The effect of oxygen and nitrogen additives on the growth of nanocrystalline diamond films

Nanocrystalline diamond (NCD) films have been synthesized by using either nitrogen addition or oxygen addition to conventional CH4/H2 mixtures besides the most commonly used Ar/CH4 with or without H2 chemistry. However, the synthesis of NCD films using both nitrogen and oxygen addition simultaneously into CH4/H2 gases has not been reported thus far. In this work, we investigate the effect of simultaneous O2 and N2 addition to CH4/H2 plasma on the growth of nanocrystalline diamond (NCD) films, focusing particularly on the ratio between the amount of O2 and N2 additives into conventional CH4/H2 gas mixtures on the morphology, microstructure, texture, and crystalline quality of the NCD films. The NCD samples were produced by using a high microwave power (3 kW) in a microwave plasma-assisted chemical vapour deposition reactor with a maximum power of 5 kW on large silicon wafers, 2 inches in diameter, and characterized by high-resolution scanning electron microscopy, x-ray diffraction and micro-Raman spectroscopy. Our work demonstrates that, under the conditions investigated here, NCD films can be formed when the ratio of O2/N2 addition is increased from 0 through 1 up to 7/3 (at higher than 7/3, for example 4, a large-grained polycrystalline diamond film will form), and the crystalline quality is significantly enhanced with the increase of oxygen addition. The mechanism of O2 and N2 additives on the formation of NCD films is briefly studied.

[1]  P. May,et al.  Microcrystalline, nanocrystalline, and ultrananocrystalline diamond chemical vapor deposition: Experiment and modeling of the factors controlling growth rate, nucleation, and crystal size , 2007 .

[2]  Rui F. Silva,et al.  Growth rate improvements in the hot-filament CVD deposition of nanocrystalline diamond , 2006 .

[3]  Paresh Chandra Ray,et al.  Role of inert gas in the low-temperature nano-diamond chemical vapour deposition process , 2006 .

[4]  P. May,et al.  Deposition of NCD films using hot filament CVD and Ar/CH4/H2 gas mixtures , 2006 .

[5]  J. Röpcke,et al.  Modeling of microwave discharges of H2 admixed with CH4 for diamond deposition , 2005 .

[6]  W. Hofmeister,et al.  The effect of growth rate control on the morphology of nanocrystalline diamond , 2005 .

[7]  P. Bruno,et al.  Formation of 〈110〉 texture during nanocrystalline diamond growth: an X-ray diffraction study , 2005 .

[8]  Khaled Hassouni,et al.  Nucleation, growth and characterization of nanocrystalline diamond films , 2005 .

[9]  I. Lin,et al.  Growth of microcrystalline and nanocrystalline diamond films by microwave plasmas in a gas mixture of 1% methane/5% hydrogen/94% argon , 2004 .

[10]  John A. Carlisle,et al.  Low temperature growth of ultrananocrystalline diamond , 2004 .

[11]  Jin-Seok Park,et al.  Electron-emission from nano- and micro-crystalline diamond films: the effects of nitrogen and oxygen additives , 2004 .

[12]  Richard B. Jackman,et al.  Spectroscopic impedance study of nanocrystalline diamond films , 2003 .

[13]  H. Kuzmany,et al.  Evidence for trans-polyacetylene in nanocrystalline diamond films from H–D isotropic substitution experiments , 2003 .

[14]  D. Gruen,et al.  Morphology and electronic structure in nitrogen-doped ultrananocrystalline diamond , 2002 .

[15]  Y. Vohra,et al.  Gas-phase thermodynamic models of nitrogen-induced nanocrystallinity in chemical vapor-deposited diamond , 2002 .

[16]  D. Gruen,et al.  Microstructure of ultrananocrystalline diamond films grown by microwave Ar–CH4 plasma chemical vapor deposition with or without added H2 , 2001 .

[17]  M. Kanatzidis,et al.  Transitions in morphology observed in nitrogen/methane-hydrogen depositions of polycrystalline diamond films , 2001 .

[18]  J. Robertson,et al.  Origin of the 1 1 5 0 − cm − 1 Raman mode in nanocrystalline diamond , 2001 .

[19]  David N. Jamieson,et al.  The Raman spectrum of nanocrystalline diamond , 2000 .

[20]  J. Asmussen,et al.  THE EFFECT OF NITROGEN ON THE GROWTH, MORPHOLOGY, AND CRYSTALLINE QUALITY OF MPACVD DIAMOND FILMS , 1999 .

[21]  R. Chang,et al.  Synthesis and electron field emission of nanocrystalline diamond thin films grown from N2/CH4 microwave plasmas , 1997 .

[22]  R. Haubner,et al.  Influence of nitrogen additions on hot‐filament chemical vapor deposition of diamond , 1996 .

[23]  Frank Fuchs,et al.  Nitrogen induced increase of growth rate in chemical vapor deposition of diamond , 1996 .

[24]  P. Koidl,et al.  Nitrogen stabilized 〈100〉 texture in chemical vapor deposited diamond films , 1994 .

[25]  Dieter M. Gruen,et al.  Fullerenes as precursors for diamond film growth without hydrogen or oxygen additions , 1994 .

[26]  H. Ehrhardt,et al.  Preparation of smooth and nanocrystalline diamond films , 1993 .

[27]  Wang,et al.  Detailed surface and gas-phase chemical kinetics of diamond deposition. , 1991, Physical review. B, Condensed matter.

[28]  P. Koidl,et al.  Texture formation in polycrystalline diamond films , 1990 .

[29]  S. Harris,et al.  Effects of oxygen on diamond growth , 1989 .

[30]  Jacqueline A. Johnson,et al.  Interpretation of the Raman spectra of ultrananocrystalline diamond , 2005 .

[31]  A. Fernandes,et al.  Study the effect of O2 addition on hydrogen incorporation in CVD diamond , 2004 .

[32]  Hans Kuzmany,et al.  The mystery of the 1140 cm−1 Raman line in nanocrystalline diamond films , 2004 .

[33]  K. H. Chen,et al.  Growth of highly transparent nanocrystalline diamond films and a spectroscopic study of the growth , 2001 .