Variation of Impedance in Lead-Acid Batteries in the Presence of Acid Stratification

Acid stratification is a common issue in lead-acid batteries. The density of the electrolyte rises from the top to the bottom and causes inhomogeneous current distribution over the electrodes. The consequences are unequal aging processes provoking earlier battery failure. In stationary applications electrolyte circulation pumps are sporadical installed in the battery to mix the acid. For automotive applications passive mixing systems are implemented by some battery manufacturers against stratification. Stratification does not show any distinct voltage-current profile to be recognizable online. However, it increases the voltage and affects the impedance, which both are essential information for diagnostic purpose. Impedance spectra were performed here on lead-acid test cells with adjusted stratification levels to analyze the influence on the impedance in details. It is observed, that the high-frequency impedance is decreased in the stratified cell and that in contrast to this the charge-transfer resistance is increased. Based on simulations with a spatially-resolved equivalent electrical circuit the increased charge-transfer resistance could be explained with an inhomogeneous State-of-Charge resulting in an accumulation of sulfate crystals in the bottom part of the electrodes. These sulfate crystals further affected recorded impedance spectra after the electrolyte was homogenized.

[2]  D Desmettre,et al.  Characterisation of photovoltaic batteries using radio element detection: the influence and consequences of the electrolyte stratification , 2003 .

[3]  Daikichi Mukoyama,et al.  Review-Development of Diagnostic Process for Commercially Available Batteries, Especially Lithium Ion Battery, by Electrochemical Impedance Spectroscopy , 2015 .

[4]  Van-Long Tran,et al.  Development of the intelligent charger with battery State-Of-Health estimation using online impedance spectroscopy , 2014, 2014 IEEE 23rd International Symposium on Industrial Electronics (ISIE).

[5]  D. Burow,et al.  Carbon blacks for the extension of the cycle life in flooded lead acid batteries for micro-hybrid applications , 2013 .

[6]  W. Kappus,et al.  Homogeneous nucleation, growth and recrystallization of discharge products on electrodes , 1983 .

[7]  Yonglang Guo,et al.  Effects of Electrolyte Stratification on Performances of Flood Lead-Acid Batteries , 2007 .

[8]  P. Ruetschi.  Aging mechanisms and service life of lead–acid batteries , 2004 .

[9]  D. Sauer,et al.  Correct processing of impedance spectra for lead-acid batteries to parameterize the charge-transfer process , 2018, Journal of Applied Electrochemistry.

[10]  Dirk Uwe Sauer,et al.  Optimierung des Einsatzes von Blei-Säure-Akkumulatoren in Photovoltaik-Hybrid-Systemen unter spezieller Berücksichtigung der Batteriealterung , 2009 .

[11]  E. Karden,et al.  A method for measurement and interpretation of impedance spectra for industrial batteries , 2000 .

[12]  Dirk Uwe Sauer,et al.  Impedanzspektroskopie an Batterien unter besonderer Berücksichtigung von Batteriesensoren für den Feldeinsatz , 2013 .

[13]  Eberhard Meissner,et al.  Lead-acid batteries in micro-hybrid vehicles , 2011 .

[14]  Eckhard Karden,et al.  Simulation of the current distribution in lead-acid batteries to investigate the dynamic charge acceptance in flooded SLI batteries , 2009 .

[15]  Norbert Wagner,et al.  Validation and evaluation of electrochemical impedance spectra of systems with states that change with time , 2001 .

[16]  P. Everill,et al.  Discrete carbon nanotubes increase lead acid battery charge acceptance and performance , 2014 .

[17]  D. Berndt.  Maintenance-Free Batteries , 1993 .

[18]  Jaber A. Abu-Qahouq,et al.  An Online Battery Impedance Measurement Method Using DC–DC Power Converter Control , 2014, IEEE Transactions on Industrial Electronics.

[19]  Julia Badeda,et al.  Determination of SoH of lead-acid batteries by electrochemical impedance spectroscopy , 2018 .

[20]  F. Huet,et al.  Investigation of the high-frequency resistance of a lead-acid battery , 2006 .

[21]  D. Sauer,et al.  Influence of measurement procedure on quality of impedance spectra on leadacid batteries , 2011 .

[22]  Dirk Uwe Sauer,et al.  Optimum battery design for applications in photovoltaic systems — theoretical considerations , 2001 .