Emission characteristics of diesel, gas to liquid, and biodiesel-blended fuels in a diesel engine for passenger cars

Abstract The need for diversification of energy sources and reducing various emissions including CO 2 emission in diesel engine can be met with alternative diesel fuels such as gas to liquid (GTL) and GTL–biodiesel blends. But there should be a clear understanding of the combustion and engine-out emission characteristics for alternative fuels. In this respect, an experimental study was conducted on a 2.0 L 4 cylinders turbocharged diesel engine fuelled with those alternative diesel fuels to investigate the engine-out emission characteristics under various steady-state engine operating conditions. The results revealed that noticeable decreases in THC (22–56%) and CO (16–52%) emissions for GTL–biodiesel blends were observed, whereas NO x emissions for GTL–biodiesel blends increased by a maximum of 12% compared to diesel. With regard to particle size distributions (PSDs) for GTL–biodiesel blends, the particulate matter (PM) number concentration in accumulation mode decreased, as a result of the excess oxygen content in biodiesel. Contrary to the tendency in the accumulation mode, there was a slight increase in the PM number concentration in the nucleation mode under the operating conditions wherein the exhaust gas recirculation (EGR) strategy was applied. The total PM number concentration for G + BD40 decreased by a maximum of 46% compared to that for diesel. From these results of enhanced emission characteristics compared to diesel and GTL fuel, the potential for the use of GTL–biodiesel blends could be confirmed.

[1]  Zhen Huang,et al.  Effects of Dimethoxy Methane Blended with Gas-to-Liquids on Particulate Matter Emissions from a Compression-Ignition Engine , 2008 .

[2]  Ouyang Minggao,et al.  Experimental Research on EGR in a Diesel Engine Equipped with Common Rail Injection System , 2003 .

[3]  Zuohua Huang,et al.  Experimental investigation on regulated and unregulated emissions of a diesel engine fueled with ultra-low sulfur diesel fuel blended with biodiesel from waste cooking oil. , 2009, The Science of the total environment.

[4]  André L. Boehman,et al.  NOx emissions of alternative diesel fuels: A comparative analysis of biodiesel and FT diesel , 2005 .

[5]  Walter Friess,et al.  HSDI Diesel Engine Optimisation for GTL Diesel Fuel , 2007 .

[6]  Md. Nurun Nabi,et al.  Improvement of engine emissions with conventional diesel fuel and diesel-biodiesel blends. , 2006, Bioresource technology.

[7]  Hiroshi Yoshida,et al.  Diesel Engine Emissions and Performance Optimization for Neat GTL Fuel , 2008 .

[8]  Koji Kitano,et al.  GTL Fuel Impact on DI Diesel Emissions , 2007 .

[9]  L. G. Schumacher,et al.  Impact of cold flow improvers on soybean biodiesel blend , 2004 .

[10]  Avinash Kumar Agarwal,et al.  Biofuels (alcohols and biodiesel) applications as fuels for internal combustion engines , 2007 .

[11]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[12]  Avinash Kumar Agarwal,et al.  Biodiesel Development and Characterization for Use as a Fuel in Compression Ignition Engines , 2001 .

[13]  Octavio Armas,et al.  Effect of biodiesel fuels on diesel engine emissions , 2008 .

[14]  L. Das,et al.  Combustion analysis of Jatropha, Karanja and Polanga based biodiesel as fuel in a diesel engine , 2009 .

[15]  Zhen Huang,et al.  Particle size distribution from a GTL engine. , 2007, The Science of the total environment.

[16]  M. Canakci,et al.  Combustion characteristics of a turbocharged DI compression ignition engine fueled with petroleum diesel fuels and biodiesel. , 2007, Bioresource technology.

[17]  Magín Lapuerta,et al.  Diesel particulate emissions from used cooking oil biodiesel. , 2008, Bioresource technology.

[18]  José Rodríguez-Fernández,et al.  Diesel Engine Performance and Emissions when First Generation Meets Next Generation Biodiesel , 2009 .

[19]  Walter Knecht,et al.  Diesel engine development in view of reduced emission standards , 2008 .

[20]  Teresa M. Mata,et al.  Microalgae for biodiesel production and other applications: A review , 2010 .

[21]  José M. Desantes,et al.  Methodology for measuring exhaust aerosol size distributions from heavy duty diesel engines by means of a scanning mobility particle sizer , 2004 .

[22]  Octavio Armas,et al.  Potential for reducing emissions in a diesel engine by fuelling with conventional biodiesel and Fischer–Tropsch diesel , 2010 .

[23]  Ingemar Denbratt,et al.  Combustion of Fischer-Tropsch, RME and Conventional Fuels in a Heavy-Duty Diesel Engine , 2007 .

[24]  Richard Hugh Clark,et al.  Engine performance and emissions from the combustion of low-temperature Fischer-Tropsch synthetic diesel fuel and biodiesel rapeseed methyl ester blends , 2009 .

[25]  Siddharth Jain,et al.  Prospects of biodiesel from Jatropha in India: A review , 2010 .

[26]  R. Dunn.  Effects of minor constituents on cold flow properties and performance of biodiesel , 2009 .