Modeling condensation heat transfer on a horizontal finned tube in the presence of noncondensable gases

Abstract European designs for the next generation of nuclear reactors incorporate innovative passive systems in their containments to enhance heat removal by condensation under postulated accident conditions. These systems consist of several units of cross-flow finned tube bundles internally cooled with water. So far most of the studies that have been addressed to the issue of heat transfer onto finned surfaces under condensing conditions have involved refrigerants and pure vapor conditions. This study presents a model (HTCFIN) capable of predicting condensation of a cross-flow air–steam mixture onto a single horizontal finned tube. The comparison of HTCFIN predictions to the available databases shows its acceptable accuracy in a wide range of conditions and allows an interpretation of the influence of major variables acting on the scenario. As a consequence, HTCFIN model represents a step forward in the present theoretical capability to estimate heat transfer within containments of next generation of European reactors in the case of a hypothetical accident.

[1]  H. Honda,et al.  A prediction method for heat transfer during film condensation on horizontal low integral-fin tubes , 1987 .

[2]  S. Churchill,et al.  A Correlating Equation for Forced Convection From Gases and Liquids to a Circular Cylinder in Crossflow , 1977 .

[3]  S. Churchill,et al.  Correlating equations for laminar and turbulent free convection from a vertical plate , 1975 .

[4]  T. M. Rudy,et al.  Prediction of the Condensation Coefficient on Horizontal Integral-Fin Tubes , 1985 .

[5]  Per F. Peterson,et al.  Diffusion Layer Theory for Turbulent Vapor Condensation With Noncondensable Gases , 1993 .

[6]  A. Briggs,et al.  Accurate Heat Transfer Measurements for Condensation on Horizontal, Integral-Fin Tubes , 1992 .

[7]  Per F. Peterson,et al.  An investigation of condensation from steam–gas mixtures flowing downward inside a vertical tube , 1997 .

[8]  Warren M. Rohsenow,et al.  Heat Mass and Momentum Transfer , 1961 .

[9]  Thomas Adamek,et al.  Bestimmung der Kondensationsgrößen auf feingewellten Oberflächen zur Auslegung optimaler Wandprofile , 1981 .

[10]  P. J. Marto.  An Evaluation of Film Condensation on Horizontal Integral-Fin Tubes , 1988 .

[11]  K. Murata,et al.  PREDICTION OF CONDENSATION HEAT TRANSFER COEFFICIENT IN HORIZONTAL INTEGRAL-FIN TUBE BUNDLES , 1992 .

[12]  R. Webb,et al.  Prediction of film condensation on horizontal integral fin tubes , 1990 .

[13]  Jonathan Rose,et al.  Forced Convection Condensation on a Horizontal Tube—Experiments With Vertical Downflow of Steam , 1989 .

[14]  Jonathan Rose,et al.  Approximate equations for forced-convection condensation in the presence of a non-condensing gas on a flat plate and horizontal tube , 1980 .

[15]  Nakai Seiichi,et al.  HEAT TRANSFER FROM A HORIZONTAL CIRCULAR WIRE AT SMALL REYNOLDS AND GRASHOF NUMBERS-II , 1975 .

[16]  S. T. Keswani,et al.  INVESTIGATION OF SURFACE TENSION AND GRAVITY EFFECTS IN FILM CONDENSATION , 1982 .

[17]  Luis E. Herranz,et al.  A diffusion layer model for steam condensation within the AP600 containment , 1998 .

[18]  Ralph L. Webb,et al.  An Analytical Model to Predict Condensate Retention on Horizontal Integral-Fin Tubes , 1985 .

[19]  Stuart W. Churchill,et al.  Correlations for Laminar Forced Convection with Uniform Heating in Flow over a Plate and in Developing and Fully Developed Flow in a Tube , 1973 .

[20]  R. Reid,et al.  The Properties of Gases and Liquids , 1977 .

[21]  Luis E. Herranz,et al.  Experimental analysis of heat transfer within the AP600 containment under postulated accident conditions , 1998 .

[22]  Gumersindo Verdú,et al.  Turbulent vapor condensation with noncondensable gases in vertical tubes , 1996 .

[23]  Jonathan Rose,et al.  Effect of Fin Spacing on the Performance of Horizontal Integral-Fin Condenser Tubes , 1985 .

[24]  Gumersindo Verdú,et al.  Heat transfer modeling in the vertical tubes of the passive containment cooling system of the simplified boiling water reactor , 1997 .

[25]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[26]  Adrian Briggs,et al.  Condensation of steam and R113 on a bank of horizontal tubes in the presence of a noncondensing gas , 1995 .

[27]  P. Peterson.  Theoretical basis for the uchida correlation for condensation in reactor containments , 1996 .

[28]  P. J. Marto,et al.  Film Condensation of Steam on Horizontal Finned Tubes: Effect of Fin Spacing , 1986 .