High power GaN-based LEDs with nano-structured Ga-doped ZnO (GZO) transparent conductive layer (TCL)

High power GaN-based LEDs with nano-structured Ga-doped ZnO (GZO) transparent conductive layer (TCL) were fabricated by using metal-organic chemical vapor deposition (MOCVD) method. Compared with the conventional LED with Ni/Au or ITO process, the saturation current in the LEDs with GZO TCL approximately increased up to more than 14 % and 13 %, and the light output intensity up to 57.5 % and 30.1 %, respectively. This improvement was attributed to the high carrier concentration of GZO TCL and the planar structure at the TCL bottom, which improved the electrical conductivity, and therefore promoted current spreading. The refractive index of GZO is similar to GaN (n ≈ 2) and thereby results in the reduction of the reflection loss between GaN and TCL interface. In addition, the nano-structure of GZO TCL increased the light output critical angle and enhanced surface light emitting while reducing the lateral light loss and consequently improved light extraction efficiency of LEDs.

[1]  Yong-Seok Choi,et al.  Enhanced optical power and low forward voltage of GaN-based light-emitting diodes with Ga-doped ZnO transparent conducting layer , 2010 .

[2]  Ashutosh Tiwari,et al.  Metallic conductivity and metal-semiconductor transition in Ga-doped ZnO , 2006 .

[3]  D. Bour,et al.  Nitride-based semiconductors for blue and green light-emitting devices , 1997, Nature.

[4]  David C. Look,et al.  Ga-Doped ZnO Films Grown on GaN Templates by Plasma-Assisted Molecular-Beam Epitaxy , 2000 .

[5]  V. Avrutin,et al.  InGaN light-emitting diodes with highly transparent ZnO:Ga electrodes , 2010, OPTO.

[6]  Seong-Ju Park,et al.  Selective wet etching of p-GaN for efficient GaN-based light-emitting diodes , 2006, IEEE Photonics Technology Letters.

[7]  Hyunsang Hwang,et al.  Effect of an oxidized Ni/Au p contact on the performance of GaN/InGaN multiple quantum well light-emitting diodes , 2001 .

[8]  Shuji Nakamura,et al.  High‐power InGaN single‐quantum‐well‐structure blue and violet light‐emitting diodes , 1995 .

[9]  S. Denbaars,et al.  Increase in the extraction efficiency of GaN-based light-emitting diodes via surface roughening , 2004 .

[10]  Jinn-Kong Sheu,et al.  Low Operation Voltage of Nitride-Based LEDs with Al-Doped ZnO Transparent Contact Layer , 2008 .

[11]  Tsunemasa Taguchi,et al.  High Output Power InGaN Ultraviolet Light-Emitting Diodes Fabricated on Patterned Substrates Using Metalorganic Vapor Phase Epitaxy , 2001 .

[12]  Takashi Jimbo,et al.  Improved characteristics of InGaN multiple-quantum-well light-emitting diode by GaN/AlGaN distributed Bragg reflector grown on sapphire , 2000 .

[13]  Weon-Pil Tai,et al.  Electrical and optical properties of Al-doped ZnO thin films by sol–gel process , 2007 .

[14]  Yicheng Lu,et al.  Integrated ZnO nanotips on GaN light emitting diodes for enhanced emission efficiency , 2007 .

[15]  Renaud A. L. Vallée,et al.  In situ tuning the optical properties of a cavity by wrinkling , 2010 .

[16]  Joel R. Wendt,et al.  InGaN/GaN quantum-well heterostructure light-emitting diodes employing photonic crystal structures , 2004 .

[17]  Jinn-Kong Sheu,et al.  Ga-Doped ZnO Transparent Conductive Oxide Films Applied to GaN-Based Light-Emitting Diodes for Improving Light Extraction Efficiency , 2008, IEEE Journal of Quantum Electronics.

[18]  Gyu-Chul Yi,et al.  Enhanced light output of GaN-based light-emitting diodes with ZnO nanorod arrays , 2008 .

[19]  K. H. Kim,et al.  III-nitride blue and ultraviolet photonic crystal light emitting diodes , 2004 .