Gas–liquid distribution in tubular reactors with solid foam packings

Abstract The axial evolution of gas–liquid distribution patterns in co-current downward gas–liquid two-phase flow through solid foam packings of different pore density expressed by pores per inch was experimentally studied. The experimental results are based on time-averaged capacitance measurements of the liquid phase with embedded wire-mesh sensors, positioned at different axial heights of the solid foam packing. The measurements revealed the spatial distribution of the liquid phase saturation, which was applied to quantify the degree of liquid maldistribution. Both the spray nozzle and the multipoint distributor provide rather uniform initial liquid distributions across the foam packings with low maldistribution factors at superficial liquid velocities above 0.009 m/s. However, the uniform initial irrigation deteriorates along the foam packing length, in particular for foams with low pore density. The gas flow rate does not significantly influence the liquid distribution. Furthermore, the foam’s ability to radially spread the liquid phase in the cross-section downstream from a single drip point distributor was studied and found to be low, independent from the pore density.

[1]  Z. Mao,et al.  Scale and variance of radial liquid maldistribution in trickle beds , 1998 .

[2]  Milorad P. Dudukovic,et al.  Study of liquid spreading from a point source in a trickle bed via gamma-ray tomography and CFD simulation , 2005 .

[3]  M. Schubert,et al.  Liquid–solid mass transfer in a tubular reactor with solid foam packings , 2014 .

[4]  S. Kuhn,et al.  Scalar transport in a milli-scale metal foam reactor , 2010 .

[5]  Angélique Léonard,et al.  Phase distribution measurements in metallic foam packing using X-ray radiography and micro-tomography , 2009 .

[6]  H. Freund,et al.  Determining the specific surface area of ceramic foams: The tetrakaidecahedra model revisited , 2011 .

[7]  Dieter Mewes,et al.  Investigation of the two-phase flow in trickle-bed reactors using capacitance tomography , 1997 .

[8]  F. J. Zuiderweg,et al.  Small scale and large scale liquid maldistribution in packed columns , 1986 .

[9]  H. Kryk,et al.  Spatially resolved inline measurement of liquid velocity in trickle bed reactors , 2010 .

[10]  Charlotte Pham,et al.  Experimental measurements and multiphase flow models in solid SiC foam beds , 2008 .

[11]  Ville Alopaeus,et al.  CFD modeling of radial spreading of flow in trickle-bed reactors due to mechanical and capillary dispersion , 2009 .

[12]  S. Sundaresan,et al.  Cocurrent downflow of air and water in a two‐dimensional packed column , 1986 .

[13]  Markus Schubert,et al.  Hydrodynamic multiplicity in a tubular reactor with solid foam packings , 2013 .

[14]  van der J John Schaaf,et al.  Hydrodynamics of gas¿liquid counter-current flow in solid foam packings , 2005 .

[15]  K. Nigam,et al.  The liquid spreading on porous solids: Dual action of pores , 2005 .

[16]  U. Hampel,et al.  Capacitance wire-mesh sensor for fast measurement of phase fraction distributions , 2007 .

[17]  K. Ng,et al.  Liquid distribution in trickle-beds. An experimental study using computer-assisted tomography , 1991 .

[18]  Matthias Kind,et al.  Hydrodynamics of Ceramic Sponges in Countercurrent Flow , 2011 .

[19]  Hiroshi Takeuchi,et al.  Liquid distribution in a packed column , 1973 .

[20]  Uwe Hampel,et al.  Slow-mode gas/liquid-induced periodic hydrodynamics in trickling packed beds derived from direct measurement of cross-sectional distributed local capacitances , 2010 .

[21]  N. Sylvester,et al.  Radial liquid distribution in cocurrent two-phase downflow in packed beds , 1975 .

[22]  Faïçal Larachi,et al.  Monitoring Filtration in Trickle Beds Using Electrical Capacitance Tomography , 2009 .

[23]  R. Carbonell,et al.  The hydrodynamics of trickling flow in packed beds. Part II: Experimental observations , 1986 .

[24]  K. Kan,et al.  Multiple Hydrodynamic States in Cocurrent Two-Phase Downflow through Packed Beds , 1978 .

[25]  Gabriel Wild,et al.  Liquid Distribution in Trickle-Bed Reactor , 2000 .

[26]  K. Nigam,et al.  TRICKLE-BED REACTORS: LIQUID DISTRIBUTION AND FLOW TEXTURE , 2004 .

[27]  P. V. Ravindra,et al.  Liquid Flow Texture in Trickle-Bed Reactors: An Experimental Study , 1997 .

[28]  Uwe Hampel,et al.  Liquid flow texture analysis in trickle bed reactors using high-resolution gamma ray tomography , 2008 .

[29]  H. Prasser,et al.  A new electrode-mesh tomograph for gas–liquid flows , 1998 .

[30]  W. Nicol,et al.  Multiple hydrodynamic states in trickle flow: Quantifying the extent of pressure drop, liquid holdup and gas–liquid mass transfer variation , 2006 .