Disposable PVDF ultrasonic transducers for nondestructive testing applications

Disposable ultrasonic contact transducers have been constructed with inexpensive PVDF films for nondestructive testing (NDT) applications. This paper reports the temperature-dependent ultrasonic performance of commercial polyvinylidene fluoride (PVDF) films and PVDF sensors. PVDF film was evaluated for its material properties of interest for ultrasonic transducer performance including the relative dielectric constant /spl epsi//sub r/, dielectric loss tangent tan /spl delta//sub e/, electromechanical coupling constant k/sub t/, mechanical quality factor Q/sub m/, and acoustic impedance Z. Disposable PVDF transducers were then coupled to both low and high acoustic impedance test panels and their ultrasonic insertion loss/sensitivity and frequency bandwidth measured as a function of temperature in both the pulse-echo and pitch-catch modes. The results yielded center frequencies in the 3.5-16 MHz range, with -6-dB fractional bandwidths for some of the transducers exceeding 100%. The temperature dependence of the transducers' performance is reported for the -40 to 80/spl deg/C range and shows an approximate linear decrease in center frequency and increase in fractional bandwidth with increasing temperature. These measured results are compared with predictions from computer simulations based on Mason's model. These tests showed that the same disposable transducers can be used for both ultrasonic and acoustic emission sensing NDT applications. This paper summarizes the quantitative ultrasonic and vibration sensing performance for all of the disposable PVDF film transducers which were tested.

[1]  H. Ohigashi,et al.  Electromechanical properties of polarized polyvinylidene fluoride films as studied by the piezoelectric resonance method , 1976 .

[2]  Dominique Broussoux,et al.  Acoustic and Dielectric Loss Processes in PVF2 , 1980 .

[3]  S. Saitoh,et al.  The Method of Determining ktand Qm, for Low Q Piezoelectric Materials , 1985, IEEE 1985 Ultrasonics Symposium.

[4]  R. Newnham,et al.  Measurement of Complex Coefficients for Thick PVDF Polymer , 1987, IEEE 1987 Ultrasonics Symposium.

[5]  J. Herbert,et al.  The Applications of Ferroelectric Polymers , 1988 .

[6]  F. Foster,et al.  Determination of electromechanical coupling coefficients in transducer materials with high mechanical losses , 1988, IEEE 1988 Ultrasonics Symposium Proceedings..

[7]  Hiroji Ohigashi,et al.  Analysis of Frequency Response Characteristics of Polymer Ultrasonic Transducers , 1988 .

[8]  Vijay K. Varadan,et al.  Measurement of all the elastic and dielectric constants of poled PVDF films , 1989, Proceedings., IEEE Ultrasonics Symposium,.

[9]  L. Brown,et al.  Ultrasound transducer models for piezoelectric polymer films , 1989, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[10]  New ferroelectric polymer ultrasound contact transducers for nondestructive testing applications , 1990, [Proceedings] 1990 IEEE 7th International Symposium on Applications of Ferroelectrics.

[11]  Michael Platte,et al.  PVDF Ultrasonic Transducers for Non-Destructive Testing , 1991 .

[12]  Piezoelectric Properties of β-Form PVDF Films Crystallized at High Pressure and Their Applications to Heat-Resistant Ultrasonic Transducers , 1991 .

[13]  Lewis F. Brown.  New developments in piezoelectric polymer ultrasound transducers and transducer systems , 1992, SPIE Optics + Photonics.

[14]  David Vilkomerson,et al.  Quasi-omnidirectional transducers for ultrasonic electronic-beacon guidance of invasive devices , 1992, SPIE Optics + Photonics.

[15]  L. Brown.  New extremely broadband ferroelectric polymer ultrasound transducers , 1992, ISAF '92: Proceedings of the Eighth IEEE International Symposium on Applications of Ferroelectrics.

[16]  L. Brown,et al.  Ferroelectric polymers: current and future ultrasound applications , 1992, IEEE 1992 Ultrasonics Symposium Proceedings.

[17]  A technique for the high-speed characterization of ultrasonic transducer insertion loss performance. , 1993, Biomedical sciences instrumentation.

[18]  Lewis F. Brown,et al.  Custom PVDF Transducers for Pulse-Echo Testing of Solid Rocket Motors for Detection of Propellant-to-Boot-Liner Unbonds , 1993 .

[19]  L. Brown.  Large-area ultrasonic gap profile measurements using two-dimensional PVDF "blanket array" transducers , 1995, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.