Efficiently engineering pore-scale processes: The role of force dominance and topology during nonwetting phase trapping in porous media

Abstract We investigate trapping of a nonwetting (NW) phase, air, within Bentheimer sandstone cores during drainage–imbibition flow experiments, as quantified on a three dimensional (3D) pore-scale basis via x-ray computed microtomography (X-ray CMT). The wetting (W) fluid in these experiments was deionized water doped with potassium iodide (1:6 by weight). We interpret these experiments based on the capillary–viscosity–gravity force dominance exhibited by the Bentheimer–air–brine system and compare to a wide range of previous drainage–imbibition experiments in different media and with different fluids. From this analysis, we conclude that viscous and capillary forces dominate in the Bentheimer–air–brine system as well as in the Bentheimer–supercritical CO 2 –brine system. In addition, we further develop the relationship between initial (post-drainage) NW phase connectivity and residual (post-imbibition) trapped NW phase saturation, while also taking into account initial NW phase saturation and imbibition capillary number. We quantify NW phase connectivity via a topological measure as well as by a statistical percolation metric. These metrics are evaluated for their utility and appropriateness in quantifying NW phase connectivity within porous media. Here, we find that there is a linear relationship between initial NW phase connectivity (as quantified by the normalized Euler number, χ ˆ ) and capillary trapping efficiency; for a given imbibition capillary number, capillary trapping efficiency (residual NW phase saturation normalized by initial NW phase saturation) can decrease by up to 60% as initial NW phase connectivity increases from low connectivity ( χ ˆ  ≈ 0) to very high connectivity ( χ ˆ  ≈ 1). We propose that multiphase fluid-porous medium systems can be efficiently engineered to achieve a desired residual state (optimal NW phase saturation) by considering the dominant forces at play in the system along with the impacts of NW phase topology within the porous media, and we illustrate these concepts by considering supercritical CO 2 sequestration scenarios.

[1]  Philippe Renard,et al.  Connectivity metrics for subsurface flow and transport , 2013 .

[2]  S. Bachu.  Screening and ranking of sedimentary basins for sequestration of CO2 in geological media in response to climate change , 2003 .

[3]  D. Wildenschilda,et al.  Pore-scal e observati ons of supercr itical CO2 drainage in Bentheimer sandsto ne by syn chrotron x-ray imaging , 2014 .

[4]  M. Blunt,et al.  Pore Scale Modeling of Rate Effects in Imbibition , 2000 .

[5]  A. Palmer,et al.  SUMMARY OF THE IPCC SPECIAL REPORT ON CARBON DIOXIDE CAPTURE AND STORAGE , 2006 .

[6]  Randy D. Hazlett,et al.  Simulation of capillary-dominated displacements in microtomographic images of reservoir rocks , 1995 .

[7]  Markus Hilpert,et al.  Pore-morphology-based simulation of drainage in totally wetting porous media , 2001 .

[8]  Ioannis Chatzis,et al.  Entrapment and Mobilization of Residual Oil in Bead Packs , 1988 .

[9]  M. Blunt,et al.  Nonwetting phase residual saturation in sand packs , 2010 .

[10]  S. Bachu,et al.  Interfacial Tension between CO2, Freshwater, and Brine in the Range of Pressure from (2 to 27) MPa, Temperature from (20 to 125) °C, and Water Salinity from (0 to 334 000) mg·L−1 , 2009 .

[11]  Martin J. Blunt,et al.  Measurements of Non-Wetting Phase Trapping Applied to Carbon Dioxide Storage , 2009 .

[12]  R. Armstrong,et al.  Critical capillary number: Desaturation studied with fast X‐ray computed microtomography , 2014 .

[13]  Cass T. Miller,et al.  The influence of porous medium characteristics and measurement scale on pore-scale distributions of residual nonaqueous-phase liquids , 1992 .

[14]  M. Honarpour,et al.  The effects of rock characteristics on relative permeability , 1990 .

[15]  Dorthe Wildenschild,et al.  Pore-scale observations of supercritical CO2 drainage in Bentheimer sandstone by synchrotron x-ray imaging , 2014 .

[16]  W. Brent Lindquist,et al.  Image Thresholding by Indicator Kriging , 1999, IEEE Trans. Pattern Anal. Mach. Intell..

[17]  N. Morrow,et al.  Effect of Capillary Number on the Microstructure of Residual Oil in Strongly Water-Wet Sandstones , 1988 .

[18]  Dorthe Wildenschild,et al.  Effect of fluid topology on residual nonwetting phase trapping: Implications for geologic CO 2 sequestration , 2013 .

