A Fully Coupled Computational Fluid Dynamics Method for Analysis of Semi-Submersible Floating Offshore Wind Turbines Under Wind-Wave Excitation Conditions Based on OC5 Data

Accurate prediction of the time-dependent system dynamic responses of floating offshore wind turbines (FOWTs) under aero-hydro-coupled conditions is a challenge. This paper presents a numerical modeling tool using commercial computational fluid dynamics software, STAR-CCM+(V12.02.010), to perform a fully coupled dynamic analysis of the DeepCwind semi-submersible floating platform with the National Renewable Engineering Lab (NREL) 5-MW baseline wind turbine model under combined wind–wave excitation environment conditions. Free-decay tests for rigid-body degrees of freedom (DOF) in still water and hydrodynamic tests for a regular wave are performed to validate the numerical model by inputting gross system parameters supported in the Offshore Code Comparison, Collaboration, Continued, with Correlations (OC5) project. A full-configuration FOWT simulation, with the simultaneous motion of the rotating blade due to 6-DOF platform dynamics, was performed. A relatively heavy load on the hub and blade was observed for the FOWT compared with the onshore wind turbine, leading to a 7.8% increase in the thrust curve; a 10% decrease in the power curve was also observed for the floating-type turbines, which could be attributed to the smaller project area and relative wind speed required for the rotor to receive wind power when the platform pitches. Finally, the tower-blade interference effects, blade-tip vortices, turbulent wakes, and shedding vortices in the fluid domain with relatively complex unsteady flow conditions were observed and investigated in detail.

[1]  F. Menter.  Two-equation eddy-viscosity turbulence models for engineering applications , 1994 .

[2]  Jason Jonkman,et al.  Dynamics Modeling and Loads Analysis of an Offshore Floating Wind Turbine , 2007 .

[3]  Matthew A. Lackner,et al.  DEVELOPMENT OF A FREE VORTEX WAKE METHOD CODE FOR OFFSHORE FLOATING WIND TURBINES , 2012 .

[4]  Yuri Bazilevs,et al.  Fluid–structure interaction modeling of wind turbines: simulating the full machine , 2012, Computational Mechanics.

[5]  Jason Jonkman,et al.  Validation of a FAST semi-submersible floating wind turbine numerical model with DeepCwind test data , 2013 .

[6]  Jun Xu,et al.  CFD Simulation of a Floating Offshore Wind Turbine System Using a Quasi-Static Crowfoot Mooring-Line Model , 2014 .

[7]  Jinseop Song,et al.  Computational Fluid Dynamic Analysis of a Floating Offshore Wind Turbine Experiencing Platform Pitching Motion , 2014 .

[8]  Torgeir Moan,et al.  Effect of wind turbine surge motion on rotor thrust and induced velocity , 2014 .

[9]  Jinping Ou,et al.  Coupled wind-wave time domain analysis of floating offshore wind turbine based on Computational Fluid Dynamics method , 2014 .

[10]  Eric G. Paterson,et al.  Development and validation of a tightly coupled CFD/6-DOF solver for simulating floating offshore wind turbine platforms , 2015 .

[11]  Atilla Incecik,et al.  Full-scale unsteady RANS CFD simulations of ship behaviour and performance in head seas due to slow steaming , 2015 .

[12]  Decheng Wan,et al.  Numerical Study of Interactions Between Phase II of OC4 Wind Turbine and Its Semi-Submersible Floating Support System , 2015 .

[13]  Torgeir Moan,et al.  Comparison of wave load effects on a TLP wind turbine by using computational fluid dynamics and potential flow theory approaches , 2015 .

[14]  Qing Xiao,et al.  Investigation of the effects of platform motion on the aerodynamics of a floating offshore wind turbine , 2015 .

[15]  Dong-Hyun Kim,et al.  The coupled dynamic response computation for a semi-submersible platform of floating offshore wind turbine , 2015 .

[16]  S. Narasimalu,et al.  FLOATING OFFSHORE WIND TURBINE ROTOR OPERATING STATE-MODIFIED TIP LOSS FACTOR IN BEM AND COMPARION WITH CFD , 2015 .

[17]  Dong-Hyun Kim,et al.  A CFD study into the influence of unsteady aerodynamic interference on wind turbine surge motion , 2016 .

[18]  Sebastien Gueydon,et al.  Aerodynamic Damping on a Semisubmersible Floating Foundation for Wind Turbines , 2016 .

[19]  Dong-Hyun Kim,et al.  Fully coupled aero-hydrodynamic analysis of a semi-submersible FOWT using a dynamic fluid body interaction approach , 2016 .

[20]  Ekaitz Zulueta,et al.  Five Megawatt Wind Turbine Power Output Improvements by Passive Flow Control Devices , 2017 .

[21]  J. Jonkman,et al.  OC5 Project Phase II: Validation of Global Loads of the DeepCwind Floating Semisubmersible Wind Turbine , 2017 .

[22]  Qing Xiao,et al.  Establishing a fully coupled CFD analysis tool for floating offshore wind turbines , 2017 .

[23]  Trond Kvamsdal,et al.  Quasi-Static & Dynamic Numerical Modeling of Full Scale NREL 5MW Wind Turbine , 2017 .

[24]  Oscar Barambones,et al.  Computational Modelling of Rectangular Sub-Boundary Layer Vortex Generators , 2018 .

[25]  Decheng Wan,et al.  Comparisons of the dynamical characteristics of a semi-submersible floating offshore wind turbine based on two different blade concepts , 2018 .