTICLES BY ELECTRICAL ATOMIZATION. (PROJECT CIRRUS). OCCASIONAL REPORT NO. 36. Seventh Occasional Report. MULTIPLE-STAGE DILUTION OF AEROSOLS BY USE OF ASPIRATORS. (PROJECT CIRRUS). OCCASIONAL REPORT NO. 37. Eighth Occasional Report , 1952 .

[8]  J. Mora,et al.  The current emitted by highly conducting Taylor cones , 1994, Journal of Fluid Mechanics.

[9]  A. Sanfeld,et al.  Existence of charged droplets in a saturated atmosphere containing polluting molecules: A model for clouds, mists and spindrifts , 1998 .

[10]  J. Rosell-Llompart,et al.  Generation of submicron monodisperse aerosols in electrosprays , 1990 .

[11]  Wanguang Li,et al.  Aerosol Evaporation in the Transition Regime , 1996 .

[12]  P. W. Kidd.  Parametric studies with a single-needle colloid thruster. , 1968 .

[13]  K. C. Thong,et al.  The production of charged monodisperse fuel droplets by electrical dispersion , 1971 .

[14]  D. A. Saville,et al.  Stability of Electrically Charged Viscous Cylinders , 1971 .

[15]  J. Rosell-Llompart,et al.  Generation of monodisperse droplets 0.3 to 4 μm in diameter from electrified cone-jets of highly conducting and viscous liquids , 1994 .

[16]  A. Souyri,et al.  Dynamic behavior of single glycerol droplets in humid air streams , 1989 .

[17]  Y. Jaluria,et al.  An Introduction to Heat Transfer , 1950 .

[18]  David Y. H. Pui,et al.  Electrospraying of conducting liquids for monodisperse aerosol generation in the 4 nm to 1.8 μm diameter range , 1995 .

[19]  M. Huberman.  Measurement of the Energy Dissipated in the Electrostatic Spraying Process , 1970 .

[20]  Arnold Weissberger,et al.  Organic solvents;: Physical properties and methods of purification , 1970 .

[21]  A. Gañán-Calvo.  20.O.05 The size and charge of droplets in the electrospraying of polar liquids in cone-jet mode, and the minimum droplet size , 1994 .

[22]  A. Gomez,et al.  On the structure of an electrostatic spray of monodisperse droplets , 1994 .

[23]  Philip W. Kidd.  Erratum: "Parametric Studies with a Single-Needle Colloid Thruster" , 1968 .

[24]  John Zeleny,et al.  Instability of Electrified Liquid Surfaces , 1917 .