A review of the fatigue failure mechanism of metallic materials under a corroded environment

Abstract Assessment of the fatigue strength of pipeline steels is essential considering that the components are subjected to cycle loads in service. This paper presents a fatigue life assessment review of failure pipeline steels. Failure or deterioration of pipelines takes place by corrosion and fatigue, which later leads to rupture. Stress-life, strain-life, and linear elastic fracture mechanics crack propagation method has shown to be well accepted as a benchmark model of fatigue assessment. The relation curves are based on different cases of individual characterised fatigue properties. Other methods like probability and statistical-based assessment are employed to provide reliable results in the assessment of fatigue strength. This method deals with scatter data resulting from variations in sample parameters. It shows that choosing an appropriate and accurate method is important; particularly for quantifying the extent to which the fatigue life is reduced. Good predictions subsequently offer successful designs of pipelines and therefore, any unwanted damage can then be avoided.

[1]  Y. F. Cheng,et al.  Effect of alternating current on cathodic protection on pipelines , 2013 .

[2]  J. Neshati,et al.  2-Butyne-1,4-diol as a novel corrosion inhibitor for API X65 steel pipeline in carbonate/bicarbonate solution , 2012 .

[3]  Z. Azari,et al.  Influence of sandblasting and hydrogen on tensile and fatigue properties of pipeline API 5L X52 stee , 2011 .

[4]  E. A. Charles,et al.  Hydrogen embrittlement of high strength pipeline steels , 2006 .

[5]  L. Briottet,et al.  Quantifying the hydrogen embrittlement of pipeline steels for safety considerations , 2012 .

[6]  Robert Akid,et al.  Corrosion fatigue life prediction of a steel shaft material in seawater , 2013 .

[7]  G. P. Sendeckyj,et al.  Constant life diagrams : a historical review , 2001 .

[8]  T Breton,et al.  Identification of failure type in corroded pipelines: a bayesian probabilistic approach. , 2010, Journal of hazardous materials.

[9]  Thiru Aravinthan,et al.  Effectiveness of using fibre-reinforced polymer composites for underwater steel pipeline repairs , 2013 .

[10]  W. Ni,et al.  A mechanistic model for pipeline steel corrosion in supercritical CO2–SO2–O2–H2O environments , 2013 .

[11]  Meibao Chen,et al.  Researches on the Fatigue Crack Propagation of Pipeline Steel , 2012 .

[12]  D. Mohammadyani,et al.  Characterisation of weldment hardness, impact energy and microstructure in API X65 steel , 2012 .

[13]  Fakhruldin Mohd Hashim,et al.  Recent developments in in-line inspection tools (ILI) for deepwater pipeline applications , 2011, 2011 National Postgraduate Conference.

[14]  Hongyun Luo,et al.  Effects of micro-structure on fatigue crack propagation and acoustic emission behaviors in a micro-alloyed steel , 2013 .

[15]  J. Lesage,et al.  X-Ray Diffraction Study of Microstructural Changes During Fatigue Damage Initiation in Steel Pipes , 2012 .

[16]  John A. Beavers,et al.  Development of a Probabilistic Model for Stress Corrosion Cracking of Underground Pipelines Using Bayesian Networks: A Concept , 2012 .

[17]  M. H. Mohd,et al.  Investigation of the corrosion progress characteristics of offshore subsea oil well tubes , 2013 .

[18]  Mahmudur Rahman,et al.  FEA BASED DURABILITY USING STRAIN-LIFE MODELS FOR DIFFERENT MEDIUM CARBON STEEL AS FABRICATION MATERIALS FOR AN AUTOMOTIVE COMPONENT , 1970 .

[19]  J. Alamilla,et al.  Failure analysis and mechanical performance of an oil pipeline , 2013 .

[20]  M. A. Mohtadi-Bonab,et al.  Hydrogen induced cracking susceptibility in different layers of a hot rolled X70 pipeline steel , 2013 .

[21]  N. Birbilis,et al.  A green MnMgZn phosphate coating for steel pipelines transporting CO2 rich fluids , 2012 .

