Performance and emission characteristics of a turbocharged spark-ignition hydrogen-enriched compressed natural gas engine under wide open throttle operating conditions

This paper investigates the effect of various hydrogen ratios in HCNG (hydrogen-enriched compressed natural gas) fuels on performance and emission characteristics at wide open throttle operating conditions using a turbocharged spark-ignition natural gas engine. The experimental data was taken at hydrogen fractions of 0%, 30% and 55% by volume and was conducted under different excess air ratio (λ) at MBT operating conditions. It is found that under various λ, the addition of hydrogen can significantly reduce CO, CH4 emissions and the NOx emission remain at an acceptable level when ignition timing is optimized. Using the same excess air ratio, as more hydrogen is added the power, exhaust temperatures and max cylinder pressure decrease slowly until the mixture’s lower heating value remains unchanged with the hydrogen enrichment, then they rise gradually. In addition, the early flame development period and the flame propagation duration are both shorter, and the indicated thermal efficiency and maximum heat release rate both increase with more hydrogen addition.

[1]  T. Nejat Veziroglu,et al.  21st Century's Energy: Hydrogen Energy System , 2008 .

[2]  Yin Cheng,et al.  Study on Property of a Stable Pressure Box with Damping Line for Engine Experiment , 2001 .

[3]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[4]  Yong Li,et al.  Effects of hydrogen addition on cycle-by-cycle variations in a lean burn natural gas spark-ignition engine , 2008 .

[5]  Zuo-hua Huang,et al.  Measurements of laminar burning velocities for natural gas–hydrogen–air mixtures , 2006 .

[6]  Bing Liu,et al.  Combustion behaviors of a direct-injection engine operating on various fractions of natural gas-hydrogen blends , 2007 .

[7]  A. Quader,et al.  Lean Combustion and the Misfire Limit in Spark Ignition Engines , 1974 .

[8]  T. W. Forest,et al.  Effect of hydrogen addition on the performance of methane-fueled vehicles. Part I: effect on S.I. engine performance , 2001 .

[9]  Marie Bysveen,et al.  Engine characteristics of emissions and performance using mixtures of natural gas and hydrogen , 2007 .

[10]  Meyer Steinberg,et al.  Modern and prospective technologies for hydrogen production from fossil fuels , 1989 .

[11]  Kirk Collier,et al.  Untreated Exhaust Emissions of a Hydrogen-Enriched CNG Production Engine Conversion , 1996 .

[12]  Ghazi A. Karim,et al.  Hydrogen as a spark ignition engine fuel , 2003 .

[13]  Yong Li,et al.  Experimental study on thermal efficiency and emission characteristics of a lean burn hydrogen enriched natural gas engine , 2007 .

[14]  Keshav S. Varde,et al.  A Study of The Flame Development and Rapid Burn Durations In A Lean-Burn Fuel Injected Natural Gas S.I. Engine , 1998 .