Application of PVDF membranes in desalination and comparison of the VMD and DCMD processes

Abstract Membrane distillation (MD) is a promising desalination technology that may help to resolve the fresh water shortage. Hydrophobic flat-sheet polyvinylidene fluoride (PVDF) membranes were used for desalination by direct contact MD (DCMD) and vacuum MD (VMD) processes. The effect of the operating conditions, such as the feed temperature, flow velocity on both the hot and cold sides and the concentration of the feed solution were investigated. During the DCMD processing of a 35 g/L aqueous NaCl solution, with a hot side temperature of 73 °C and a cold distillate water temperature of 25 °C, the permeate flux was as high as 18.9 kg/m 2  h with a NaCl rejection of 99.8%. A permeate flux of 22.4 kg/m 2  h and a NaCl rejection of 99.9% were attained during the VMD process at the same feed temperature and a downstream pressure of 31.5 kPa. Furthermore, there was hardly any wetting during 6 h desalination test. A dusty gas model was used to successfully predict the permeating flux in both the DCMD and VMD processes, and the mass transfer mechanisms through the membrane were determined. Comparison of the flux and the thermal efficiency in the DCMD and VMD processes under the same conditions demonstrated that this type of thin flat-sheet membrane, which had a high surface hydrophobicity and a sponge-like cross-section, was more suitable for use in the VMD process than in the DCMD process.

[1]  Kai Yu Wang,et al.  Effect of inner-layer thermal conductivity on flux enhancement of dual-layer hollow fiber membranes in direct contact membrane distillation , 2010 .

[2]  K. Smolders,et al.  Terminology for Membrane Distillation , 1989 .

[3]  Kai Yu Wang,et al.  Mixed Matrix PVDF Hollow Fiber Membranes with Nanoscale Pores for Desalination through Direct Contact Membrane Distillation , 2009 .

[4]  Anthony G. Fane,et al.  Effect of pore size distribution and air flux on mass transport in direct contact membrane distillation , 2003 .

[5]  Seeram Ramakrishna,et al.  Production of drinking water from saline water by air-gap membrane distillation using polyvinylidene fluoride nanofiber membrane , 2008 .

[6]  M. Khayet.  Membranes and theoretical modeling of membrane distillation: a review. , 2011, Advances in colloid and interface science.

[7]  Mohamed Khayet,et al.  Theory and experiments on sweeping gas membrane distillation , 2000 .

[8]  Marek Gryta,et al.  Influence of polypropylene membrane surface porosity on the performance of membrane distillation process , 2007 .

[9]  Jun-de Li,et al.  Performance of asymmetric hollow fibre membranes in membrane distillation under various configurations and vacuum enhancement , 2010 .

[10]  Mohamed Khayet,et al.  A Monte Carlo simulation model for vacuum membrane distillation process , 2007 .

[11]  Anthony G. Fane,et al.  Mass transfer mechanisms and transport resistances in direct contact membrane distillation process , 2006 .

[12]  M. Vázquez-González,et al.  Water distillation through poly(tetrafluoroethylene) hydrophobic membranes in a stirred cell , 1994 .

[13]  M. Qtaishat,et al.  Design of novel direct contact membrane distillation membranes , 2006 .

[14]  K.S.M.S. Raghavarao,et al.  Mass transfer in osmotic membrane distillation , 2006 .

[15]  D. R. Lloyd,et al.  Membrane distillation. II. Direct contact MD , 1996 .

[16]  D. R. Lloyd,et al.  Membrane distillation. I. Module design and performance evaluation using vacuum membrane distillation , 1996 .

[17]  Xing Yang,et al.  Performance improvement of PVDF hollow fiber-based membrane distillation process , 2011 .

[18]  Mohamed Khayet,et al.  Modelling Transport Mechanism Through A Porous Partition , 2001 .

[19]  Mohamed Khayet,et al.  A framework for better understanding membrane distillation separation process , 2006 .

[20]  F. J. Florido-Díaz,et al.  Theoretical and experimental studies on desalination using membrane distillation , 2001 .

[21]  Noam Lior,et al.  Membrane-distillation desalination: Status and potential , 2005 .

[22]  Anthony G. Fane,et al.  Heat and mass transfer in membrane distillation , 1987 .

[23]  C. Dosoretz,et al.  Heat transfer in vacuum membrane distillation: Effect of velocity slip , 2009 .

[24]  Enrico Drioli,et al.  Direct contact membrane distillation: modelling and concentration experiments , 2000 .

[25]  Giulio C. Sarti,et al.  Vacuum membrane distillation: Experiments and modeling , 1997 .

[26]  Mohamed Khayet,et al.  Characterization of membranes for membrane distillation by atomic force microscopy and estimation of their water vapor transfer coefficients in vacuum membrane distillation process , 2004 .

[27]  Anthony G. Fane,et al.  Desalination by membrane distillation adopting a hydrophilic membrane , 2005 .

[28]  E. Drioli,et al.  Membrane Distillation and Related Operations—A Review , 2005 .

[29]  L. Martinez-diez,et al.  Temperature and concentration polarization in membrane distillation of aqueous salt solutions , 1999 .

[30]  Fawzi Banat,et al.  Theoretical and experimental study in membrane distillation , 1994 .

[31]  Anthony G. Fane,et al.  A new model for mass transfer in direct contact membrane distillation , 2003 .

[32]  Pedro Prádanos,et al.  Characterisation of three hydrophobic porous membranes used in membrane distillation , 2002 .

[33]  Giulio C. Sarti,et al.  Heat and mass transport resistances in vacuum membrane distillation per drop , 1999 .