Removal of formaldehyde, methanol, dimethylether and carbon monoxide from waste gases of synthetic resin-producing industries.

The removal of mixtures of gas-phase pollutants released from formaldehyde- and formaldehyde resin-producing industries was studied in different bioreactor systems. The waste gases contained formaldehyde, methanol, dimethylether and carbon monoxide. The use of a hybrid two-stage bioreactor, composed of a biotrickling filter and a conventional biofilter connected in series, led to very high elimination capacities and removal efficiencies close to 100% for overall pollutant loads exceeding 600g m(-3)h(-1). The presence of low concentrations of dimethylether in the gaseous mixture did not have a significant effect on the removal of formaldehyde or methanol under our operating conditions, although moderate concentrations of these compounds did negatively affect the biodegradation of dimethylether. When a mixture of all four compounds, at concentrations around 100, 100, 50 and 50mg m(-3) for formaldehyde, methanol, carbon monoxide and dimethylether, respectively, was fed to a conventional biofilter, removal efficiencies higher than 80% were obtained for the first three pollutants at empty bed retention time values above 30s. On the other hand, dimethylether was removed to a lower extent, although its reduced environmental impact allows to conclude that these results were satisfactory.

[1]  Bioreactor design studies for a hydrogen-producing bacterium. , 2002, Applied biochemistry and biotechnology.

[2]  D. Grant Allen,et al.  Biofiltration of mixtures of hydrophilic and hydrophobic volatile organic compounds , 2000 .

[3]  C. Kennes,et al.  Bioreactors for Waste Gas Treatment , 2001 .

[4]  Christian Kennes,et al.  Biofiltration of waste gases containing a mixture of formaldehyde and methanol , 2004, Applied Microbiology and Biotechnology.

[5]  C. Kennes,et al.  Bioprocesses for the removal of nitrogen oxides from polluted air , 2005 .

[6]  Marc A. Deshusses,et al.  Behavior of Field-Scale Biotrickling Filter under Nonsteady State Conditions , 2004 .

[7]  S. Møller,et al.  Activity of Toluene-degrading Pseudomonas putida in the early growth phase of a biofilm for waste gas treatment. , 1997, Biotechnology and bioengineering.

[8]  C. Kennes,et al.  Formaldehyde biodegradation in the presence of methanol under denitrifying conditions , 2006 .

[9]  Johan W. van Groenestijn,et al.  Biotechniques for air pollution control: past, present and future trends , 2005 .

[10]  C. Kennes,et al.  Review: Waste gas biotreatment technology , 1998 .

[11]  C. Kennes,et al.  Optimization of nutrient supply in a downflow gas-phase biofilter packed with an inert carrier , 2002, Applied Microbiology and Biotechnology.

[12]  C. Kennes,et al.  Inert filter media for the biofiltration of waste gases – characteristics and biomass control , 2002 .

[13]  C. Kennes,et al.  Effect of key parameters on the removal of formaldehyde and methanol in gas-phase biotrickling filters. , 2006, Journal of hazardous materials.

[14]  C. Kennes,et al.  Treatment of gas-phase methanol in conventional biofilters packed with lava rock. , 2005, Water research.

[15]  P. Martikainen,et al.  Oxidation of Gas Mixtures Containing Dimethyl Sulfide, Hydrogen Sulfide, and Methanethiol Using a Two-Stage Biotrickling Filter , 2001, Journal of the Air & Waste Management Association.

[16]  Spiros N. Agathos,et al.  Biotechnology for the Environment: Wastewater Treatment and Modeling, Waste Gas Handling , 2003, Focus on Biotechnology.

[17]  E. Lee.  Continuous treatment of gas-phase trichloroethylene by Burkholderia cepacia G4 in a two-stage continuous stirred tank reactor/trickling biofilter system. , 2003, Journal of bioscience and bioengineering.

[18]  C. Kennes,et al.  Biodegradation of toluene by the new fungal isolates Paecilomyces variotii and Exophiala oligosperma , 2005, Journal of Industrial Microbiology and Biotechnology.

[19]  James R. Mihelcic,et al.  Field Measurements and Modeling of Two-Stage Biofilter that Treats Odorous Sulfur Air Emissions , 2003 .

[20]  S. Ottengraf,et al.  Long term performance of biotrickling filters removing a mixture of volatile organic compounds from an artificial waste gas: dichloromethane and methylmethacrylate , 1999 .

[21]  Christian Kennes,et al.  Fungal biocatalysts in the biofiltration of VOC-polluted air. , 2004, Journal of biotechnology.

[22]  B. C. Baltzis,et al.  Biofiltration of methanol vapor , 1993, Biotechnology and bioengineering.

[23]  T NASH,et al.  The colorimetric estimation of formaldehyde by means of the Hantzsch reaction. , 1953, The Biochemical journal.

[24]  E. Wolfrum,et al.  Bioreactor Development for Biological Hydrogen Production , 2002 .

[25]  C. Kennes,et al.  Bioreactors for the Treatment of Industrial Waste Gases Containing Formaldehyde and Other Aliphatic Compounds , 2003 .

[26]  R. Amal,et al.  Effect of inlet mass loading, water and total bacteria count on methanol elimination using upward flow and downward flow biofilters , 2000 .

[27]  J. van Ham,et al.  Biotechniques for air pollution abatement and odour control policies : proceedings of an international symposium, Maastricht, the Netherlands, 27-29 October, 1991 , 1992 .

[28]  M. D. Fumi,et al.  VOCs removal from waste gases: gas-phase bioreactor for the abatement of hexane by Aspergillus niger , 2003 .

[29]  Jianmeng Chen,et al.  Effects of gas flow‐rate and inlet concentration on nitric oxide removal in an autotrophic biofilter , 2006 .

[30]  J. Devinny,et al.  Evaluation of a two-stage biofilter for treatment of POTW waste air , 1999 .

[31]  O. Meyer,et al.  Oxidation of Carbon Monoxide in Cell Extracts of Pseudomonas carboxydovorans , 1979, Journal of bacteriology.

[32]  M. Deshusses,et al.  Retrofitting existing chemical scrubbers to biotrickling filters for H2S emission control , 2003, Proceedings of the National Academy of Sciences of the United States of America.