[22]  Yazhi Li,et al.  The interrelation of the parameters in the Paris equation of fatigue crack growth , 2012 .

[23]  Guian Qian,et al.  Probabilistic fracture assessment of piping systems based on FITNET FFS procedure , 2011 .

[24]  A. A. Oskuie,et al.  Electrochemical impedance spectroscopy analysis of X70 pipeline steel stress corrosion cracking in high pH carbonate solution , 2012 .

[25]  Qingyun Sha,et al.  Microstructure, mechanical properties and hydrogen induced cracking susceptibility of X80 pipeline steel with reduced Mn content , 2013 .

[26]  Chao Xu,et al.  Impact of SO2 concentration on the corrosion rate of X70 steel and iron in water-saturated supercritical CO2 mixed with SO2 , 2011 .

[27]  Y. Lin,et al.  Investigation of uniaxial low-cycle fatigue failure behavior of hot-rolled AZ91 magnesium alloy , 2013 .

[28]  Y. F. Cheng,et al.  Experimental and numerical studies of effectiveness of cathodic protection at corrosion defects on pipelines , 2014 .

[29]  Kusmono,et al.  Analysis of Internal Corrosion in Subsea Oil Pipeline , 2014 .

[30]  G. Malakondaiah,et al.  Effect of environment on corrosion characteristics of newly developed DMR-1700 structural steel , 2008, Science and technology of advanced materials.

[31]  Bin Ma,et al.  Assessment on failure pressure of high strength pipeline with corrosion defects , 2013 .

[32]  J. Gilgert,et al.  A fatigue initiation parameter for gas pipe steel submitted to hydrogen absorption , 2010 .

[34]  Mohammad Modarres,et al.  A probabilistic physics-of-failure model for prognostic health management of structures subject to pitting and corrosion-fatigue , 2011, Reliab. Eng. Syst. Saf..

[35]  F. Caleyo,et al.  Stochastic approach to pitting-corrosion-extreme modelling in low-carbon steel , 2010 .

[36]  Andrzej Seweryn,et al.  Low-cycle fatigue model of damage accumulation – The strain approach , 2010 .

[37]  Yun Xie,et al.  Corrosion behavior of novel 3%Cr pipeline steel in CO2 Top-of-Line Corrosion environment , 2012 .

[38]  J. Shuai,et al.  Measurement and analysis of crack tip opening angle in pipeline steels , 2012 .

[39]  Ilson P. Pasqualino,et al.  Fatigue analysis of damaged steel pipelines under cyclic internal pressure , 2009 .

[40]  Terje Haukaas,et al.  Optimal inspection planning for onshore pipelines subject to external corrosion , 2013, Reliab. Eng. Syst. Saf..

[41]  P. B. R. Dissanayake,et al.  Effect of High Amplitude Loading on Fatigue Life Prediction of Steel Bridges , 2011 .

[42]  M. Petrenec,et al.  Fatigue behavior of ferritic-pearlitic-bainitic steel in loading with positive mean stress , 2012 .

[43]  Duane S. Cronin,et al.  Failure prediction for Crack-in-Corrosion defects in natural gas transmission pipelines , 2012 .

[44]  M. Modarres,et al.  Reliability Analysis for Degradation Effects of Pitting Corrosion in Carbon Steel Pipes , 2011 .

[45]  Jiao Liu,et al.  Study of submarine pipeline corrosion based on ultrasonic detection and wavelet analysis , 2010, 2010 International Conference on Computer Application and System Modeling (ICCASM 2010).

[46]  P. G. Fazzini,et al.  Experimental determination of stress corrosion crack rates and service lives in a buried ERW pipeline , 2007 .

[47]  Cuiwei Du,et al.  Effects of solution environments under disbonded coatings on the corrosion behaviors of X70 pipeline steel in acidic soils , 2009 .

[48]  P. Refait,et al.  Estimation of residual corrosion rates of steel under cathodic protection in soils via voltammetry , 2013 .

