Stall Detection Using Pseudo-Acoustic Pressure Modulation in Industrial Fans

This work investigates the use of unconventional sensors to measure pressure modulation interpreted as pseudo sound in the near field on the casing of a fan in a view to detect rotating stall. Rotating stall is an aerodynamic issue with a frequency signature usually half the rotor frequency. In low speed turbomachines, such as industrial fans, this turns in very low frequencies, even lower than 10 Hz.Traditional methods use piezoelectric sensors, e.g., pressure transducers or microphones, respectively in the near and far-field, to detect instability from the signal patterns with broad frequency ranges. Recently electret microphones have been proposed, but with a cut-off frequency of 20 Hz as such not suitable for signal in near infrasound region.The sensor used in this work, have a narrower frequency range than more advanced technologies. The authors developed and set-up a measurement system able to acquire low frequency pressure signals using dynamic microphones.In this paper the authors developed a measurement chain based on dynamic microphone and pressure transducer in order to create a stall warning system. They tested the system on a low speed axial fan and they validated the work against state of the art acoustic control techniques. For this reason those devices represent candidate solutions for the detection of the patterns typical of rotating stall in turbomachines.

[1]  Zeng,et al.  Estimating the Lyapunov-exponent spectrum from short time series of low precision. , 1991, Physical review letters.

[2]  I. Day.  Active Suppression of Rotating Stall and Surge in Axial Compressors , 1991 .

[3]  R. Mañé,et al.  On the dimension of the compact invariant sets of certain non-linear maps , 1981 .

[4]  N. A. Cumpsty,et al.  A critical review of turbomachinery noise , 1977 .

[5]  Eisuke Outa,et al.  Early Stall Warning Technique for Axial-Flow Compressors , 2007 .

[6]  R. Gallager.  Information Theory and Reliable Communication , 1968 .

[7]  Yasuji Sawada,et al.  Practical Methods of Measuring the Generalized Dimension and the Largest Lyapunov Exponent in High Dimensional Chaotic Systems , 1987 .

[8]  James P. Crutchfield,et al.  Geometry from a Time Series , 1980 .

[9]  H. Abarbanel,et al.  Distribution of mutual information , 2000, nlin/0011016.

[10]  Jon Wright.  Method for calculating a Lyapunov exponent , 1984 .

[11]  Eisuke Outa,et al.  Active Stall Control With Practicable Stall Prediction System Using Auto-Correlation Coefficient , 2001 .

[12]  Edward M. Greitzer,et al.  Surge and Rotating Stall in Axial Flow Compressors—Part I: Theoretical Compression System Model , 1976 .

[13]  Alessandro Corsini,et al.  Detection of Stall Regions in a Low-Speed Axial Fan: Part I—Azimuthal Acoustic Measurements , 2010 .

[14]  M. Rosenstein,et al.  A practical method for calculating largest Lyapunov exponents from small data sets , 1993 .

[15]  Thomas Carolus,et al.  Experimental and Unsteady Numerical Investigation of the Tip Clearance Noise of an Axial Fan , 2013 .

[16]  L. Tsimring,et al.  The analysis of observed chaotic data in physical systems , 1993 .

[17]  Alessandro Corsini,et al.  Stall Warning in a Low-Speed Axial Fan by Visualization of Sound Signals , 2011 .

[18]  R Hegger,et al.  Improved false nearest neighbor method to detect determinism in time series data. , 1999, Physical review. E, Statistical physics, plasmas, fluids, and related interdisciplinary topics.

[19]  A. Wolf,et al.  Determining Lyapunov exponents from a time series , 1985 .

[20]  N. A. Cumpsty.  Sum and difference tones from turbomachines , 1974 .

[21]  Aspi Rustom Wadia,et al.  Development and Demonstration of a Stability Management System for Gas Turbine Engines , 2006 .

[22]  H. Abarbanel,et al.  LYAPUNOV EXPONENTS IN CHAOTIC SYSTEMS: THEIR IMPORTANCE AND THEIR EVALUATION USING OBSERVED DATA , 1991 .

[23]  H. Abarbanel,et al.  Determining embedding dimension for phase-space reconstruction using a geometrical construction. , 1992, Physical review. A, Atomic, molecular, and optical physics.

[24]  Steven A. Orszag,et al.  Stability and Lyapunov stability of dynamical systems: A differential approach and a numerical method , 1987 .

[25]  Y. Pesin.  CHARACTERISTIC LYAPUNOV EXPONENTS AND SMOOTH ERGODIC THEORY , 1977 .

[26]  L. Valavani,et al.  Active control of rotating stall in a low-speed axial compressor , 1993 .

[27]  Manuj Dhingra,et al.  A Stochastic Model for a Compressor Stability Measure , 2006 .

[28]  Alessandro Corsini,et al.  A Critical Review of Stall Control Techniques in Industrial Fans , 2013 .

[29]  Alessandro Corsini,et al.  Stall Inception, Evolution and Control in a Low Speed Axial Fan With Variable Pitch in Motion , 2012 .

[30]  F. Takens.  Detecting strange attractors in turbulence , 1981 .

[31]  Ulrich Parlitz,et al.  Comparison of Different Methods for Computing Lyapunov Exponents , 1990 .

[32]  Alessandro Corsini,et al.  Demonstration of a stall detection system for induced draft fans , 2013 .