Plasma-enhanced chemical vapour deposition of microcrystalline silicon: On the dynamics of the amorphous-microcrystalline interface by optical methods

Abstract Very-high-frequency plasma-enhanced chemical vapour deposition was used to produce p-type microcrystalline samples. Spectroscopic ellipsometry measurements and transmission electron microscopy observations on the deposited samples are compared and discussed. Continuous deposition is observed to result in a growth which is initially amorphous and then evolves to microcrystalline. At this stage, the grains are observed to propagate towards the interface with the substrate. In order to obtain very thin layers, a deposition + hydrogen etching + deposition sequence was also used. This technique produces an increase in the microcrystalline fraction by a factor of more than ten with respect to continuous deposition: a crystalline fraction as large as 48% at the film–substrate interface for a 20 nm film is detected. Electrical measurements are correlated with the sample structure. The dark conductivity confirms the microcrystalline nature of samples, but is also shown to depend on the distribution of the microcrystalline phase.

[1]  S. Wagner,et al.  Amorphous and microcrystalline silicon technology -- 1998 , 1999 .

[2]  Hiroyuki Fujiwara,et al.  Optimization of hydrogenated amorphous silicon p–i–n solar cells with two-step i layers guided by real-time spectroscopic ellipsometry , 1998 .

[3]  W. Fuhs,et al.  Hydrogen-mediated structural changes of amorphous and microcrystalline silicon , 1998 .

[4]  O. Vetterl,et al.  Growth of microcrystalline silicon using the layer-by-layer technique at various plasma excitation frequencies , 1998 .

[5]  A. Matsuda,et al.  Role of the hydrogen plasma treatment in layer-by-layer deposition of microcrystalline silicon , 1997 .

[6]  T. Umeda,et al.  GROWTH OF AMORPHOUS-LAYER-FREE MICROCRYSTALLINE SILICON ON INSULATING GLASS SUBSTRATES BY PLASMA-ENHANCED CHEMICAL VAPOR DEPOSITION , 1997 .

[7]  Reinhard Carius,et al.  Optical and transport studies on thin microcrystalline silicon films prepared by very high frequency glow discharge for solar cell applications , 1997 .

[8]  S. Hamma,et al.  In situ correlation between the optical and electrical properties of thin intrinsic and n-type microcrystalline silicon films , 1997 .

[9]  Jr. G.E. Jellison,et al.  Spectroscopic ellipsometry data analysis : measured versus calculated quantities , 1997 .

[10]  Solomon,et al.  Real-time spectroscopic ellipsometry study of the growth of amorphous and microcrystalline silicon thin films prepared by alternating silicon deposition and hydrogen plasma treatment. , 1995, Physical review. B, Condensed matter.

[11]  H. Nguyen,et al.  Preparation of ultrathin microcrystalline silicon layers by atomic hydrogen etching of amorphous silicon and end‐point detection by real time spectroellipsometry , 1994 .

[12]  R. Hollingsworth,et al.  Doped microcrystalline silicon growth by high frequency plasmas , 1994 .

[13]  M. Heintze,et al.  Surface controlled plasma deposition and etching of silicon near the chemical equilibrium , 1993 .

[14]  Matthew F. Chisholm,et al.  Optical functions of chemical vapor deposited thin‐film silicon determined by spectroscopic ellipsometry , 1993 .

[15]  A. Asano.  Effects of hydrogen atoms on the network structure of hydrogenated amorphous and microcrystalline silicon thin films , 1990 .

[16]  S. Logothetidis.  Surface‐roughness and grain‐boundary effects on the optical properties of low‐pressure chemical‐vapor‐deposited silicon thin films by spectroscopic ellipsometry , 1989 .

[17]  S. Logothetidis,et al.  Study of the optical transitions in poly- and micro-crystalline Si by spectroscopic ellipsometry , 1988 .

[18]  James K. Gimzewski,et al.  Properties of microcrystalline silicon. IV. Electrical conductivity, electron spin resonance and the effect of gas adsorption , 1983 .

[19]  S. Vepřek,et al.  Highlights of preparative solid state chemistry in low pressure plasmas , 1982 .

[20]  H. Fujiwara,et al.  Amorphous/Microcrystalline Phase Control in Silicon Film Deposition for Improved Solar Cell Performance , 1998 .

[21]  A. Matsuda,et al.  Role of Hydrogen for Microcrystalline Silicon Formation , 1998 .

[22]  E. Centurioni,et al.  Effect of Hydrogen Plasma Treatments at very High Frequency on p-Type Amorphous and Microcrystalline Silicon Films , 1998 .

[23]  K. Lips,et al.  Preparation and Characterization of Microcrystalline and Epitactially Grown Emitter Layers for Silicon Solar Cells , 1998 .

[24]  G. Habermehl,et al.  ReviewPure appl. Chem: Rinehart, K. L., et al. Marine natural products as sources of antiviral, antimicrobial, and antineoplastic Agents. 53, 795 (1981). (K. L. Rinehart, University of Illinois, Urbana, IL 61801, U.S.A.) , 1983 .

[25]  John Ziman,et al.  Models of disorder , 1979 .

[26]  D. A. G. Bruggeman.  Berechnung verschiedener physikalischer Konstanten von heterogenen Substanzen. I. Dielektrizitätskonstanten und Leitfähigkeiten der Mischkörper aus isotropen Substanzen , 1935 .