[49]  R. S. Hrabovskyi Determination of the resource abilities of oil and gas pipelines working for a long time , 2009 .

[50]  F. M. Song,et al.  Predicting the mechanisms and crack growth rates of pipelines undergoing stress corrosion cracking at high pH , 2009 .

[51]  Yongxing Wang,et al.  Study on the mechanism of high-cycle corrosion fatigue crack initiation in X80 steel , 2012 .

[52]  V. Olden,et al.  3D cohesive modelling of hydrogen embrittlement in the heat affected zone of an X70 pipeline steel , 2013 .

[53]  M. Torres,et al.  Describing fatigue crack growth and load ratio effects in Al 2524 T3 alloy with an enhanced exponential model , 2012 .

[54]  Faisal Khan,et al.  Analysis of pitting corrosion on steel under insulation in marine environments , 2013 .

[55]  Weixing Chen,et al.  Fatigue of steel in air at low cyclic loading frequency , 2011 .

[56]  Ayhan Ince,et al.  A modification of Morrow and Smith–Watson–Topper mean stress correction models , 2011 .

[57]  Xiaogang Li,et al.  Mechanistic aspect of near-neutral pH stress corrosion cracking of pipelines under cathodic polarization , 2012 .

[58]  R. Melchers,et al.  Pitting corrosion in pipeline steel weld zones , 2011 .

[59]  Jung-Gu Kim,et al.  Acceleration and quantitative evaluation of degradation for corrosion protective coatings on buried pipeline: Part II. Application to the evaluation of polyethylene and coal-tar enamel coatings , 2013 .

[60]  Adam Niesłony,et al.  A study of compatibility between two classical fatigue curve models based on some selected structural materials , 2012 .

[61]  Y. F. Cheng,et al.  Development of a finite element model for simulation and prediction of mechanoelectrochemical effect of pipeline corrosion , 2013 .

[62]  Krishnaswamy Hariharan,et al.  Weighted error criterion to evaluate strain–fatigue life prediction methods , 2011 .

[63]  C. Guedes Soares,et al.  Palmgren–Miner’s rule and fracture mechanics-based inspection planning , 2011 .

[64]  Masayuki Kamaya,et al.  Strain-based modeling of fatigue crack growth – An experimental approach for stainless steel , 2012 .

[65]  Qingyuan Wang,et al.  Energy-Based Prediction of Low Cycle Fatigue Life High-Strength Structural Steel , 2012 .

[66]  A. S. Grema,et al.  Corrosion problems during oil and gas production and its mitigation , 2013, International Journal of Industrial Chemistry.

[67]  Anja Pfennig,et al.  Corrosion and corrosion fatigue of AISI 420C (X46Cr13) at 60 °C in CO2-saturated artificial geothermal brine , 2013 .

[68]  Ricardo Galván-Martínez,et al.  Mechanical and environmental effects on stress corrosion cracking of low carbon pipeline steel in a soil solution , 2012 .

[69]  Akram Alfantazi,et al.  Corrosion of the Heat-Affected Zones (HAZs) of API-X100 pipeline steel in dilute bicarbonate solutions at 90 °C – An electrochemical evaluation , 2013 .

[70]  Y. F. Cheng,et al.  Electrochemical polarization behavior of X70 steel in thin carbonate/bicarbonate solution layers trapped under a disbonded coating and its implication on pipeline SCC , 2010 .

[71]  C. Li,et al.  Stress Corrosion Cracking of Welded API X70 Pipeline Steel in Simulated Underground Water , 2013, Journal of Materials Engineering and Performance.

[72]  Hai-Jun Shen,et al.  Relations between the S-N, ε-N and da/dN-ΔK Curves of Materials , 2009 .

[73]  D. Lados,et al.  A unified method of design for fatigue crack growth resistance in structural materials , 2013 .

[74]  S. Yu,et al.  A method of probabilistic analysis for steel pipeline with correlated corrosion defects , 2009 .

[75]  Xiaogang Li,et al.  Influence of carbon on stress corrosion cracking of high strength pipeline steel , 2013 .