[19]  Norman R. Morrow,et al.  Physics and Thermodynamics of Capillary Action in Porous Media , 1970 .

[20]  Cass T. Miller,et al.  An experimental investigation of pore-scale distributions of nonaqueous phase liquids at residual saturation , 1993 .

[21]  D. Wildenschild,et al.  Quantitative Analysis of Flow Processes in a Sand Using Synchrotron‐Based X‐ray Microtomography , 2005, Vadose Zone Journal.

[22]  Karsten Pruess,et al.  Formation dry‐out from CO2 injection into saline aquifers: 1. Effects of solids precipitation and their mitigation , 2009 .

[23]  R. Kharrat,et al.  The investigation of suitability of different capillary number definitions for flow behavior characterization of surfactant-based chemical flooding in heavy oil reservoirs , 2012 .

[24]  B. Metz.  IPCC special report on carbon dioxide capture and storage , 2005 .

[25]  Ruben Juanes,et al.  Impact of relative permeability hysteresis on geological CO2 storage , 2006 .

[26]  Fluid topology, pore size and aspect ratio during imbibition , 1988 .

[27]  Ivan Lunati,et al.  Experimental characterization of nonwetting phase trapping and implications for geologic CO2 sequestration , 2015 .

[28]  Martin J. Blunt,et al.  Pore‐by‐pore capillary pressure measurements using X‐ray microtomography at reservoir conditions: Curvature, snap‐off, and remobilization of residual CO2 , 2014 .

[29]  Yildiray Cinar,et al.  An experimental investigation of the balance between capillary, viscous, and gravitational forces during CO2 injection into saline aquifers , 2011 .

[30]  H. Gundersen,et al.  Quantification of connectivity in cancellous bone, with special emphasis on 3-D reconstructions. , 1993, Bone.

[31]  Klaus Mecke,et al.  Euler characteristic and related measures for random geometric sets , 1991 .

[32]  S. Berg,et al.  THE VISCOUS-CAPILLARY PARADOX IN 2-PHASE FLOW IN POROUS MEDIA , 2009 .

[33]  Carlon S. Land,et al.  Calculation of Imbibition Relative Permeability for Two- and Three-Phase Flow From Rock Properties , 1968 .

[34]  Ruben Juanes,et al.  Relative-Permeability Hysteresis: Trapping Models and Application to Geological CO2 Sequestration , 2005 .

[35]  木股 雅章,et al.  SPIE's International Symposium on Optical Science, Engineering, and Instrumentation報告 , 1998 .

[36]  N. Morrow,et al.  Correlation of capillary number relationships for sandstone , 1984 .

[37]  H. Vogel,et al.  Quantification of Gas‐Phase Trapping within the Capillary Fringe Using Computed Microtomography , 2015 .

[38]  Morteza Akbarabadi,et al.  Relative permeability hysteresis and capillary trapping characteristics of supercritical CO2/brine systems: An experimental study at reservoir conditions , 2013 .

[39]  Martin J. Blunt,et al.  Pore‐scale imaging of geological carbon dioxide storage under in situ conditions , 2013 .

[40]  Sally M. Benson,et al.  The role of hydrogeological and geochemical trapping in sedimentary basins for secure geological storage of carbon dioxide , 2004, Geological Society, London, Special Publications.

[41]  A. Kantzas,et al.  Capillary Number Correlations for Gas-Liquid Systems , 2004 .

[42]  Mark A. Knackstedt,et al.  The effect of displacement rate on imbibition relative permeability and residual saturation , 2006 .

[43]  L. Scriven,et al.  Dependence of residual nonwetting liquid on pore topology , 1982 .

[44]  Hans-Jörg Vogel,et al.  Topological Characterization of Porous Media , 2002 .

[45]  Peter J. Eng,et al.  Geoscience applications of x-ray computed microtomography , 1999, Optics & Photonics.

[46]  Helmut Geistlinger,et al.  Quantification of capillary trapping of gas clusters using X‐ray microtomography , 2014 .

[47]  D. Wildenschilda,et al.  Using X-ray computed tomography in hydrology : systems , resolutions , and limitations , 2002 .

[48]  Stefan Bachu,et al.  Effects of in-situ conditions on relative permeability characteristics of CO2-brine systems , 2008 .

[49]  Tetsuya Suekane,et al.  Direct Observation of Trapped Gas Bubbles by Capillarity in Sandy Porous Media , 2010 .

[50]  Stefan Bachu,et al.  Dependence of CO2-brine interfacial tension on aquifer pressure, temperature and water salinity , 2007 .