[76]  Mostafa Alizadeh,et al.  Effects of microstructure alteration on corrosion behavior of welded joint in API X70 pipeline steel , 2013 .

[77]  Y. F. Cheng,et al.  Micro-electrochemical characterization and Mott–Schottky analysis of corrosion of welded X70 pipeline steel in carbonate/bicarbonate solution , 2009 .

[78]  Chengshuang Zhou,et al.  The effect of the partial pressure of H2S on the permeation of hydrogen in low carbon pipeline steel , 2013 .

[79]  A. Syrotyuk,et al.  Relationship between fatigue crack growth behaviour and local hydrogen concentration near crack tip in pipeline steel , 2013 .

[80]  Mario Guagliano,et al.  Fatigue behavior of X70 microalloyed steel after severe shot peening , 2013 .

[81]  S. Adeosun,et al.  Comparative studies on mechanical and corrosion characteristics of API 5LX60 Steel and RST 37-2 Steel , 2012 .

[82]  Alfonso Fernández-Canteli,et al.  A general regression model for statistical analysis of strain–life fatigue data , 2008 .

[83]  N. Acuña-González,et al.  Early Corrosion Fatigue Damage on Stainless Steels Exposed to Tropical Seawater: A Contribution from Sensitive Electrochemical Techniques , 2012 .

[84]  Valeriu V. Jinescu Critical energy approach for the fatigue life calculation under blocks with different normal stresses amplitudes , 2013 .

[85]  Felipe Alexander Vargas Bazán,et al.  Stochastic process corrosion growth models for pipeline reliability , 2013 .

[86]  J. Neshati,et al.  Failure analysis of stress corrosion cracking occurred in a gas transmission steel pipeline , 2011 .

[87]  Luis Volnei Sudati Sagrilo,et al.  Reliability of non-destructive test techniques in the inspection of pipelines used in the oil industry , 2008 .

[88]  P. Fassina,et al.  Fatigue Behavior Of Pipeline Steel Under Hydrogen Environment And Low Temperature , 2011 .

[89]  M. Javidi,et al.  Investigating the mechanism of stress corrosion cracking in near-neutral and high pH environments for API 5L X52 steel , 2014 .

[90]  S. Abdullah,et al.  Acoustic Emission Study of Corrosion Fatigue and Fatigue for API 5L X70 Gas Pipeline Steel , 2011 .

[91]  V. Smanio,et al.  Contribution of acoustic emission to the understanding of sulfide stress cracking of low alloy steels , 2011 .

[92]  R. Melchers,et al.  A numerical study of damage caused by combined pitting corrosion and axial stress in steel pipes , 2013 .

[93]  Shahrum Abdullah,et al.  Fatigue crack growth rate of API X70 steel pipelines under spectrum loading , 2012 .

[94]  Alaa Chateauneuf,et al.  Maintenance planning under imperfect inspections of corroded pipelines , 2013 .

[95]  Donavan Marney,et al.  The science of pipe corrosion: A review of the literature on the corrosion of ferrous metals in soils , 2012 .

[96]  Xiaogang Li,et al.  Effect of Strength and Microstructure on Stress Corrosion Cracking Behavior and Mechanism of X80 Pipeline Steel in High pH Carbonate/Bicarbonate Solution , 2014, Journal of Materials Engineering and Performance.

[97]  Richard Kania,et al.  Stress corrosion cracking initiation under the disbonded coating of pipeline steel in near-neutral pH environment , 2010 .

[98]  D. Kong,et al.  Stress Corrosion of X80 Pipeline Steel Welded Joints by Slow Strain Test in NACE H2S Solutions , 2013 .

[99]  Rachel C. Thomson,et al.  Effect of crack depth on fatigue crack growth rates for a C–Mn pipeline steel in a sour environment , 2010 .

[100]  Pengfei Liu,et al.  Failure analysis of natural gas buried X65 steel pipeline under deflection load using finite element method , 2010 .

[101]  Adam Niesłony,et al.  Mean stress effect correction using constant stress ratio S–N curves , 2013 .